2003 saturn ion . Consumer writes in regards to vehicle recall issues *tgw the consumer stated the vehicle was purchased new and she was never informed of a recall regarding the body control module which she was having problems with. The consumer stated the problem first started when the driver side window dropped when she closed the door. Then it would not stay up. Then half of the dash went black. The next window would go up and down on its own with no contact of any type. Then the controls to the electric windows stopped working completely and the electronic lock/opening device would not open the doors any longer or lock the trunk. The consumer was informed she would have to pay for a diagnostic test. The consumer also stated there was also a problem with the transmission. The vehicle did not react to being in park, so therefore, she had difficulty removing the keys from the ignition. The o2 sensor and the ignition switch had to be replaced. The consumer stated the transmission was never properly replaced. On one occasion, the vehicle stalled and the steering locked up.
2003 Saturn Ion visibility complaints
Page 2 of 2: complaints 11 to 38 of 38, newest first, as owners wrote them.
Tl* the contact owns a 2003 saturn ion. The contact stated that the while driving in incliment weather, he noticed that the windshield wipers would not operate. The vehicle was inspected by an independent mechanic, who was unable to diagnose the failure. The manufacturer was notified and stated that there were no recalls addressing the failure. The vehicle was not repaired. The failure mileage was approximately 52,000. The VIN was unavailable.
I am the owner of a 2003 saturn ion and was driving down the highway when it started raining. I have very poor visibility because the drivers side wiper blade flew off the side of the windshield. I called saturn about this concern, was told I have to replace it. It shows the connective joint on the wiper broke loose and after reading several hundred complaints online about this same problem, it is apparent that saturn knows of this defective product, but charges hundreds of dollars to repair the problem. Many injuries and possibly death could result from this defect and I am very unhappy with saturn's lack of concern for public safety. I can only drive my car when it is not raining because I cannot afford 481.00 to fix what should not have broken in the first place. The plastic molding on the windshield cavity is not sufficient or safe for any vehicle. Please attend to this matter before someone is killed.
2003 saturn ion wiper failure: the wiper linkage aka wiper transmission broke while driving down the highway at 70mph in a rain storm. There was not any ice and the wipers were in good shape. The wiper proceeded to go outside of the windshield and not return to the off position. Very dangerous and others have had the same problem. Again there was not any ice involved.
Saturn have a recall on the 2003 saturn ion l series and I experienced a very dangerous situation involving the wiper motor. While traveling on an expressway doing about 60mph, the windshield wiper completely flew off the range of the window. Upon safely getting off, I pulled into a mechanic shop and was told the wiper motor just failed. I contacted saturn to tell them about the recall on the l series and that this car demonstrates the same problem. They offered not assistance or even cared about the fact the I could have been killed because it was raining hard and the motor went out. Someone should investigate this problem before lives are lost.
Power-operated window,." the power windows are inoperable after the ignition has been turned to the "off" position and the front passenger door is opened *cn the reverse lights do not work!!! Have been replaced many many times
Tl*the contact owns a 2003 saturn ion. The contact started the ignition and the windshield wiper system activated. Immediately, the driver's side windshield wiper began to move erratically. The failure occurred without warning. Currently, the driver's side windshield wiper is inoperative. The vehicle has not been repaired. The VIN was not accepted by the system. The failure and current mileages were 62,000.
The other day while driving my saturn ion in the rain my windshield wiper went the opposite direction into on coming traffic had to stop the car and attempt to fix on highway. The wiper since then will not work. The wiper arm no sits loosely on car. This issue happened to my wife's saturn ion also we had to repair it. That time it happened while vehicle was at mechanic they never took responsibility for it.
On my 2003 saturn ion 3 the left side wiper went the opposite way and locked in place while driving car on highway. Had to pull over and try to repair while on road. This happened to my wife's saturn ion 2 and we paid to repair it.
Tl*the contact owns a 2003 saturn ion. The contact stated that the duct port, where air travels through the vehicle, fails to transport correctly and becomes stuck. The insulation between the vent loosens and stops switching between heat and defrost. The failure began at 36,000 miles. The failure has not been repaired. The contact feels that this is a safety issue because the windows could fog up and reduce visibility. The failure occurs in rainy weather conditions. The VIN was unknown. The current and failure mileages were 80,000.
