Ram 3500 wipers problems

Filed May 10, 2026 · Electrical · AR

The truck had about 7400 miles on it. It gave a warning that the DPF was near full and take it to dealer, about 20 minutes late it said DPF full power reduced. Two days later it cleared that code and began flashing the turn signal intermittently and giving warnings that the trailer brakes were not working, then that the tailgate was down. Shortly after that the instrument cluster went completely blank. I was driving it to the dealer when it ran out of fuel and forced me to stop on the highway. The vehicle has been at the dealer for almost 4 months now. When they replaced the dash cluster it would take too long to start. They replaced multiple modules and I believe three dash clusters before declaring it repaired. I picked it up for a test drive and the frontal collision warning came on intermittently along with a warning that automatic wipers would not work. I took it back. While at the dealership they reported to me that it developed additional issues and would not shift into gear. It is still at the dealership in Pine Bluff AR.

Filed Oct 21, 2025 · Airbags, Brakes · VA

Recurring water intrusion through firewall/wiper cowl causes electrical corrosion and loss of vehicle communication (CAN bus). Dealer repeatedly documented: • 05/19/2022: “Cowl drains clogged; water entering passenger side” (Invoice #XXX). • 08/15/2025: “Water intrusion through firewall due to wiper cowl drains being clogged with organic debris; water found in passenger kick-panel connector” (Invoice #XXX). Resulting failures include: • BCM shorted (02/16/2022 – replaced). • HVAC module failure (10/15/2022 – replaced). • Intermittent CAN bus, loss of gauges while driving (09/04/2025 – Invoice #XXX; dealer suspects internal corrosion from prior water leaks). • 10/16/2025: Dealer states “old water damage to BCM causing corrosion on circuit board and disrupting bus circuits”; BCM replaced again (Invoice #XXX). • 10/20/2025 (current): Dealer states “ORC (airbag module) dead on bus; ABS module loss-comm with ORC; replace airbag module” (Workorder #XXX). The truck has lost instrumentation and safety systems in rain, with airbag and ABS communication currently inoperative. This is a safety defect; seeking investigation and manufacturer remedy/reimbursement. Injuries/Crashes: None, near-miss due to loss of gauges. Dealer: Hall Chrysler Dodge Jeep Ram, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 6, 2025 · Visibility · 161,000 miles · OH

The contact owns a 2022 Ram 3500. The contact stated while driving approximately 65 MPH during the rain, the windshield wipers suddenly failed to operate as needed. The vehicle was taken to the dealer who diagnosed that the park switch wiring had failed. The wiring was replaced; however, the failure remained. The dealer determined that the Variable Cylinder Management (VCM) had failed and DTC: B2303/11; was retrieved. The contact stated that the VCM was repaired; however, the failure remained. The manufacturer was not informed of the failure. The failure mileage was approximately 161,000.

Filed Nov 2, 2023 · Fuel system, Steering · VT

I HAVE 27 OPEN RECALLS, the steering wheel knuckle just keeps getting looser, nothing on the column will tighten, my wipers short out , I was sold a Omission deleted truck with documentation the day of purchase it was omission deleted, I was never told this vehicle was unsafe, The manufacture wants me to pay hundreds of dollars out of pocket for them to see if it maybe safe enough . Both Chysler, and the certified dealership of ford refuse to take any accountability or action

Filed Aug 9, 2023 · Brakes, Electrical · WA

1. HCU and ABS. Yes available for inspection. 2. Faulty braking, faulty fuse control, faulty anti skid, electronics began random operations such as radio, gauges flashing and wipers working. 3.Yes. Dealer said bad HCU and ABS. Currently with dealer due to no part availability. 4. No. Dealership inspected. 5. Yes, in June 2022 the service 4wd light came on periodically when driving but when we got it into service it was working fine. July 2023 the lights began flashing, wipers going, warning lights flashing then no lights and the truck died. Had to have it towed to dealer.

Filed Jul 18, 2022 · Lights · FL

when using the automatic rain wipers with automatic headlights activated during the daytime the dash illumination is darken to night time values. Since the dash is digital along with the radio system, it is EXTREMELY difficult to see anything. It requires you take take your eyes off the road for a longer period to time to view any information on the dash or in the navigation/radio. The dash illumination should never darken during the daytime, unless the light value is decreased to what a nightime value would be.

Filed Feb 18, 2021 · Visibility · 51,000 miles · KY

Tl* the contact owns a 2019 ram 3500. The contact stated that the windshield wipers were shredded and deteriorating. The vehicle was taken to dan cummins chrysler dodge jeep ram of georgetown (1470 cherry blossom way, georgetown, ky 40324, (502) 378-5386) the vehicle was not diagnosed nor repaired. The manufacturer was not contacted or notified of the failure. The failure mileage was 51,000.

Filed Sep 20, 2018 · Visibility · 22,101 miles · MA

Vehicle windshield wipers malfunctioned and will not turn off, kills vehicle battery. Wipers do not function with fuse removed to prevent battery from draining, and windshield from being damaged, cannot safely drive vehicle in rain. Truck is now not safe to drive, cannot obtain inspection sticker, and ram cannot provide a replacement part to fix the vehicle. Part has been on back order for 3 months and will not provide a rental. I am being forced by ram to drive a vehicle, with my family, that is not safe, and illegally because I cannot obtain an inspection sticker and my registration will be revoked soon. Truck was never repaired and dealer (artioli dodge/ram) closed repair order without completing the repair.

Filed Nov 1, 2017 · Airbags, Visibility · 70,000 miles · OR

Pdc (fuse box) aka tipm has corrosion or bad internal electrical connections causing wipers to not function and possible air bag failure upon impact

Filed Oct 16, 2015 · Electrical, Engine · 40,000 miles · CO

July 17, 2015 - while stationary, I started truck only to have all warning lights on the dash illuminate, wipers activate on their own, and radio unit power off. Eventually, all power was lost to the dash. Truck was towed to dealer for repair. Truck received new PCM and was returned to me. July 17, 2015 - later that evening, the truck was towed back to dealer for the same problem. Truck was in the service center for two months receiving a new wiring harness and new computers. September 16, 2015 - truck returned to me. October 13, 2015 - while driving on a city street the truck exhibited the same problem. Momentarily lost engine power and transmission functionality. Lost all power to dash including trailer brakes. The truck sat idling for approximately one hour while waiting for a tow truck. I have recorded video of the dash continuing to flicker and power up and down erratically. October 16, 2015 - truck still at service center awaiting diagnosis and parts.