2017 Ram Promaster engine problems

Filed May 18, 2026 · Engine · PA

COMPONENT FAILED: Left transmission mount bracket and its fasteners on a 2017 RAM ProMaster with 3.6L V6 Pentastar (sales code ERB) and 62TE 6-speed automatic (sales code DG2). At least one bracket-to-transaxle bolt sheared. The bracket separated from the transmission, the powertrain dropped on the driver side, the left front CV axle pulled out of the transaxle, and transmission fluid loss occurred. The transmission case casting also appears cracked at the bracket mounting boss. All failed components are preserved and available for inspection. SAFETY RISK: Failure occurred during LOW-SPEED MANEUVERING. Had it occurred at highway speed, the dropped powertrain and separated front drive axle could have caused loss of vehicle control, sudden disabling of the vehicle in traffic, and roadway debris from dragging components. Industry-published cases describe identical failures at 40+ mph (Certified Transmission, May 2019). Multiple owner reports of the same failure exist for 2015-2021 ProMasters. CONFIRMED BY: Failure confirmed by visual inspection at an independent service facility. The failure mode matches FCA Service Bulletin 23-022-19 (8/27/2019), which warns the bracket fasteners are torque-to-yield, single-stage, one-time use, and that reuse can lead to bracket bolt failure. The TSB is classified Information Only — no recall has been issued. INSPECTED BY: Inspected by the owner and an independent repair technician. Not yet inspected by the manufacturer, police, or insurance. The vehicle had recent service in the transmission area; whether the one-time-use fasteners specified by the TSB were replaced during that service is under investigation. WARNING SIGNS: None. No warning lamps, messages, or symptoms preceded the failure. Given the documented failure mode, manufacturer service bulletin, and multiple owner reports of identical failures across model years, a formal investigation into a potential safety recall is requested.

Filed May 21, 2025 · Engine · WA

The contact owns a 2017 Ram Promaster 3500. The contact received notification of the federal safety agency Campaign Number: 19V818000 (Equipment, Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Jan 6, 2025 · Brakes, Engine · AL · crash

Went to use the brakes and they would not work. Had to swerve into a ditch to stop. ABS and Traction issue.

Filed Sep 13, 2024 · Electrical, Engine · CA

There’s already a recall on the engine cooling fans. I was driving on the freeway when the cooling g fans failed causing overheating and major damage to the engine, specifically the head gasket, thermostat, and radiator. I took it to the dealer after finding out about the recall. They replaced the fans but are still not working correctly. They also refused to repair the other damages that were caused due to the recall part failure. I use my vehicle for work and have been unable to work for more than 2 weeks now due to the damages and have had to decline a lot of work in that time. This is affecting my livelihood. So far the dealer and manufacturer have only wanted to charge me for any additional diags or repairs when my vehicle was running great until this incident. The vehicle is unsafe to drive and the recall report stated the engine could catch fire. I took my vehicle to the dealer, a second time to see what they could do for me, Just to find out, they only wanted to charge me for multiple diagnostic diagnosis and would have me wait. At least a week before they could even begin touching my vehicle also refusing to give me a loaner vehicle in the meantime.

Filed Sep 11, 2024 · Electrical, Engine · CA

What happened: While driving on the freeway, the engine cooling fans failed, causing the engine temperature to rise excessively and increasing pressure within the cooling system. This resulted in a hole being blown through the thermostat, and all the coolant leaked out. Only after the coolant was lost did the engine overheating warning lamp come on. I safely pulled over, but the engine had already overheated severely. I was unable to drive the vehicle for a week while waiting for the dealer to replace the cooling fans under the recall. After the recall repair was completed, I picked up my vehicle from the dealer. On my way home, I noticed a loss of power, poor acceleration, and engine shaking, especially after the engine had been off for a few hours. I replaced the thermostat and radiator myself, but I believe the overheating caused internal engine damage, potentially a blown head gasket, cracked, or warped heads. Additionally, before taking the vehicle back to the dealer, I noticed the newly installed cooling fans (replaced under the recall) stopped working again. Despite all these issues clearly being related to the initial fan failure and overheating, the dealer is now charging me for further repairs and is not addressing the underlying problem with the cooling system. The fact that the cooling fans have a recall due to failure and have caused other issues are trying to tell me I’m responsible. They wouldn’t give me a loaner vehicle while they were performing the initial recall repair or now since I’ve taken it back.

