2005 Saturn Relay electrical problems

Filed Jul 17, 2018 · Electrical · 180,000 miles · MI

Exact same issue as described in april 2014 gm recall 14063. Sudden loss of electrical power while driving causing the engine to shut off. Unpredictable very dangerous. Seems to be the ignition switch. Other saturns are listed in the 2014 recall but mine is not. It should be listed.

Filed Jul 15, 2016 · Brakes, Driver assistance · 90,000 miles · CT

Tl* the contact owns a 2005 saturn relay. While operating the vehicle, the speed sensor and traction control sensor lights illuminated and the braking distance increased when the brake pedal was depressed. The vehicle was taken to the dealer where it was diagnosed that the electronic body control module was faulty and needed to be replaced. The vehicle was not repaired. Also, the sliding door chime activated even though both sliding doors were closed. Also, the steering wheel suddenly became very difficult to turn. The cause of the failures were not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The VIN was invalid. The failure mileage was 90,000. Updated 09/08/16*lj

Filed Aug 22, 2015 · Electrical, Lights · 100,000 miles · GA

When I drive at night I have to turn my headlights off to use my turn signals. I have noticed that the turn signal on the driver's side of the 2005 saturn relay will not work unless the headlights are turned off. I have not had any accidents...yet. This is a real safety issue.

Filed Aug 22, 2015 · Driver assistance, Electrical · 110,000 miles · GA

The first time I was parked and the van would not start. I was told it might be the fuel pump. I had the van tow to a service center. They said it was the fuel relay. I paid to have the fuel relay replaced. A few days later same thing happened again. The van would not start. This time we thought it was the battery or spark plugs. I paid to have a new battery, new spark plugs, spark plug cables. A few days later I was leaving from work and the van would not start again. I had it tow and they said it might be the fuel pump. They were going to replaced the fuel pump but then noticed the wires located on the passenger side of the van. The mechanic wiggled the wires and the van started. A few weeks later I was driving down the road doing about 50 and the van just lost power. It was as if it ran out of gas. I was able to safely pull over and had the van towed again. After this several times, while driving the van will act as if it ran out of gas. I have been very lucky I have not been in an accident...yet. I have to get out of the van, go to the passenger side and wiggle the wires located under the glove compartment of the van.

Filed Apr 20, 2015 · Electrical · 102,515 miles · CA

Driving around 10 MPH, car died. Took it to the shop and they said it was the ignition switch. Looked on gm website and there is a recall for this same problem, however not for the relay. I believe there should be a recall for all saturns! I am very lucky I was not driving on the freeway when this incident occurred.

Filed Feb 16, 2015 · Electrical · 190,000 miles · WI · fire

On 1/12/15, while my 2005 saturn relay was parked in my garage, started on fire. Vehicle was not started or going at the time. Last drove the vehicle approximately one hour prior. It was determined that the ceiling component that has the buttons to open the back sliding doors, onstar and garage opening, is what started the electrical fire, which burned a whole in my roof, burned the drivers side visor, which in turn burned the driver side seat and car seat behind the driver's door. Gm determined it was not there problem because the vehicle was 10 years old and no other cases were on file. A very very very scary situation.

Filed Aug 11, 2014 · Electrical, Steering · 112,000 miles · MA

Tl* the contact owns a 2005 saturn relay. While driving 30 MPH, the steering failed and an unknown warning indicator illuminated. The vehicle also veered to the left and right. The vehicle was turned off and restarted. The failure occurred on numerous occasions. The vehicle was taken to a private mechanic who stated that the steering wheel knuckle and ignition switch needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 112,000.

Filed Jul 1, 2014 · Electrical · 250,000 miles · TN

Tl* the contact owns a 2005 saturn relay. The contact stated that the vehicle failed to start. The vehicle restarted briefly but stalled immediately after. The vehicle was taken to an independent mechanic. The technician diagnosed that the ignition switch was defective and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the problem. The approximate failure mileage was 250,000.

Filed Mar 31, 2014 · Electrical · 75,000 miles · TX

Tl* the contact owns a 2005 saturn relay. The contact stated that the vehicle sporadically failed to start. The vehicle was not taken for inspection or repairs. The manufacture was made aware of the failure and stated that the vehicle was not included in any recalls. The vehicle was not repaired. The failure mileage was 75,000. Updated 05/28/14

Filed Mar 8, 2014 · Brakes, Electrical · GA

After having my brakes replaced, the ABS light continues to come on. The light will go off for awhile, but every time I apply the brakes it will come back on for days. I am also having issues with my brake lights, turn signals, and headlights. They keep going in and out. Sometimes the passenger side door will not open or close correctly, I check to make sure nothing is in the way but still have the problem.