Cylinder #4 exhaust vale failure in july of 2004. Subaru dealer prestige imports pulled head and replaced valve. They insisted the cause was "bad gasoline." april 2005 car is found to have high level of co2 in cooling system. Subaru dealer prestige imports refuses to do a leak down test to determine which head gasket has failed. Pulls both heads at a cost of close to $3,000. Refused to acknowledge that they removed the head in july 2004 to replace the valve and refuse to acknowledge that this may have been the cause of the july 2005 failure. Told me "we've seen this before." refused to call subaru USA because "they would just laugh at us." in a meeting with prestige imports gm jim borreli he indicated that this is a common problem and promised to contact subaru USA he never did and would not return my phone calls. Subaru USA has been extremely unhelpful and claims that they have nothing to do with authorized dealer repairs or issues with head gaskets on 2.5 l type 1 engines. This is an very common problem apparently. Almost every auto mechanic in america is familiar with it. On the federal safety agency complain site I counted at least 18 head gasket related complaints. A search of the web brings up hundreds if not thousands more., why has the federal safety agency ignored these problems and not acted in the best interest of costumers?
1998 Subaru Outback engine complaints
Page 2 of 2: complaints 11 to 40 of 40, newest first, as owners wrote them.
While driving vehicle overheated. This happened three times. When taken to get serviced the third time it was determined that it was due to the head gasket.*ak
Head gasket failure in subaru legacy outback 1998. Engine overheated which lead to lead to smoke coming out under the hood and subsequent warping of engine heads. I hard to replace gasket heads but I am told there is no guarantee this would not happen again since there is an apparent design flaw in the 2.5l engines.
Legacy outback with 2.5 l engine began to overheat with coolant boiling over into resevoir. The car was taken to repair shop. They replaced thermostat, tested for hydrocarbons in system, pressured tested cap and system and flushed radiator. Car still overheated and was returned to repair shop and tested for hydrocarbons in the antifreeze with negative results. No problem was identified. Engine continued to overheat and was taken into repair shop while the pointer was off the top of the temperature gauge. This time hydrocarbons were identified in the coolant and problem was identified as a blown gasket. Manager reported that the week before another subaru owner had the same problem with same difficulty in identifying the cause. Repairs cost $1,400. Had a similiar report for another subaru owner but work was done with pressure on dealer after initial refusal.
Engine overheating started 10 months ago on long trips only. Overheating was common when engine was under heavier than normal loads for long periods of time(climbing hilss, etc.). Fluid in radiator was eventually deplented leading to sharp rise in engine temperature. Lately this has been worse as only 30 miles of normal driving will cause the same symptoms. The fault turned out to be a head gasket failure on subaru r2.5l type 1 engines. The coolant was being forced out of the radiator by the slow leak of exhaust gases in the coolant around the radiator. This vechicle has been serviced since new by only the local subaru dealer. A search on the internet for subaru 2.5l engines 1996-1999 (legacy) turned up multiple hits for owners with this same problem. Failure is as low as 40k miles to over 100k for the same problem. This multi-layer gasket for the type 1 engine has be redesigned 6 times, leading one to surmise that the head gaskets are defective. The type2 engine also has this failure but this has been intercepted by subaru of america by adding a "lubricant" to the coolant, ie: block sealer. This engine should have been recalled to replace the multiple defects which subaru will only do on type 2 engines and only if the owner knows to ask for the "secret waranty". Given that there is no other choice, I plan to pull the engine myself and fix the problem. The dealer wants over $2k to do the same work.
Complaint received via e-mail. The temperature gauge was in the hot range while driving. The cooling system checked out okay, but was told that the car was low on coolant. The consumer refilled coolant, went out of country, and 2 weeks later encountered the same problem. A month later, while driving, coolant leaked out again, and the head gasket was bad. This was a common problem with these vehicles. *ak *sc
Took my subaru to dealer for 60,000 mile check. He advised me that my head gasket was about to fail and needed replacement. He also informed me that failure of the head gasket in 1998 outbacks was common. This repair is very costly (about $1500), and failing to make it could cause catastrophic damage to the engine.
