2014 Prevost X3-45 technical service bulletins
174 technical service bulletins and manufacturer communications cover the 2014 Prevost X3-45.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The gasket thickness was increased from 1.5 mm to 3 mm to prevent interference between the collar ends,...
- Sway bar collars improvement
- Sway bar collars improvement
- Kit power steering tank convertion cummins to zf with D13 engine
- Improved bearings are now available to replace the original bearings used on some Prevost vehicles idler...
- Electric fan drive cooling system conversion with bosch alternator
- Electric fan drive cooling system conversion with delco remy alternator
- Steering gateway.
- Air Tanks Draining Sequence
- Air Tanks Draining Sequence
- Air Tanks Draining Sequence
- Halogen to LED fog light replacement kit
- Tag axle hub flange - alternate cap screw
- STEERING GATEWAY, revision A : Cancel watch dog removal from EFD part of the instruction
- STORAGE AND STARTUP GUIDELINES : part number updates
- Steering gateway
- X3 series envirocare - ions air sanitizer
- Central HVAC merv filters installation
- Bosch HD10 alternator diagnostic guide
- Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair – From US10 to newer...
- Ront & tag axle – unitized hub bearing end play verification and replacement
- Electric fan drive cooling system conversion with delco remy alternator - X3 series US10 up to GHG17...
- Eberspacher preheater installation
- Electric fan drive cooling system conversion with bosch alternator
- Electric fan drive cooling system conversion with delco remy alternator
- Electric fan drive cooling system conversion with bosch alternator - X3 series US10 up to GHG17 cooling system
- Central HVAC merv filters installation reva
- Storage and startup guidelines
- Automatic fire suppression system - tamper seal replacement
- Tie rod 610052 first installation instructions
- Introducing a new engine coolant into prevost service center network
- Volvo i-shift transmission replacement - difference between connections at the top of the oil filter housing
- Rev A: Mention added concerning DDC Series 60 engine SCA requirement
- Introducing a new engine coolant into service
- Engine oil & filter change intervals - volvo D13 engine, from US10
- Prevost aware adaptive cruise braking (ACB) FLR20 radar sensor replacement kit
- Storage and startup guidelines
- Engine Exhaust Gas Recirculation Differential Pressure
- Jerky, noisy or hard to turn steering gearbox
- General hoisting and towing procedures
- Electric fan drive cooling system conversion with delco remy alternator revision : b
- Electric fan drive cooling system conversion with bosch alternator
- Storage and startup guidelines
- Plexiglass Panel Behind Driver X3
- Accessory air filter replacement Replaces 642192
- Prevost vehicle disinfection procedure
- Hand sanitizer dispenser installation
- Prevost vehicle disinfection procedure
- Storage and startup guidelines - all prevost vehicles & volvo 9700
- Repair instructions to address fault codes P029800
- Repair instructions to address fault codes P040200 Engine Exhaust Gas Recirculation 1 Valve PositionFlow...
- Repair instructions to address fault codes P052400 Engine Oil Pressure Too Low
- Repair instructions to address fault codes P054415 Exhaust Gas Temperature Sensor Bank 1 Sensor 1
- Repair instructions to address fault codes P105998 Gearbox Oil Temperature Sensor
- Repair instructions to address fault codes P107017 Gearbox Brake Valve (VAGB)
- Repair instructions to address fault codes P107575 Clutch System
- Repair instructions to address fault codes P10CE97 Reductant Return: No Flow Detected
- Repair instructions to address fault codes P203115 Exhaust Gas Temperature Sensor Bank 1 Sensor 2
- Repair instructions to address fault codes P203F00 Reductant Level Low
- Repair instructions to address fault codes P204713 Reductant Injection Valve Control Bank 1 Unit 1 –...
- Repair instructions to address fault codes P204A13 Reductant Pressure Sensor
- Repair instructions to address fault codes P208464 Exhaust Gas Temperature Sensor Circuit...
