2005 Subaru Outback: brake failure

Filed Oct 27, 2023 · Brakes · CT

Vehicle brakes failed while driving, the brake pedal went to the floor and almost caused a serious car accident. Yes, vehicle and brake lines are available for inspection upon request. My safety, the safety of others and more importantly my life and the lives of others were severely threatened because of the major break failure that occurred. It is terrifying to think that I was unknowingly driving around this vehicle with an imminent accident that could happen anytime, without any warning, which could have killed me. After taking pictures of my brake lines, recording videos and doing some quick research, I called a local to inspect my brake lines. I told them the scenario that I experienced and reported to them that my brake lines were covered in rust. I told them that I found out my vehicle had a recall remedy done on the brake lines in 2017, which is before I owned the vehicle. I told them that the rust and corrosion was in the same spots that were supposed to be fixed in the recall repair and that I am positive that the repair was done incorrectly or the repair was not done at all. I requested they take pictures of the brake lines and show them to the manufacturer or use the photos I took but they ensured they would take care of all of that. Called for update a week later and was unable to get in contact with anyone. I waited over a month before one of my calls was finally answered. I was told they still hadn’t looked at my vehicle yet. Having no vehicle had a very negative impact towards my job because I had no transportation for so long. I called back a few days later and was told that they would not repair my vehicle. My vehicle was not inspected by the police or insurance because I wasn’t in an accident. I was less then a minute from home when this life threatening incident occurred and thankfully was able to pull the car into my driveway. No warning lamps, no messages and no symptoms of the problem were present prior to this life threatening occurrence.

Filed Dec 12, 2022 · Brakes · MA

Vehicle experienced sudden complete brake failure while driving due to a rupture in brake system in the exact area of a known defect / recalls the federal safety agency SUBARU RECALL WQG-43 and WQK-47 (both completed) which had been issued to inspect and repair the defect. Safety of driver / occupants were immediately put at grave risk due to inability to slow or stop vehicle. Car was traveling on a two way high traffic road at a speed of approximately 30+MPH. I was able to stop slowly using the emergency hand brake though only after attempting to pump the brakes which became absolutely unresponsive (this took approximately 7-10 seconds while pumping the Brake pedal). It was pure luck that there was no one directly in front of me at the time. If anything had been in front of me my choices would have been: A) swerve to the right into parked cars B) swerve left into oncoming traffic or C) run into or hit whatever was in front of me. None of those would have been acceptable options and all could have potentially injured or killed occupants within the vehicle not to mention the potential to have injured or killed any other parties involved in a collision. I am frankly amazed that a brake system defect of this nature was not fully repaired and or replaced using a non-defective design and parts. I view any application of a aerosol surface treatment as temporary & superficial at best. It's only a matter of time for the brakes to fail on every 2005-2009 Subaru that has this defect. The risks to vehicle occupants and any other individuals involved in potential accidents are simply too high.Vehicle is currently at IRA Subaru in Danvers Massachusetts and has been inspected by them confirming the problem with photo documentation. There was no other prior warning before the sudden complete brake system failure. It is unclear if the Vehicle or component has been inspected by the manufacturer. No other party has inspected the vehicle. Vehicle is available for inspection upon request. Mileage: 77,884K

Filed Sep 26, 2022 · Brakes · IA

puddle of brake fluid under car no brakes after looking at it 4way joint connector at rear of car is leaking . online says recall was done but specifications for the repair are ludacris to spray wax over corrosion ! the lines are already damaged and that would just seal the corrosion in and continue to deteriorate! that recall in itself is a safety hazard and needs to be reevaluated!

Filed May 12, 2020 · Brakes · 152,730 miles · MA

I was driving home from work on the highway when I pressed the brake pedal as normal to slow down and the pedal went soft and I had no brakes. I was able to make it home using the emergency brake to stop. Upon inspection the lines were leaking from the same place repaired in recall wqk47, the federal safety agency campaign 14v311000. Visual inspection could confirm that the initial recall wqk47 repair completely failed causing serious danger to my life. I researched complaints about wqk47 recall and came to the conclusion that I am not the only subaru owner with this serious life threatening issue. I called my dealership and even spoke with corporate subaru and both said since recall was performed once repair/replacement will cost me. I cannot fathom why, if the first recall repair failed resulting in a life threatening situation, subaru wouldn't want to immediately fix the problem and ensure all their customers who had this recall performed are still safe and functioning to proper standards.

Filed Jan 31, 2019 · Brakes · 192,000 miles · NC

Brake system failure due to brake line corrosion ; driving vehicle and brakes failed, leaving me without ability to stop. Luckily I was on a hardly-traveled road and getting home was uphill.

Filed Nov 14, 2017 · Brakes · 170,000 miles · NY

4way connector brake line leaking causing no brakes. Could of got in serious accident hazzard to drive called about recall on this but the said my car VIN number was not listed and we're very rude and she hung up on me. Had to put car in nutral to slow diwn

Filed May 13, 2010 · Acceleration, Airbags · PA · crash · fire · 4 injuries

Tl*the contact owned a 2005 subaru outback. The contact stated that the brakes failed to engage and the vehicle crashed into a tree and caught fire. The air bags did not deploy. Four people were injured and police and fire reports were filed. A month prior to the accident, the vehicle was inspected and no failures were found. The vehicle was inspected after the crash and it was discovered that the tumbler system was defective. The VIN was unavailable at the time of the complaint. The current and failure mileages were unknown. Updated 7/16/10 *cn updated 07/27/10