My 18 yr old daughter was driving to school this morning during a heavy rain downpour and almost had a wreck due to the sudden malfunction of the driver's side windshield wiper assembly. The wiper arm sudden became "possessed" were it was moving erratically causing practically zero visibility on a busy two-lane highway. She barely pulled off the road as a school bus rounded the curve. Needless to say everyone was lucky. A good samaritan mechanic stopped and quickly assessed that a plastic support had broken on the wiper motor assembly. We had to leave the car in a stranger's driveway until we can make arrangements to move it during safer conditions. I got on the computer and found where others had suffered the same issue!! I know parts wear out, but this is a major safety issue that gives no warning. My daughter was lucky not have wrecked or injured the school children that were standing on the side of the road, awaiting the bus. Angry mother
Tl*the contact owns a 2003 saturn ion. While driving approximately 55 MPH on normal road conditions, the windshield wipers were activated to clean the windshield. The driver's side windshield wipers failed to operate. The failure occurred without warning. The vehicle was taken to an independent repair shop and they stated that the failure was related to the windshield wiper transmission. The vehicle was repaired. The contact was concerned of the safety risk involved. She is in the process of notifying the manufacturer. The failure mileage was 36,000 and current mileage was 37,000.
Tl*the contact owns a 2003 saturn ion. Sporadically, while driving various speeds, the vehicle would stall without warning. The contact would also experience a no start condition. He took the vehicle to the dealer and they replaced the ignition switch at the cost of several hundred dollars. Two years later, the failure recurred, but the dealer would not assume any responsibility. Lastly, the windshield wipers would repeatedly hop around the windshield. On one occasion, the wiper fractured and had to be replaced. The failure mileage was 54,000 and current mileage was 99,000.
Temperature control knobs don't rotate and it restricts the air flow preventing the car from defogging front windshield, drivers side and passenger side windows restricting visibility making the continue operation of the vehicle unsafe.
The windshield wiper arm component on my 2003 saturn ion (which connects the right and left wipers) has plastic parts that will snap in cold weather, rendering at least the left windshield wiper inoperative. This could have created an extremely hazardous condition, especially during a snow or ice storm. The repair shop told us that the component arm had to be on back order, and it would take two weeks to get a replacement. It actually took four weeks, which leads me to believe that the problem is not an isolated one. The replacement, which cost $162.00 without labor, also has plastic components. The windshield wipers sit below the part on the windshield where the defroster vents are aimed, causing the wipers to stay frozen on the windshield even after the defroster is turned on. When the wipers are turned on, the strain on the arm component (caused when the frozen wiper blades stay stuck on the windshield) causes the plastic part to snap, rendering at least the left wiper inoperative.
When it rains or snows, my driver seat and floor gets wet. There are no water stains around the sun roof nor is there any water damage on the drivers' door. In new england, the car is non-functional in the winter and spring because of this problem. I have taken it to the local saturn dealership and they have refused to fix it. 2) I have had to replace my front turn signals 3 times in 1.5 years. I am almost convinced it is a socket problem and not a lightbulb problem. 3) I have had to replace the brakes and rotors twice within a 12 month period. In that time. I have only driven 17,000 miles. Once is understandable. Twice is expensive and ridiculous.
Tl*the contact owns a 2003 saturn ion. While driving 55 MPH during rainy conditions, the windshield wipers traveled beyond the normal radius. The contact noticed that the plastic linkage on the wiper motor had failed. The dealer has not inspected the vehicle. There is a defect investigation open (the federal safety agency action # pe07011) for the windshield wiper linkages. The current and failure mileages were 43,000.
Tl* the contact owns a 2003 saturn ion. The windshield wiper linkage failed while driving 50 MPH in the rain. The windshield wiper came off the driver's side window shield and would not return to its normal position. The failure mileage was 42,990. The dealer informed the contact that they were repairing the linkage. The contact was aware that of investigation# pe 07011 on the same year, make and model vehicle for the duplicate failure. Also, the dealer informed the contact that the timing chain should be repaired, it was related to investigation #dp 05008. The current mileage was 43,000.
