Incident Overview: In late February 2026, at approximately 114,000 miles, this 2022 Rivian R1T suffered a comprehensive failure of its kinetic (hydraulic) suspension system. The failure occurred during normal on-road operation at approximately 60 mph in temperate (60°F) conditions. The vehicle has no history of off-road use or heavy hauling. Safety Risk & Critical Failure Mode: The suspension is a safety-critical system essential for vehicle stability, emergency braking, and predictable handling. A loss of hydraulic integrity in this system directly compromises the vehicle’s ability to maintain ride height and damping control. High-Speed Exposure: The initial failure manifested while traveling at 60 mph. Although a warning lamp was triggered, the vehicle’s functional safety logic failed to initiate a "limp mode" or restricted speed state. This allowed the 7,000lb vehicle to continue at highway speeds with a compromised high-pressure hydraulic circuit, posing an unreasonable risk of loss of control. Lack of System Redundancy: A localized hydraulic leak resulted in a cascading collapse of the entire architecture. Per the $10,662 service estimate, the repair requires replacing the front and rear dampers, hydraulic pump, manifold, and all fluid lines. This suggests a design-level vulnerability where a single-point failure in the hydraulic circuit necessitates a total system overhaul, indicating a lack of modularity or redundancy. Safety Protocol Gap: After diagnosing the leak, the authorized service center deferred to my personal judgment regarding operational safety. This forced an untrained consumer to make a critical safety determination on a high-pressure system while the vehicle remained capable of full highway speeds. Technical Confirmation: An authorized Rivian service center confirmed the failure on March 3, 2026, and determined a full system-wide replacement is required. All components are available for inspection. No prior warnings or symptoms were presen
2022 Rivian R1T suspension complaints
Page 2 of 2: complaints 11 to 17 of 17, newest first, as owners wrote them.
The vehicle experienced a failure of the air suspension system, initially presenting with warnings indicating the vehicle was raising and advising not to drive to avoid damage. Shortly thereafter, the vehicle became visibly uneven, tilting approximately 2–3 inches to the driver side. I took the vehicle to Rivian service, where they confirmed the air suspension had failed. The repair was not covered under warranty, so I initially declined service while attempting to escalate the issue. During this time, the condition worsened significantly, with the vehicle continuing to tilt and the suspension actively lowering while driving. On multiple occasions, the vehicle became unstable and began bouncing uncontrollably, making it difficult to steer and maintain control, creating a serious safety risk and potential for collision. The issue was ongoing and reproducible. I ultimately proceeded with the repair and had the suspension system replaced; however, following the repair, the vehicle is now tilting in the opposite direction (passenger side), indicating a continued or recurring failure. The vehicle is available for inspection, and a follow-up service appointment is scheduled. The cause appears to be a failure of the air suspension system and/or improper repair, though the exact root cause is unknown.
My vehicle is subject to an active safety recall involving a rear toe bolt that Rivian has identified as potentially shearing and causing loss of vehicle control and a crash. I am located in Ketchikan, Alaska. Rivian does not offer mobile or field service for this recall and requires the vehicle to be transported to either Anchorage or Seattle for repair. Transport to Anchorage is not possible, and while transport to Seattle is possible, there is no viable or predictable way to return the vehicle to my location, potentially leaving me without my primary vehicle for several months. Rivian has stated they will not cover transport and has not provided a feasible alternative. This leaves me without reasonable access to a safety recall remedy and effectively requires me to either operate a vehicle with a known safety defect or surrender it indefinitely. I am reporting this as a lack of reasonable access to a safety recall repair.
I was driving about 35-40mpg when the right rear toe link snapped due to inproper torquing. I believe the bolt had backed out then snapped. When I contacted rivian they initially blamed me for it before even in before inspecting the vehicle. Once they inspected it they stated it would be covered under warranty. There was no paint on the bolt to show proper torque had been applied. Which is a standard process for rivian. I had asked them to please check the left rear toe link as well and make sure it’s all torque properly or even replace the link since they are one time use parts. They did not check it they did not paint mark any of the left side. They did paint mark the right side. The result of this link snapping out my family in great danger by sliding across the road and almost going into the mountain side. We were on the freeway while this happened I would not be writing the report. I beg you to please look into this matter. I no longer feel safe putting my family into the vehicle as I am scared something else was not put on correctly. They also stated in the service report that the halfshafts were not seated properly which could have caused a catastrophic accident. Thank you
The suspension system has failed three times. The entire system has been replaced by the dealership twice under warranty. The most recent failure has not been addressed, as the dealer is now refusing to make further repairs. The suspension issues significantly affect vehicle handling and steering during normal operation. Under heavy acceleration, the vehicle becomes difficult to control, posing a serious safety risk.
Catastrophic failure of rear upper control arm / suspension resulting in temporary loss of control. Occurred driving straight at 35mph without any prior damage or symptoms.
Was driving through an intersection in traffic when I heard a loud explosion/metal-on-metal sound from the front drivers side of the vehicle. Instantly received two warnings in the IP; one for "Performance Limited" and the other for "Service Suspension Soon". The IP also stated speed was limited to 80MPH. I didn't notice any difference in driving but decided to pull over and check. Upon checking I identified a hydraulic suspension line completely disconnected and leaking hydraulic fluid in the front driver side wheel well. The wheel well also appeared to be covered in hydraulic fluid. Over the next 10-15 minutes the suspension became uneven/lopsided and the passenger side wheels were touching the wheel well. I called Rivian service and they said it was not safe to drive and had it towed to the Rivian service center. Rivian service is backlogged and will not be able to inspect and assess the damage until 9/21. Ultimately, I don't think the warnings accurately conveyed the severity of the issue and don't understand why the vehicle would let you drive up to 80mph when rivian service said it was not safe to drive.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Rivian R1T?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history