- Repair instructions to address fault codes P20E892 Reductant Pressure Too Low
- Repair instructions to address fault codes P242A15 Exhaust Gas Temperature Sensor Bank 1 Sensor 3
- Repair instructions to address fault codes P256000 Engine Coolant Level Low
- Repair instructions to address fault codes U029D00 Lost Communication With NOx Sensor "A"
- Repair instructions to address fault codes U029E00 Lost Communication With NOx Sensor "B"
- Repair instructions to address fault codes U02A200 Lost Communication with Reductant Quality Module
- Added: Power cables for L.H. side alternator & fan drive breaker box
- Repair instructions to address fault codes P008A-00; P0087-00
- Repair instructions to address fault codes P207F-00
- Repair instructions to address fault codes P207F-00; P20EE-00
- Repair instructions to address fault codes P021700 Engine Coolant Over Temperature Condition
- Revision : Mention added stating to disable Prime & parts added in the kit.
- This instruction Sheet explains how to install a seatbelt cutter in the driver's area
- This instruction sheet explains how to install the Electric Cooling System Conversion kit (with Delco Remy...
- On the vehicles affected by
- Neutral gear - software update
- Prevost aware adaptive cruise braking (ACB) - FLR20 & FLR21 radar sensor alignment
- Vehicles identified below are compatible with a new tie rod design
- This instruction sheet shows how to install a flap over the diesel filling cap.
- Power steering pump discharge hose (pressure) replacement
- This instruction sheet shows how to replace kneeling level sensor #21643575 by sensor #22194741.
- This instruction sheet explains how to perform the replacement of the power steering pump discharge hose...
- This instruction sheet explains how to perform alternator conversion, from Bosch to Delco Remy, on X3 vehicles
- On the independent front suspension (IFS) of the vehicles affected by
- This bulletin explains how install an extension to the linear thermal detector (LTD) over the alternators
- This Instruction Sheet explains how to add Sunshade Switches on the Dashboard
- On the vehicles affected by
- On the vehicles affected by
- New aramid cord poly-v belts are now available to replace the polyester cord alternator belts previously...
- Explains that improved bearings are now available to replace the original bearings used on some Prevost...
- On the vehicles affected by this bulletin, replace the pitman arm nut and re-torque to specification.
- This maintenance information describes the steps to be followed on your computer to add the volvo engine...
- On the vehicles affected by this bulletin, vibration is causing damage to a/c compressor and compressor...
- Communication letter from Accociate Administration for Enforcement, the federal safety agency From Prevost...
- Bendix M-32QR ABS modulator valve replaced by new M-40QR valve.
- On the vehicles affected by
- On the vehicles affected by
- This Maintenance Information explains how to run a n Air Conditionning performance test
- On the vehicles affected by
- On the vehicles affected by
- This Maintrenance infomration explains that the Castrol Syntrans oil isn?t fully approved for 500 000...
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- This Instruction Sheet explains how to install a "T" Key on curbside Engine Compartment Door
- This Instruction Sheet prvides a Road Side and Workshop Instructions for Replacing 040949 6mm DEF Hose to...
- On the vehicles affected by
- Prevost: information provided on certain buses, the sway bar clamps of steer and drive axles need hardware...
- Summary to be provided on a future date.
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the independent front suspension level valve linkage of the vehicles affected by
- On the vehicles affected by
- Prevost: the supply hose for power steering needs be replaced on some buses
- Prevost: due to intermittently working, the five foot switches, on some buses, will be replaced
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- Prevost: rear junction box connections need inspected with clean terminals and TERMIN8R lubricant or black...
- Prevost: on some buses, the bi-fold door mechanism needed various improvements performed on it
- Prevost: when bus in position of low or high buoy, brake hose will contact air spring support and would...
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- Prevost: warranty issued, on some buses, regarding control rod of independent front suspension level...
- Prevost: when button to door is pressed to open, entrance door, on some buses, inadvertently, will open...
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
- Prevost: bosch hd 10 alternator connections, on some buses, need to be inspected and may need other parts...
- On the vehicles affected by
- On the vehicles affected by
- On the vehicles affected by
VIN decoder
See the problems and recalls for an exact car
Buying a used 2014 Prevost X3-45?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history