Scion FR-S engine failure problems

Filed Jun 8, 2026 · Engine · AR

On approximately May 27, 2026 I delivered my 2013 Scion FR-S (approx. 105,000 miles) to an authorized Toyota dealer for Safety Recall J02 (the federal safety agency 18V‑772, engine valve spring replacement). I picked it up on June 3, 2026. Immediately the engine ran sluggish and the air conditioning, which had worked, stopped blowing cold. On June 7, 2026 - four days and only a few miles later - the engine spun a rod bearing and began knocking loudly. The vehicle is now inoperable. This recall requires removing and disassembling the engine and is widely documented to cause oil starvation and spun bearings when excess RTV sealant from reassembly clogs the oil pickup screen. My engine ran normally for years and failed within days of the recall repair. The recall repair caused catastrophic engine failure. No crash or injury has occurred; the vehicle is parked to prevent further damage.

Filed May 30, 2023 · Engine · NC

The engine suffered catastrophic failure 2,988 miles after the J02 Saftey recall was performed by Preston Toyota of New Castle, PA. I was travelling at highway speeds when the engine died and would not turn on. I lost all power brakes and could have wrecked and injured myself, others or worse, caused a fatality. The car was towed to a toyota dealership that confirmed the issue was due to the work performed during the recall on the car. The oil light flashed a few times then shut off and then a few seconds later the engine died.

Filed May 21, 2023 · Engine · OR

Vehicle suffered engine failure in line with previous recalled, and subsequently repaired parts. Both Toyota & Subaru have refused to repair. Vehicle is under 100,000 miles.

Filed Jan 18, 2023 · Engine · NJ

Engine failure. My safety is compromised by car leaving me stranded at an unpreditable time. Serviced center fixed vehicle twice unsuccecfully because different engine brand but joint partnership. No warning lamps were present before or after failure of engine.

Filed May 15, 2022 · Engine · CA

Was going down the road. To a fast food place. As soon as I turned. A pop happens and the whole car started to shake. All the maintenance was done every 6k miles. Got the car at 32k miles Went to Toyota. And they called and said it was engine failure “mechanical failure” then they called back and said there was no coolant. In my eyes I feel it’s to cover their end to not do a recall.

Filed Apr 18, 2022 · Engine, Transmission · CA

2013 SCION FR-S Valve spring recall notice was received in the mail. Recalled valve spring replacement caused engine to seize twice. The first time the engine seized Tustin Toyota admitted fault, noting issue was from recall fix and repaired the engine at no cost. The second time the engine seized Toyota denied responsibility and wanted to charge $5000

Filed Feb 3, 2022 · Engine, Transmission · NE

After completing the valve spring recall I got my car back and not 200 miles later the engine started to have rod knock. The Toyota dealership told me that there was now metal in my oil pan and I would need a new engine. This is not a unique issue, it has been happening to hundreds of other cars going through this exact recall, for years now.

Filed Aug 8, 2021 · Engine · NJ

I was driving 80 mph in the inner lane of a multi lane highway. Out of no where with no warning lights or sounds the car just lost all power, the steering felt like it locked and the car fell on it's face. I was almost hit by two different cars trying to get over to the shoulder and there was white smoke pouring out of the exhaust making cars behind me swerve because they couldn't see. Had it towed to the Toyota dealership and they told me that basically the engine blew and that they have seen this on other Scion model years and those are recalled but mine isn't recalled

Filed Aug 1, 2021 · Engine · CA

Toyota of El Cajon performed the J02 recall for engine valve springs on August 13, 2020 at 98, 448 mileage. Toyota of El Cajon performed service oil/filter change, coolant change, and multipoint inspection June 2021 (work order 356309). The engine of my 2013 Scion FR-S malfunctioned with a rod knock on July 13, 2021 at 105k mileage, eleven months after J02 recall performed. There were no warnings lamps, oil lights, or any messages prior to failure. The only symptom was the engine rod knock when the car starts. Toyota of El Cajon technician and shop floorman do not know the cause, yet they attempt to deny that this issue relates to the J02 recall. They said it would cost a "couple thousand" to take apart the engine to investigate the cause. They said it would be $9k out of my pocket to replace the short block and would be "terribly expensive". I towed my unfixed vehicle home through my insurance. Vehicle has not been inspected by manufacturer, police, insurance or others. I am contacting Toyota Corporate to create claim #. Engine failure after J02 recall is a well-known issue. There are several other cases of this happening and a Class Action lawsuit due to workmanship error and sealant. This issue should be fixed by the dealership/manufacturer without cost to consumer. The safety, reliability and reputation of the vehicle depends on it. Do the right thing!

Filed Jul 28, 2021 · Engine · TN

I was driving down the road and felt the car lose power. Shortly, after the traction control and check engine light came on. I pulled over and a I slowed the engine died on me. It took several tries and it finally started and I made it home going about 45. The next day I went to town and as I pulled into a parking lot the engine completely died again. I went to the parts store right next door and the code read can shaft sensor fault. I then slowly drove to a family members house and where we replaced those sensors. This didn't fix anything. I then took it too my mechanic who proceeded to tell me I needed a new engine. There were multiple codes showing with his code reader. I only remember low oil pressure but the oil was full. Tried to drive it back to family members (less than 2 miles)but it didn't make it and I had to have it towed home.i had the valve spring recall repaired in the summer of 2020. My car has 103,000 miles and has had every oil change and had a tune up when I took it to the dealership for the recall.