1998 subaru outback showed signs of overheating as temperature gauge rose up past the usual midline and cold air inside car from air conditioner suddenly got warmer. I pulled over and coolant was over flowing from overflow reservoir through the cap. I drove with the heater on full power and made it to a repair facility and remove the thermostat which had seized. Replaced the thermostat and radiator cap ($30) and everything was fine until four months later (march 2004) when car showed signs of over heating again (rise in inside air conditioned air temperature from cold to warm). Took car to rallysport engineering in costa mesa, ca and mechanic could not find symptoms of head gasket failure although this is what he thought it was. He added stop leak, new thermostat, and new coolant ($150 parts/labor) and the problem was resolved although the temperature gauge reading was a little higher than it was when using original equipment (prior to november). Now, july 2004, car has almost overheated again. I took the car to south coast subaru in costa mesa, ca and they stated that it was a head gasket failure and that they could smell the exhaust fumes through the overflow reservoir. The estimate to fix the repair will be $1500 parts and labor.
My car overheated and died on the highway. It was determined that the head gasket had failed -- it was replaced, and the engine was tuned in associated ways. One month later, the car overheated again, with coolant leaking out of the engine. Once again the head gasket was replaced, as well as the water pump, which the dealer said may have been the original problem. I have had the car back for one week now, and it's working fine. Each time the car overheated, it was soon after I turned on the A/C (and the A/C didn't work well either time -- I.e., warm air came out of the vents). My A/C is working okay, now.
Catastrophic failure of a major engine component which is considerably outside the expected statistical failure rate(based on my research of complaints by other purchasers of this model subaru automobile), resulting in significant costs to repair. At approximately 56000 miles the head gaskets on my 1998 subaru outback with the 2.5l engine failed.the cost to repair was $ 1880.00. I contacted subaru in an effort to get them to absorb at least part of the cost since the car was well within the mileage warranty period, but was slightly outside the time warranty.their response was sorry tough luck. I indicated to subaru that a component of this nature with such a high failure rate, was obviously due to a significant design or manufacturing defect.their response was, again, they were not goint to do anything about it. Someone needs to put pressure on subaru to make this a recall item.
The headgasket burned through. Replaced headgasket, had heads milled. Now exactly 1 1/2 years later in april 2003 the car is overheating, everyone says the car should not be doing that, but it is. It is alot of money for a car that is only 5 yrs. Old and having major engine problems.
Appears I have a blown head gasket on my 1998 2.5l outback. Coolant contains oil , coolant reservoir fills up rapidly with coolant when driven on the highway. Coolant never returns to the radiator after cooling down.
Car overheated. Towed to garage. They replaced thermostat and tested. Ran ok for about 20 miles. Overheated again. Towed to garage. Now the diagnosis is that I need a new head gasket. This car has less than 90,000 miles and has been maintained flawlessly.
While driving at 70 MPH, and with no warning vehicle stalled, causing the driver to lose control. Owner had contacted dealership on four separate occasions, but problem still occurring.
Blown head gasket at 105,000 miles. My research indicates that this is a very common failure for this engine/model year. It cost me $3400 for a new short block/labor to effect repairs.
I own a 1998 subaru outback.: VIN #[xxx]. On the date below, the timing belt on my car, which had 53 thousand miles on it at the time, broke and resulted in a catastrophic engine failure. This forced me to buy a used engine. Fortunately, I was only driving at 20 MPH and was able to safely pull over. Had this happened at interstate highway speed the result might have been very different. Subaru's own maintenance schedule says that the timing belt should be inspected at 60 thousand miles. I've been in touch with the company but they don't seem to be very responsive or forthcoming. Thank you for your attention to this matter.*ak information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
My subaru outback has dripped a little oil from the front ever since I bought the car new and had a burning smell. I took it back 2 times in the first year but they didn't do anything except tell me it was transit paint burning off. I took it back when I was 1000 miles out of my warranty because it was worse and smelled burning more. They told me it was the oil pump seal but wouldn't cover it under warranty. They said if I had been having regular work done through the dealer they might have been able to work something out. Since then it is worse and the burning smell is very bad. I know of 2 other subaru legacy's with the same problem and a $500 to $700 fix. I was also told by a mechanic that there have been some fires in subarus due to this problem and dripping on the catalytic convertor.
