2006 Startrans Senator problems

What is wrong

Supreme Corporation (Supreme) is recalling certain model year 2006-2012 Startrans Trolley, Sentinel, Senator HD, Senator, Candidate, C2, S2, PS2, and President transit buses equipped with Ricon manufactured wheelchair lifts which have an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover.

Risk

The cable may contact the power lug at the base of the wheel chair lift causing a short circuit that could result in a fire.

Remedy

Ricon will be conducting this recall on behalf of Supreme. Ricon will notify the affected owners and will provide a supplemental cover kit and instructions, free of charge. The recall began on March 8, 2013. Owners may contact Supreme at 1‑800‑642‑4889 or Ricon at 1‑818‑267‑3000.

Recall number 13V067000 · Recall details

What is wrong

Startrans is recalling certain model year 2006 through 2010 transit buses equipped with carrier genv em-1 evaporator units. Due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.

Risk

If sufficient arcing occurs, the fuse holder may melt, and a vehicle fire may occur.

Remedy

Startrans will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. This service will be performed free of charge. The safety recall began on april 18, 2011. (see carrier's recall campaign 11e-003.) owners may contact carrier at 1‑800‑793‑4741 or startrans at 1- 877‑258‑1391.

Recall number 11V227000 · Recall details

What is wrong

Startrans is recalling certain model year 2006 and 2007 candidate, candidate ii, senator hd, trolley, president, senator, and senator ii transit buses equipped with trans/air ta73 evaporators. The evaporator utilizes a power resistor to regulate blower speed. Should a short occur in the "low or medium speed" circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse.

Risk

This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. The overheating can result in a fire.

Remedy

Trans/air, in cooperation with startrans, will install a thermal shutdown device in series with the speed resistors. This service will be performed free of charge. The safety recall began on january 11, 2011. Owners may contact trans/air warranty and service center at 1‑800‑673‑2446.

Recall number 10V562000 · Recall details

What is wrong

Startrans is recalling certain model year 2001 through 2009 transit buses manufactured between october 15, 2001 and september 24, 2009, equipped with luminator horizon LED side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.

Risk

A short could occur, possibly causing smoke and fire.

Remedy

Startrans will notify owners and the buses will be repaired by either startrans or luminator free of charge. Please see luminator's defect report 09e-054. The safety recall is expected to begin during november 2009. Owners may contact luminator at 1‑972‑516‑3033 or startrans at 1‑574‑642‑0811.

Recall number 09V409000 · Recall details

What is wrong

Startrans is recalling 4,409 my 2004-2008 senator and candidate shuttle buses built on ford or chevrolet chassis and equipped with ricon platform style wheelchair lifts. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations in motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.

Risk

The user of the lift could be injured should the lift move unintentionally.

Remedy

Startrans is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). Owners may contact ricon at 1‑818‑267‑3000 or startrans at 877‑258‑1392.

Recall number 08V626000 · Recall details

What is wrong

Startrans is recalling 4,409 my 2004-2008 senator and candidate shuttle buses built on ford or chevrolet chassis and equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift.

Risk

A lift occupant can be injured should the lift begin to stow unintentionally.

Remedy

Startrans is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). Owners may contact ricon at 1‑818‑267‑3000 or startrans at 877‑258‑1392.

Recall number 08V627000 · Recall details