Subaru Outback sunroof shattered problems

Filed Jul 27, 2026 · AK

On May 16, 2026, I was driving approximately 65 mph northbound on the Glenn Highway near Anchorage, Alaska, in my 2025 Subaru Outback Wilderness. Traffic was light, and there were no vehicles within approximately 150 yards of my vehicle. Without warning, my wife and I heard a loud bang followed immediately by the sound of rattling glass. The factory-installed moonroof suddenly shattered while the vehicle was traveling at highway speed. I did not observe any object strike the vehicle, and there were no nearby vehicles or adverse weather conditions that would explain the failure. Fortunately, the interior moonroof shade was closed. Had it been open, shattered glass could have fallen directly onto the driver and passenger, potentially causing eye injuries, distraction, or loss of vehicle control while traveling at highway speed. After safely pulling over, I documented the damage with photographs and contacted Continental Subaru of Anchorage two days later to schedule a warranty inspection. When I brought the vehicle to the dealership on May 28, the warranty claim was dismissed before any inspection findings were explained to me. I was ultimately told that Subaru does not cover shattered moonroof glass under warranty and that only cracked glass may be covered. I was directed to file an insurance claim instead. I asked the dealership to identify evidence of an external impact that would explain the failure, but no impact point or other physical evidence was shown to me. I was required to pay for replacement of the moonroof despite the vehicle having only approximately 30,000 miles. I am submitting this report because a spontaneous failure of a factory-installed moonroof while driving at highway speed presents a significant safety hazard. I am also aware of numerous publicly reported incidents involving similar sudden moonroof failures in Subaru Outback vehicles, which I believe warrant further investigation.

Filed Jun 11, 2026 · OH

I have a Suburu Outback 2026.. I was driving 30 mph on a country highway in Monroe, Michigan when my sun roof tempered glass window exploded upward... it sounded like a shotgun went off in my car… the Suburu warranty claim was rejected… they determined it as “outside influence”… that caused my Sun roof window to implode… if this had happened on a highway, it may have caused a serious injury accident. Since that time, I have researched to see if other people have experienced similar incidents.. it appears that sun roof spontaneous explosions are not uncommon. This is why I am reaching out to you.

Filed May 4, 2026 · Electrical, Visibility · NC

Sunroof exploded outwards while driving.

Filed Mar 26, 2026 · Body · VA

Our sunroof exploded and shattered. It could have caused a bad accident as the speed limit is 65-70 full of cars and trucks on I-95 north. There was no warning, just a large explosion and shattered glass. Luckily our sunshade was closed so the glass was contained. It was raining and about 50 degrees.

Filed Mar 6, 2026 · CT

Driving on highway and moon roof exploded. Have nonindication of a projectile hitting glass. Did not see any cracks

Filed Jan 4, 2026 · Body · LA

We were driving down an interstate highway going 70 mph on a foggy Christmas Eve 2025 approximately 7 a.m. No cars were close around us. We had been on the road for 30 minutes or so, and it was in the 50-60 degree temperature range. Suddenly we heard what sounded like a gunshot right above our heads. We opened the sunshade under the sunroof, and saw that our sunroof had exploded and left a hole. Before this, we heard nothing strike the sunroof or the car. It seemed like a spontaneous explosion. The explosion noise is recorded on our dash cam video. I was unable to upload the video because it must not be in the correct format.

Filed Dec 29, 2025 · PA

Driving on a flat dry road with cloudy conditions we heard what sounded like a shotgun. Pulled over and found our Moonroof exploded. I have dashcam video with audio of the explosion as well as photos and video of the damage immediately after

Filed Dec 15, 2025 · UT

While driving my 2018 Subaru Outback on the freeway, the sunroof spontaneously shattered without warning. At the time of the incident, there were no nearby vehicles, road debris, or external factors that could explain the failure. This appears to be a dangerous and unexpected defect.

Filed Oct 2, 2025 · Body · MS

Sunroof exploded driving home in 90 degree sunny and clear weather. It sounded like a gun went off right over my head. It scared me so bad I jerked my steering wheel into the other lane. Thank God no one was in that lane. I had to get it replaced at Mid State Glass company. according to what I found on the internet this happens rather frequently. No notification by Subaru that this was even a possibility. I have the receipt the replaced sunroof and photos of the sunroof after it exploded.

Filed Aug 30, 2025 · Body · TX

2025 Subaru Outback was parked in the garage. The high temperature for the day was in the upper 80's. The temperature on the thermometer in the garage was 85. The car had been parked in the garage after the drive home from work for over 3 hours. I heard a noise in the garage and the sunroof had exploded outward. I had not been hit by any debris and it was not damaged. The glass was still crackling as I walked up and took a video. It looked like a miniature volcano with the upward, circular ridge of glass. It was towed to the dealership and their initial response was they did not think the factory warranty or extended warranty will cover it. I have 35,000 miles on the vehicle. Began to investigate known issues with the Subaru and discovered this has been happening to other Subaru's and manufacturer's.