Consumer states that while driving and with no warning vehicle will stall ,and it will be hard for the consumer to control the vehicle. Dealer notified.
Engine overheats. Two subaru dealer service centers said they could not find the problem, and started an seemingly endless replacement of thermostats, and even the radiator. The problem continues, and now that I am over 60k miles, with my warranty expired, they suddenly say it is a problem with the head gasket, which will probably cost over $2,000 to replace. I now find out that there are numerous problems with the head gaskets of 1994-1998 subarus, but there has never been a recall. Why?
1998 subaru outback - blown head gasket, resulted in over heating. My mechanic estimates $2500 (assuming there is no other damage to the engine). We are also checking prices for used engines to possibly replace the existing engine. Mileage was approximately 129000 miles.
The engine over heated, and the dealer replaced the thermostat and water pump, however the problem continued, and the entire engine had to be replaced.*ak also the brake light and marker lights were replaced.
Head gasket on my '98 outback failed. Dealer said not uncommon. He has 3 more waiting for head gaskets. Seems a number of head gasket failures on the subaru discussion group on edmunds.com townhall. Fortunately, mine was discovered with no engine damage. The cost of repair was $2500.00. Quite a financial drain for me. Some talk on discussion group wondering if a design problem with the 2.5 liter engine. Subaru emailed me that there is no problem with head gaskets and that all mechanical things fail with time, some sooner and some later. On the subaru discussion group, a number of the head gaskets were at low mileage. Mine was at 94,000 miles
Safety issue: seal failure causes oil to leak onto hot exhaust (fire hazard). Mr
The head gasket blew, which resulted in coolant leaking into the cylinder walls. While parked and turned off. The engine, which is a 2.5 liter, must be replaced. The 2.5 liter engine has a history of enigine failure. Has anyone made a claim? Has there been research or a recall of any kind?
Blown head gasket. Seems to be a manufacturing problem, considering the number of blown head gaskets on subaru 2.5l engines. Contact subaru mechanics to obtain unusual high numbers.
On 1/15/01 beard subaru diagnosed and repaired my engine for an oil leak. I paid $654.50 for them to remove the transmission and reseal baffle plate as well as reseal oil pump, questionable cam seals (referring to paperwork from dealer). On 3/23/01 while driving on the highway, check engine light went on and simultaneously car completely died. Beard subaru diagnosed engine seized due to drop in pressure w/in engine. Upon several contacts w/ subaru of america, they have offered to pay 50% to rebuild engine, which has been verbally estimated at $2,500. Beard subaru unable to explain cause of engine seize, but denies it is related to recent repair of engine leak. Subaru of america requires me to accept or deny offer to of "courtesy for my patronage" 50% by wed. 4/4/01. I bought my vehicle brand new at beard subaru and have maintained it faithfully. I question a defect within my vehicle, or a direct correlation to the recent work conducted by beard subaru. I requested written documentation. They diagnosed my vehicle on 3/27/01. On 3/30/01 I received a message from beard subaru they would have to get back to me "next week". They are aware I begin a new job on 4/2/01 requiring me to rent a vehicle until my situation is resolved. Subaru of america has offered to pay 50% car rental fee for 5 days. Is there a way to have a second opinion before I am required to respond to subaru of america's deadline by 4/4/01? I am weary to accept an agreement that no one has provided a second opinion, they have failed to provide a written estimate of what I will be required to pay "after just paying $654.50 for an engine leak" and I am being told I must respond to the offer by 4/4/01 or I will not be assisted.
Power steering rack was leaking causing odor in vents. Nlm
Egr solonoid failed.
Exhaust system leaks fumes into the ventillation system.
The consumer has been experiencing problems with exhaust pumps. Whe vehicle is parked or when vehicle is started up, consumert can smell a sulphur smell. The manufacturer has yet to be contacted.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1998 Subaru Outback?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history