2013 Ram 3500 fuel system problems

Filed Apr 26, 2020 · Fuel system · 140,000 miles · AL

The def gauge does not show the correct amount of def fluid that is actually in the tank, it is always showing full.

Filed Jun 7, 2018 · Fuel system · 60,000 miles · AZ

The issue of the "dead pedal" needs to be fixed. This has left me stranded in the middle of an intersection on several occasions. This has left me on the side of the road hauling a 40" fifth wheel trailer and now today at lunch I stop at a drive through and had to park my truck there as I have a dead pedal. You give it gas and nothing happens. Google it, its a huge issue and could very easily cost someone there life.

Filed May 11, 2016 · Electrical, Engine · 6,700 miles · WY · fire · 1 injury

On dec. 15, 2014 I received a recall on my 2013 dodge ram 2500 diesel. The recall was for a inline fuel heater that may catch fire, it had no apparent fix, no parts, no instructions and no timeline as to when it would or could be fixed. I called the dealership and spoke to the service manager about my concerns, he told me that it was a remote possibility next to none, that the vehicle would catch fire. I asked him if I could park it inside and he said yes, and that the recall was just being sent out as a precaution. On the evening of jan 28th 2015 at approximately 0:920 pm smoke detectors alerted my dog and he woke me up. I woke my wife up yelling (fire) I panicked I took in a deep breath covered my mouth with my forearm, opened the personal entry door and stepped inside the garage not realizing how bad it was. The amount of heat being generated from the diesel fuel and the structure was so hot the back draft pulled the door out of my hand trapping me in the garage and because it was a schlage combination style there was no turning back, all I could see was complete black and red, red flames was shooting out from under my truck. My neighbor was kicking on my garage door yelling to wake up. I panicked again and hit the up button on the main garage door hoping to make a run for it, the garage door went up about a foot and fell hard because it pulled the door motor from the mounting brackets. I knew the only way out was the front door I used the side of the dodge as a guide and burnt my left hand, made it out the door and my neighbor handed me the garden hose hanging on the fence. All fire reports indicate the fire started under the hood of the dodge, the fire investigator from chrysler said in front of laramie county arson investigators that it originated at the fuel heater. State farm may have settled with dodge. Please read attachment.

Filed Nov 24, 2015 · Acceleration, Electrical · 24,000 miles · OR

The new dodge ram equipped with cummins diesel experience a dead pedal, or pedal delay when pressing the gas pedal 3/4 to full throttle. This poses a serious risk when needing to get out of the way, or move the vehicle under emergency circumstances. This happens under all conditions: stopped, rolling, under acceleration etc. If you push the pedal too far the truck will not respond to operator commands and will take 1.5-2 seconds to start picking up speed. This is a seriously dangerous situation and someone is going to get killed or seriously injured. There is not excuse for a vehicle not responding to driver input. Manufacture claims "turbo lag", this is simply not true. You can build turbo boost, monitored on the vehicle gauge, then press the pedal to the floor, the truck will not respond for 1.5 to 2 seconds. Please look at further information on the cummins forum below, it has numerous articles about this issue. Here as a link to just one of them. Http://www.cumminsforum.com/forum/2013-general-discussion/1836593-very-slow-throttle-response.html please, help fix this issue before someone gets hurt or killed due to the inability to move the vehicle out of harms way. This tsb somewhat addresses the problem, but only fixes it partially, not to the point that it is safe. Tsb 18-041-15 I believe the manufacture knows this is an issue, but is not fixing it due to emissions related programming on the vehicle. There are aftermarket solutions to this problem, however they void the manufacture warranty, and im not willing to lose my warranty on a new vehicle. I will be submitting another one of these for my 2015 as well, since they both have the same issue. Thank you.

Filed Oct 22, 2015 · Engine, Fuel system · IN

Tl* the contact owns a 2013 dodge ram 3500. The contact received notification of the federal safety agency campaign numbers: 14v635000 (engine and engine cooling, fuel system, diesel) and 15v541000 (steering); however, the parts to do the repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Filed Oct 21, 2015 · Fuel system · 60,000 miles · TX

My vehicle is in the shop for a 5th time for the same issue of the engine light comes on, message said error with def system , call dealer. Then message came up and said in 200 miles truck will shut down to only 5 MPH. The dealership and now warranty is refusing to fix it again basing their case on "contaminated def" fluid as the cause. I was told this is an issue on these trucks and to fix would be $1700 out of pocket even though it is still under warranty. Once the def was called "contaminated", everyone starting calling me asking for $ to repair the system saying it was my fault the fluid got contaminated. Distance driven from def error code 3 repair at the dealer to def error code 4, less than 100 miles and no def fluid was added since it left the dealer. The problem is recurring and no one wants to fix it. Truck is sitting at the dealer and cannot be driven due to the 200 mile shut down safety issue.

Filed Sep 30, 2015 · Fuel system, Steering · 80,000 miles · TX

While driving on the highway the truck starting shaking violently, the speed was reduced the shake ceased but the front driver side tire came off. When taken in a dodge dealership to inquire about repair,was told they could not repair it. This vehicle has lost power when driving on the interstate highway due to faulty fuel system.

Filed Jul 30, 2015 · Engine, Fuel system · 13,000 miles · GA

Truck loses power when accelerating from a dead stop. As the accelerator is depressed or feathered, the engine loses all power for 2-3 seconds leaving the driver helpless. If I allow the accelerator to return to idle position and then depress the accelerator again, the engine regains power and the vehicle accelerates. This is a very unsafe situation as I was towing a 12k pound trailer and was attempting to pull onto the highway. When the vehicle lost power, I was in jeopardy of being hit by oncoming traffic. This issue has occurred several times. I took the vehicle to the dealer but they were not able to duplicate the fault. I explained that this issue happened while the vehicle was under a load. The dealer never placed the vehicle under a load during their testing.

Filed Jan 13, 2015 · Engine, Fuel system · CT

Tl* the contact owns a 2013 dodge ram 3500. The contact received notification of the federal safety agency campaign number 14v635000 (engine and engine cooling, fuel system, diesel) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Filed Dec 31, 2014 · Engine, Fuel system · 8,000 miles · MI

I was on pa turnpike attemping to merge from a service plaza, when an opening in traffic was available I applied power to merge into line . As I did this my truck did not respond !! I was pulling a 36' fifth wheel trailer at the time and my merge into traffic became very perilious! After what seemed like a very long delay ( and some braking by other motorists ) my vehicle finally started to accelerate. Once the motor responded I had plenty of power to achive speed with traffic . I have told dealer about dead pedal and was told " never heard of it " this has happened to me more that once!