2002 Saab 9-3 recalls

What is wrong

On certain passenger vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production.

Risk

Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire.

Remedy

Dealers will develop a securing bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break. The recall began on june 13, 2007. This is an expansion of previous recall campaigns - see 04v557 and 06v126. Owners may contact saab at 1‑800‑955‑9007.

Recall number 07V087000 · Recall details

What is wrong

Certain passenger vehicles equipped with b205/b235 4-cylinder gasoline engines and b308 6-cylinder gasoline engines may experience overheating and burnout of the isolated gated bipolar transistor (igbt) within the ignition discharge module (idm) due to increased susceptibility to electrical loads.

Risk

Overheating of the igbt occurs most often at engine start-up, but it may also occur while the engine is running. Engine stalling may occur, which could result in a crash.

Remedy

Dealers will inspect to see what version idm is in the vehicle and replace the idm if it is a version built prior to the introduction of qp3. An interim letter will be mailed to owners in october 2005, informing them of the condition. Parts are now available and owners will be notified to bring their vehicles in to the dealers to have the idm replaced by letter dated march 13, 2006. Owners may contact saab at 1‑800‑955‑9007.

Recall number 05V399000 · Recall details

What is wrong

On certain passenger vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production.

Risk

Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire.

Remedy

Dealers will develop a securing bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break. The recall began on march 14, 2005. Owners should contact saab at 1‑800‑955‑9007.

Recall number 04V557000 · Recall details

What is wrong

Vehicle description: passenger vehicles. The tie rod end retaining nuts may not have been properly tightened at the factory.

Risk

The nut could loosen and fall off resulting in a sudden reduction or loss of steering control.

Remedy

All vehicles will be inspected and corrected prior to customer delivery. No owner notification will be required.

Recall number 01V314000 · Recall details