1997 Saturn EV1 recalls
There are 5 safety recalls on record for the 1997 Saturn EV1, covering 2,026 vehicles in total across all the models in each campaign. Newest first.
All recalls
Service brakes, hydraulic
- What is wrong
- Vehicle description: electric vehicles. These vehicles were produced with wheel speed circuitry in the brake torque control module (btcm) which can cease to operate properly.
- Risk
- If this occurs, involved vehicles will exhibit one or more of the following: a loss of front brake assist, a disabled rear brake system, a disabled anti-lock brake system, and/or a disabled regenerative brake system. This could increase brake pedal travel and vehicle stopping distance.
- Remedy
- Dealers will replace the btcm, the ballscrew assemblies in the brake pressure modulator valve, and install new software.
Recall number 00V369000 · Recall details
Electrical system: 12v/24v/48v battery
- What is wrong
- Vehicle description: generation 1 electric passenger vehicles. These vehicles were built with a charge port assembly that could fail during a charging event.
- Risk
- Heat could build up within the charge port and a fire could result.
- Remedy
- These passenger vehicles were repurchased by saturn/gm.
Recall number 00V069100 · Recall details
Service brakes, air: antilock: control unit/module
- What is wrong
- Vehicle description: electric vehicles. A transistor within the brake torque control module (btcm) causes an electrical short to ground. This does not comply with the requirements of fmvss no. 105, "hydraulic brake system."
- Risk
- As a result, vehicles can experience a loss of front brake assist, increasing the brake pedal travel, and vehicle stopping distance.
- Remedy
- Dealers will replace the brake torque control module.
Recall number 98V169000 · Recall details
Service brakes, hydraulic: power assist: vacuum: hoses, lines/piping, and fittings
- What is wrong
- Vehicle description: passenger vehicles. These vehicles were built with a damaged o-ring in the brake pressure modulator valve solenoid(s) on the brake pressure modulator. Involved vehicles can develop an external brake fluid leak in one or both of the brake pressuremodulator valve solenoids.
- Risk
- Brake fluid leakage could reduce brake effectiveness and increase stopping distances.
- Remedy
- Dealers will inspect and, if necessary, replace the solenoid(s) on the brake pressure modulator.
Recall number 97V109000 · Recall details
Electrical system
- What is wrong
- Vehicle description: electric vehicles. These vehicles were built with a drive motor charger receptacle assembly that was incompletely sealed. Incomplete sealing can allow water to intrude into the circuit board.
- Risk
- During charging a short circuit could occur. An arc at the short circuit can generate enough heat to create smoke and/or a flame. If a flame occurs, a fire could result.
- Remedy
- Dealers will inspect the drive motor battery charger receptacle assembly and replace it, if necessary.
Recall number 97V042000 · Recall details
Questions about the 1997 Saturn EV1 recalls
How do I check if my 1997 Saturn EV1 has an open recall?
Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.
Do I have to pay for a recall repair?
No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.
How many recalls does the 1997 Saturn EV1 have?
5, covering service brakes, hydraulic, electrical system and service brakes, air.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Saturn EV1?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history