Tl* - the contact called regarding a 2003 saturn ion. The contact stated that the engine would not turn over in cold temperatures. This happened intermittently, 36 times. The contact did not lose power . The vehicle will eventually start. The contact took the vehicle to the dealer for diagnosis. The dealer diagnosed the failure, but she would have to pay for the repair. The contact stated that the windshield washers did not work. The weatherwas not a factor.
I don't know what caused the failure, but it has never been abused, and the car has only 45747 miles as of the service date. We live in michigan, and although the manufacturer may want to claim that snow caused this failure, we have not had any snowfall prior to this date (10-25-06). I noticed that the windshield wiper arm was folded outward from the windshield. I took it to the dealer, and their diagnosis was that the support bracket was broken. However, there is no way to obtain the simple bracket. The entire assembly including the wiper motor which still functioned correctly had to be replaced. The parts of the assembly are a unitized module where no single part can be purchased individually. The total cost of this assembly (gm part number 15221904 according to the invoice) was $149.12 while labor and fees made up an additional $100. Overall cost to fix was $250.91 with state taxes. I asked for the broken part, which is available for you to look at (I will take digital pictures if you so wish). Additionally, while most of the mechanism is constructed of metal, the high stress points (the brackets) are made of brittle plastic. While no harm came to me because of this failure, the potential for catastrophe does exist. If this mechanism were to fail while one was driving, their vision would be obstructed and an accident could easily occur. This is particularly true in my case, where the driver's side wiper was rendered virtually useless. This defect could easily be corrected. The brackets which are both made of brittle plastic could be replaced with a more reliable metal part. To save precious pennies, saturn chose to construct this critical part of the car with an inferior material. The result is a design flaw potentially affecting the safety of thousands of unsuspecting saturn owners. I ask that consideration be made for them while this complaint is reviewed.
Premature failure of the driver side windshield wiper linkage causing wiper to be inoperable.
2003 ion has had blower fan, clutch switch, cylinder cable hood latch, brake light bulb, wiper module all replaced with in months apart from each other. *ts the rotors were warped and the tail lamp failed.
Driver noticed that the transmission would down shift on its own. Driver took vehicle to the dealer for inspection, and mechanic determined that transmission was adjusted on more than one occasion. However, driver informed the mechanic that the problem still occurred, and had not been resolved. *ak the consumer stated that the engine takes 2-5 minutes for it to idle down from 2500 RPM's. The consumer stated that the defoster on the passenger side failed. The consumer stated that the hood would not always close properly.
Interior roof around sun roof - very loss and wires are exposed. Dealership was notified when vehicle was purchased and failed to fix issue. Possible issue with wires exposed to getting wet. Ceiling has started to hang lower because the material/glue holding it in place is not working right. Possible replacement of ceiling should be done but company has not.
The driver's side door leaks at the top. Condensation gathers on the upper inside of the door and drips on the drivers leg, as well as on the power window/locks switches, which could cause corrosion or a short in the electrical system.
To date, vehicle has has multiple problems which dealer/service department has been unable to resolve. 10 service visits in less than 6 months and no end in sight. Problems include: daytime running lights/blinker lights inopperable (repaired 6 times); outside temperature guage malfunctioning (repaired 3+ times); air conditioning inopperable and compass malfunctioning.
2003 saturn ion 1. During cold weather the passenger side window frosts. The controls are set for defrost, air on and blower medium high. Even with the blower on high there is very little air coming from the passenger side defrost outlet. A co-worker has a similar problem with his ion. The dealer said the system is operating as designed. 2. The hood latch freezes and the hood cant be opened to add window washer fluid. Sometimes you can get the hood open but you cant relatch the hood completely without pushing the hood release handle down. A co-worker has a similar problem with his ion. 3. Some the edges on interior plastic parts on the are very sharp. The worst is the compartment door to the left drivers leg. This popped open and had a sharp rough edge. As I exited the car I cut my leg. I fixed this myself by filling the edge.
Consumer having problems getting two recalls performed on the vehicle. *ph when the consumer tried to make an appointment, the dealership told the consumer he had heard of the recall but was not familiar with what it said, the consumer wanted to make an appointment for the weekend, but was told the most skilled mechanics worked weekdays. The consumer felt the dealership had only been minimally informed of the recall. *jb
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 Saturn Ion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history