2011 Prevost X3-45 technical service bulletins
107 technical service bulletins and manufacturer communications cover the 2011 Prevost X3-45.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The gasket thickness was increased from 1.5 mm to 3 mm to prevent interference between the collar ends,...
- Sway bar collars improvement
- Sway bar collars improvement
- Kit power steering tank convertion cummins to zf with D13 engine
- Improved bearings are now available to replace the original bearings used on some Prevost vehicles idler...
- Electric fan drive cooling system conversion with bosch alternator
- Electric fan drive cooling system conversion with delco remy alternator
- Steering gateway.
- Air Tanks Draining Sequence
- Air Tanks Draining Sequence
- Air Tanks Draining Sequence
- Halogen to LED fog light replacement kit
- Tag axle hub flange - alternate cap screw
- STEERING GATEWAY, revision A : Cancel watch dog removal from EFD part of the instruction
- STORAGE AND STARTUP GUIDELINES : part number updates
- Steering gateway
- X3 series envirocare - ions air sanitizer
- Central HVAC merv filters installation
- Bosch HD10 alternator diagnostic guide
- Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair – From US10 to newer...
- Ront & tag axle – unitized hub bearing end play verification and replacement
- Electric fan drive cooling system conversion with delco remy alternator - X3 series US10 up to GHG17...
- Eberspacher preheater installation
- Electric fan drive cooling system conversion with bosch alternator
- Sound Selector replacement, VSS04 to VSS05; When replacing a vehicle sound selector model VSS04 with a new...
- Electric fan drive cooling system conversion with delco remy alternator
- Electric fan drive cooling system conversion with bosch alternator - X3 series US10 up to GHG17 cooling system
- Central HVAC merv filters installation reva
- Storage and startup guidelines
- Tie rod 610052 first installation instructions
- Introducing a new engine coolant into prevost service center network
- Volvo i-shift transmission replacement - difference between connections at the top of the oil filter housing
- Rev A: Mention added concerning DDC Series 60 engine SCA requirement
- Introducing a new engine coolant into service
- Engine oil & filter change intervals - volvo D13 engine, from US10
- Fan clutch plate bolts re-torquing
- Storage and startup guidelines
- Jerky, noisy or hard to turn steering gearbox
- Electric fan drive cooling system conversion with delco remy alternator revision : b
- Electric fan drive cooling system conversion with bosch alternator
- Storage and startup guidelines
- Plexiglass Panel Behind Driver X3
- Prevost vehicle disinfection procedure
- Hand sanitizer dispenser installation
- Prevost vehicle disinfection procedure
- Storage and startup guidelines - all prevost vehicles & volvo 9700
- Repair instructions to address fault codes P029800
- Repair instructions to address fault codes P052400 Engine Oil Pressure Too Low
- Repair instructions to address fault codes P256000 Engine Coolant Level Low
- Added: Power cables for L.H. side alternator & fan drive breaker box
- Repair instructions to address fault codes P207F-00
- Repair instructions to address fault codes P207F-00; P20EE-00
- Repair instructions to address fault codes P021700 Engine Coolant Over Temperature Condition
- Revision : Mention added stating to disable Prime & parts added in the kit.
- This instruction sheet explains how to install the Electric Cooling System Conversion kit (with Delco Remy...
- MP-1000 multimedia player installation
- Vehicles identified below are compatible with a new tie rod design
- This instruction sheet shows how to install a flap over the diesel filling cap.
- Power steering pump discharge hose (pressure) replacement
- This instruction sheet explains how to install Delco Remy Alternators
- This instruction sheet explains how to perform the replacement of the power steering pump discharge hose...
- This Instruction Sheet explains how to add Sunshade Switches on the Dashboard
- After the installation of the latest Multiplex system update on US10 X3-Series coaches, the instrument...
- New aramid cord poly-v belts are now available to replace the polyester cord alternator belts previously...
- Explains that improved bearings are now available to replace the original bearings used on some Prevost...
- This maintenance information describes the steps to be followed on your computer to add the volvo engine...
- When replacing a vehicle sound selector model VSS04 with a new sound selector model VSS05, an interface...
- Bendix M-32QR ABS modulator valve replaced by new M-40QR valve.
- This Maintenance Information explains how to run a n Air Conditionning performance test
- On the vehicles affected by
- This Maintrenance infomration explains that the Castrol Syntrans oil isn?t fully approved for 500 000...
- This Instruction Sheet prvides a Road Side and Workshop Instructions for Replacing 040949 6mm DEF Hose to...
- On the vehicles affected by
- Prevost: some buses will need replacements of certain components-pcj oil pressure sensor, ats doser module...
- Summary to be provided on a future date.
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- To correct the J-1939 CAN2 and Nox sensor faults that have been intermittently logging, a dedicated CAN...
- Prevost: rear junction box connections need inspected with clean terminals and TERMIN8R lubricant or black...
- Prevost: on some buses, by VIN, will have installed the J-1939 CAN2 engine subnet cable overlay, due to...
- Prevost: on some buses, the junction rear component box cover would be replaced to prevent premature corrosion
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- Prevost: bosch hd 10 alternator connections, on some buses, need to be inspected and may need other parts...
- On the vehicles affected by
- Prevost: information provided on replacing valeo wiper motor with bosch wiper motor
- Prevost: the combined charging and starting system F81 fuse, on some coaches, CAN unexpectedly blow and...
- Prevost: a corrective measure is required due to bolts loosen by being tightened to part made of rubber,...
- Prevost: if rubbing found on 4 inch od turbo outlet pipe, after closing support bracket, then to increase...
- Prevost: information being provided regarding the replacement of dipstick on certain coaches
- Prevost: power is not removed when unplugging fuse F45 to fire protection panel on driver's left console...
- Prevost: automatic fire suppression system (AFSS) extinguisher cylinder relocation
- Prevost: information is being provided regarding two procedure methods of pinning or replacing the double...
- Prevost: volvo D13 engine US10 version: engine control module (ECM) and aftertreatment control module...
- Prevost: kidde fire extinguisher control head replacement
- Prevost: volvo D13 engine EPA2010 - retightening of conical injector yoke screw
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 Prevost X3-45?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history