Filed Feb 20, 2024 · Engine · AZ

Both cams need to be replaced. Upon doing internet research and talking with the service advisor this is a very commom problem and recalls have been done on other years but not 2017. Henry Miller Dodge Ram is where my vehicle is currently at and who advised the issues at hand. The check engine light comes on and computer shows misfire.

Filed Jun 16, 2023 · Electrical, Engine · 85,000 miles · GA · fire

The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the federal safety agency campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.

Filed Jun 12, 2023 · Electrical, Engine · FL

2017, 119,000 miles. 8/9/18: maintenance transmission service at 62,651 miles. 6/4/20 Recall WOO shifter cable replaced. 11/11/21 AGM Interstate battery MTX-49 replaced. ISSUE: End of May 2022 (~117,000 miles) had driven from Florida & back 2x without any problems but was slowing down by taking my foot off the gas for exit ramp - the engine started roaring louder & the vehicle apparently had shifted to ?neutral - pulled off the road & shifted to P & then to D & drove on home without any further problem. That was #1 occurrence & I took it to a transmission shop in July (had not had the problem again) to see what they thought. They did road test, fluid check & scan of control modules for trouble codes/errors & analyzed data stream for inconsistencies - found no error codes or inconsistencies. Incidentally, have been having some type of parasitic draw on my new battery for the past year. Occurrence #2: almost a year later April 2023 I am driving up to 55 mph running errands & I slow down to 45 mph & the engine starts to roar & the van is coasting & the light up area of P-R-N-D backlight is not lit up that is normally lit up & no check codes/warnings have appeared - everything else including front drivers light panel all normally lit. I pull off into a parking lot, put in park, turn it off, then turn back on (still with unlit gear display) & I put in drive & it runs normally around the parking lot & the remaining way home.I have driven it locally for 40-60 miles each time with intermittent stops for about 4-5 times since then & can’t replicate the problem again. Incidentally still parasitic draw on battery. 1) could replaced shifter cable be a problem? 2) fuse #38 problem causing loss of power to solenoids? 3) transmission range sensor failing causing it to fall out of gear? 4) transmission control module problem? 5) solenoid problem? 6) worn/broken transmission bands? 7) worn out gears? - some cause putting into “limp mode”? This is dangerous situation?

Filed Jun 2, 2023 · Electrical, Engine · CO

Was not notified that my Ram Promaster 2017 needed two recalls when purchasing it from an official Ram dealership in 2020 with 35k miles on it. Now, at 90k miles I'm having to replace a radiator and cables that failed as a result of the coolant fan being replaced. Took it to two separate shops (first shop couldn't lift it) which both confirmed that my radiator experienced failure and caused electrical faults including blowing a 60amp fuse because this part was not replaced. I never was notified by Ram over the phone regarding this issue or from the dealership I purchased it from. Now, I'm having to pay a lot out of pocket to repair these parts (because I can't get my vehicle into any Ram dealership in the area for over a month) and having a third party, high quality mechanic do the repairs instead. I had to also pay to have the vehicle towed to the shop at my own expense as the vehicle had the check engine light on and was deemed by the first mechanic to not be safe to drive. I will upload files of the repair costs once the repairs are complete. $315 tow, $300 in diagnosing fees that won't be covered, and $1600 out of pocket for repairs is what I'm looking at. If I didn't have a 3rd party extended warranty, it would cost me close to $5k for repairs.

Filed Sep 23, 2022 · Engine · GA

2017 ram promaster. Consumer writes in regard to engine cooling fan safety recall.