The worst 1999 Sterling L-Line problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
Recalls 5
Suspension: front: hub
- What is wrong
- On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
- Risk
- Seizure of the bearings can cause wheel separation or wheel end fire.
- Remedy
- Dealers will replace both front hubs. Owner notification is expected to begin on or before september 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 03V112000 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- Vehicle description: trucks, school bus and motor home chassis, and transit buses equipped with tie rod assemblies manufactured by trw. The suspect tie rods contain 24-dl model ball sockets. Certain of the tie rod ball-socket bearings have a below-specification case depth and/or hardness, which can lead to premature wear of the socket.
- Risk
- If this condition occurs, the driver can lose partial control of the right front wheel, possibly resulting in a crash.
- Remedy
- Dealers will replace the defective ball sockets and/or drag links. Owner notification began may 22, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712 or trw customer service at 1‑866‑280‑3287.
Recall number 01V044002 · Recall details
Exterior lighting: turn signal: switch
- What is wrong
- Vehicle description: heavy duty trucks. A loss of the turn signal function can occur due to a turn signal flasher that is not compatible with the turn signal switches that allow the brake lights to override the hazard warning lights. If the hazard warning lights are on and the brake lights are activated, the turn signal flasher senses an overload condition and becomes disabled until all electric loads are removed.
- Risk
- Following drivers may not be aware of the truck's turning intentions increasing the risk of a crash.
- Remedy
- Dealers will install a turn signal flasher that is compatible with turn signal switches that allow the brake lights to override the hazard warning lights.
Recall number 00V397000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Vehicle description: heavy duty truck models with 111", 113", and 122" cabs. The fuel tank steps can develop fatigue cracks due to excessive overhang.
- Risk
- The steps could fail.
- Remedy
- Dealers will inspect the step assembly for overhang and add an end support of the trailing edge of the fuel tank step, if necessary. Owner notification began november 2, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 00V080000 · Recall details
Electrical system: ignition: module
- What is wrong
- Vehicle description: heavy duty trucks equipped with caterpillar engines and eaton autoshift transmissions. The engines can stall because of software problems.
- Risk
- Increased steering effort can occur.
- Remedy
- Caterpillar is conducting the owner notification and remedy of this recall. Dealers will update these engines with software changes.
Recall number 99V181002 · Recall details
Technical service bulletins for the 1999 Sterling L-Line 9
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Sbh5419 Wiring Changeover
- Sp54020 Strobe and Beacon Lights
- Sterling: aftermarket hood with pivot bracket mounting modification changes.
- Freightliner: procedure to replace the power steering pump with a new part
- Daimler trucks: there are new cgi bellows, because the current ones are prone to failure
- Sterling truck: airliner suspension six piece bolted service crossmember
- Sterling truck: charge air cooler tube and convoluted hose replacement
- Sterling: some barksdale height control valves have been returned for warranty because four bolts in the...
- This modification consists of installing additional fasteners to mount the grille to thehood and replacing...
Compare the 1999 Sterling L-Line
Other model years
Questions about the 1999 Sterling L-Line
Is the 1999 Sterling L-Line reliable?
Owners have filed 0 complaints about the 1999 Sterling L-Line.
What is the most common problem with the 1999 Sterling L-Line?
There are not enough complaints to tell.
How many recalls does the 1999 Sterling L-Line have?
5 recalls, covering suspension, steering and exterior lighting.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Sterling L-Line?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history