Spartan MG recalls

What is wrong

Spartan is recalling certain model year 2012 k2 and mg chassis manufactured from december 15, 2011, through january 31, 2012, and equipped with 3030 brake chambers. These vehicles fail to comply with the requirements of federal motor vehicle safety standard number 121, “air brake systems” because they do not meet the park brake and draw bar requirements.

Risk

The park brake may not hold the vehicle in place and if the vehicle moves, injury or property damage could occur without warning.

Remedy

Spartan will notify owners and install improved brake chambers, free of charge. The safety recall began on april 19, 2012. Owners may contact spartan at 1‑517‑543‑6400.

Recall number 12V125000 · Recall details

What is wrong

Spartan is recalling certain model year 2010 and 2011 incomplete recreational vehicle chassis manufactured from january 4, 2010, through january 26, 2011, equipped with an electronic control module, part number 2791-nn2e-001 or 2791-nn2e-002. When the brake is applied, the cruise control may not cancel. Additionally, these vehicles may exhibit an inadvertent, moderate increase in vehicle speed until the vehicles reaches its governed speed after the vehicle's cruise control is set.

Risk

If the driver attempts to cancel the cruise control by applying the brake or if the vehicle speed increases and the driver is unaware, they may have reduced control of the vehicle, increasing the risk of a crash.

Remedy

Spartan will notify owners and repair the vehicles free of charge. The safety recall began on january 9, 2012. Owners may contact spartan at 1‑517‑543‑6400.

Recall number 11V516000 · Recall details

What is wrong

Spartan is recalling 484 model years 2008-2010 adv, bey, fur, glc, gld, k2, k3, mg, mm, mtr, and nvs fire truck, ambulance, and motor home chassis manufactured between july 1 and december 16, 2008 equipped with certain haldex quick release valves (qrv). The rubber diaphragm inside the qrv may experience delamination resulting in significant levels of air pressure leakage past and/or through the diaphragm, or the development of a bubble in the diaphragm which may trap air pressure in the valve and not allow the service brakes to release.

Risk

Malfunction of the air brake system could result in a vehicle crash.

Remedy

Each vehicle manufacturer will provide a remedy plan and notification schedule. The affected vehicles will be repaired without charge to the owners. Owners may contact their vehicle manufacturer or spartan chassis toll-free at 1‑800‑543‑4277.

Recall number 09V184000 · Recall details

What is wrong

Spartan is recalling 2,621 my 2005-2009 k2, my 2006-2009 mg, and my 2007-2009 mm motor home chassis equipped with putnam hitches. Certain trailer hitches may fracture which could result in the loss of the trailer.

Risk

Suspect hitches may develop fractures and subsequent separation may occur, resulting in a vehicle crash, property damage or pedestrian harm.

Remedy

Dealers will replace the trailer hitch free of charge. The recall began on january 21, 2009. Owners may contact spartan at 1‑517‑543‑6400.

Recall number 08V567000 · Recall details

What is wrong

On certain motor home chassis, there may be a loose connection between the bus bar and a grid pad due to the pins being slightly smaller diameters after assembly. Electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shut down and/or not be capable of powering up.

Risk

Each vehicle could potentially experience a unique circumstance where one or a combination of the following conditions could occur: loss of electrical power to the engine, transmission, starting and engine cooling systems, operation of the right chassis stop/turn signal and right trailer stop/turn signal, the anti-lock brake system, auxiliary brake system, the heater elements in the air dryer, and the heater element in the water-in-fuel separator.

Remedy

The dvec bussmann box will be replaced. The recall began on january 16, 2008. Owners may contact spartan at 1‑517‑543‑6400.

Recall number 07V363000 · Recall details

What is wrong

On certain motor homes, the bussman box was incorrectly soldered and could fail.

Risk

Electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shutdown and/or not be capable of powering up. One or a combination of the following conditions may occur: loss of electrical power to the engine, transmission starting and engine cooling systems, in the operation of the right chassis stop/turn signal and right trailer stop/turn signal, antilock brake system (ABS), auxiliary brake system, heater elements in the air dryer, and/or the heater element in the water in-fuel separator, increasing the risk of a crash.

Remedy

Dealers will replace the defective components. The recall began on april 10, 2006. Owners may contact spartan at 1‑517‑543‑6400.

Recall number 06V094000 · Recall details

What is wrong

On certain motor homes, the brake lights become inoperable when the fuse is blown upon activation of the auxiliary brake. At the time, the auxiliary brake, the coolant level sensor, and auxiliary brake 'brake light activation' cease to function, and the 'check' engine light illuminates.

Risk

A loss of brake lights could result in a crash.

Remedy

Dealers will relocate and control the brake light power source free of charge. The recall began on february 27, 2006. Owners may contact spartan at 1‑800‑543‑4277, option 1.

Recall number 06V035000 · Recall details

What is wrong

On certain motor homes equipped with ngi air pressure gauges located on the dash panel is giving a false reading.

Risk

This may cause the park brake to engage without warning, thus throwing the passenger forward, creating the potential for injury to occupants.

Remedy

Dealers will use a jumper harness containing a 33 ohm resistor which will shift the resistance curve of the air pressure sender to match the alarm point of the current gauge. The recall began on june 3, 2005. Owners may contact spartan at 517‑543‑6400.

Recall number 05V146000 · Recall details

What is wrong

On certain motor homes, the slack adjusters in the front axles were not adjusted properly.

Risk

The driver may experience a feeling of softening in the braking function. Reduction in brake force which could cause a crash.

Remedy

Dealers will adjust the front axle brake free of charge. The recall began on february 2, 2005. Owners may contact spartan at 1‑800‑543‑4277, option 1.

Recall number 05V016000 · Recall details