1996 Spartan Diamond problems

What is wrong

Vehicle description: fire trucks. The cab tilt system contains a 12 volt electrical solenoid assembly as an accessory to the cab tilt electric motor/hydraulic pump assembly. Rain, snow, salt spray or other corrosive environment can corrode the solenoid or "bridge" the energizing coil wire terminal causing the cab tilt system to operate uncontrollably.

Risk

This could cause the cab tilt system to actuate without control, increasing the risk of personal injury.

Remedy

Dealers will install a hermetically sealed solenoid assembly.

Recall number 99V010000 · Recall details

What is wrong

Vehicle description: fire trucks. If the driver accelerates in a turn above 20 MPH forward speed, the lock pin is actuated and causes the axle to resist returning to the straight ahead position after the turn is completed because the lock pin is binding on the clamp plate surface.

Risk

Engaging the lock pin in the lcmp plate hole at high forward speeds causes excessive wear in the lock pin and/or the clamp plate hole. Lane changes and other vehicle maneuvers will greatly increase contact frequency and causes wear, increasing the risk of loss of vehicle control.

Remedy

Dealers will replace the tag axles on these fire trucks.

Recall number 98V286000 · Recall details

What is wrong

Vehicle description: fire trucks with occupant side entry doors. A difficulty in latching the side entry doors to the full closed position, and/or, the doors may release to the secondary latch position. Also loose rivets can cause the latch control mechanism to bind not allowing the door to latch properly when shut.

Risk

The cab door could unlatch from its primary latch while the vehicle is in motion, allowing the door to open unassisted to the secondary latch position.

Remedy

Dealers will remove and replace the latch and actuator on the doors.

Recall number 98V077000 · Recall details