2008 Scion XD suspension problems

Filed Sep 26, 2023 · Suspension · CT

The rear axel beam on the vehicle cracked on the drivers side. It separated at a weld and caused the entire wheel assemble to lean inward (extreme negative camber) and rub against the wheel well. Fortunately I was off the highway when the incident occurred and barely made it safely to my work place. If this had happened at a greater speed I fear for what may have happened to myself and others. It is UNKNOWN if this problem has been reproduced in other circumstances. It has not been inspected by the manufacturer or police. It was inspected by an independent service provider (mechanic). It is available for additional inspection if needed. There was no warning, message or any other symptoms prior to the issue occurring.

Filed Aug 28, 2020 · Suspension · 140,000 miles · OH

Noticed right rear tire was leaning inward. Found the rear axle assembly cracked. We then had it welded and checked the other side. Nothing was visible, but was informed that assembly could be rusting from inside out. Several weeks later, while traveling the highway, car started making noise and had a hot tire smell. Pulled over and left rear tire had leaned in and cut the tire all the way around. Left side had also cracked. We feel toyota should replace the entire rear of our car.

Filed Aug 24, 2016 · Suspension · 101,000 miles · OK

Right front clunk noise when going over bumps. Wheel remove and suspension inspected. Inspection revealed lower control arm bushing and bolt failure.

Filed Apr 27, 2016 · Fuel system, Suspension · 190,000 miles · TX

The suspension just suddenly died on my car. Knowing a bit about cars I would say my axel boots have gi c en out.

Filed Nov 5, 2015 · Engine, Suspension · 116,000 miles · TX

Tl* the contact owns a 2008 toyota scion xd. While driving at approximately 40 MPH, the bearing to the water pump fractured and caused the drive belt to fracture. In addition, the engine stalled. The vehicle was not able to restart. The vehicle was towed to a dealer where it was diagnosed that the water pump bearing failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The VIN was not provided. The approximate failure mileage was 116,000.

Filed Jul 25, 2015 · Suspension · WA

Purchased car used from dealership in march 2013 with 38,900 miles. Water pump replaced at 43,739. January 2015 engine replaced by dealer due to oil loss at 55,285 miles. Installed front brakes late june 2015 at 58,652. Mid july 2015 experience clunking sounds coming from driver's side upon acceleration. Clutch feels "loose." independent mechanic installs bolt and nut on motor mount. Problem continued over weekend. Mechanic said driver's side control arm is loose and needs replacement. Took car to dealer who says new motor mount is being ordered, despite newness of engine and no evidence of cracking. They deny control arm needs replacement. Vehicle feels unsafe to drive in city or freeway.

Filed Feb 6, 2015 · Suspension · 125,178 miles · NY

I had been hearing clunking noise from right front wheel for a few weeks, that seemed to be getting louder over time. Most prominent during braking or hitting potholes. Father looked at wheel while I backed out of driveway and noticed wheel shifting forward/backward within the wheel well about an inch when starting and stopping. Took vehicle to local tire shop and was told bold attaching lower control arm to body had corroded and broken off. Suggested I take car to dealer for repair, and mentioned there was a tsb issued for this problem that extended the warranty to 7 years/100,000 miles. Dealer repaired vehicle at my cost ($422), since the warranty has expired (mileage). I believe this part should last the life of the vehicle. Luckily my father noticed the wheel movement or the wheel may have come off at highway speed.

Filed May 20, 2013 · Brakes, Suspension · 36,000 miles · NJ · crash

I don't know what went wrong but I was on the way back from work and for some reason as I began to try and break my car maneuvered in a strange way I hit a pothole and the car swerved into the wall. Now the model is having all sorts of recalls and issues. I have received three letters regarding safety hazards in my car.

Filed May 8, 2013 · Steering, Suspension · 122,210 miles · IN

While driving on any ordinary day my car began making loud noises in the front and made the car feel as though it's jerking when I brake. My husband looked under the car and said he could see a bolt that looks rusty and "the top is gone." I took my car to the toyota dealership and they confirmed that the #2 control arm bolt head was broken from the left front to lower sub frame. After looking for the part online my search results were mainly other scion owners who were experiencing the same thing unfortunately.

Filed Apr 22, 2013 · Steering, Suspension · 53,000 miles · NY

The front lower control arm on 2007-present toyota yaris and 2008-present scion xd have a design flaw. The #2 bolt rusts badly on some vehicle starting from as early as 20000 miles, and some even snaps off and causes the car to lose control while driving. Toyota have issued a tsb to replace the whole control arm with a new design, yet have only extended the warranty to the #2 bolt. The arms are still rusted, and the flawed design still causes the #2 bolt to rust prematurely. This is a serious safety defect and toyota still refuses to issue a recall.