Suzuki Forenza engine failure problems

Filed Mar 17, 2015 · Electrical, Steering · 91,000 miles · NJ

Tl* the contact owns a 2008 suzuki forenza. While traveling 15 MPH, the steering and the ignition seized and the vehicle stalled. The contact was unable to get the steering and ignition to release, but the brake pedal extended to the floor when the failure occurred. There was no warning prior to the failure. The vehicle was inspected by an independent mechanic. The technician diagnosed that the steering cylinder needed to be replaced. The vehicle was not repaired. The VIN was not available. The failure mileage was 91,000.

Filed Nov 6, 2014 · Acceleration, Engine · 70,000 miles · TX

I bought my 2006 suzuki forenza brand new. The engine gave out on me in 2009. I replaced the engine once. Additional to the engine problems, one day while exiting from a major highway, the car just stopped going about 45 MPH and started going about 10 MPH, while a noticeable flashing square with a blinking line comes up on the gear indicator, on the dash. I almost caused an accident. I was told it was the transmission range sensor which I've now replaced two times. Note: brand new transmission range sensors were placed and still have the same issue. When I put it from park to drive (gear), the motor jerks and feels like the motor's going to fall off. The catalytic converter has also failed to pass inspection. The A/C gave out about 2 years from the time I bought it (brand new car). It's not a reliable car, at all. Once I fix something, something else breaks. Then the paint on the door handles is chipped off, I've had two door handles break on the interior, now I hear it has electrical problems under the dash. I haven't had this issue but not looking forward to it. It constantly drains my wallet, therefore the car has been sitting in the driveway pending repairs which might not be beneficial to continue making.

Filed Aug 2, 2014 · Electrical, Engine · 89,000 miles · MO

My engine died while driving. My battery (which was replaced 7 months prior) also died. When I tried to get a jump start, the engine would run for a few moments before dying again. I had the vehicle toed to a lot and haven't been able to afford repairs, so I had it scrapped.

Filed Jun 28, 2013 · Engine · 68,391 miles · MO

January 2011 as I was driving on the highway the car lost all speed and then just stopped. I could not turn it over and once I got it to the shop they said the piston's went through the engine. They replaced the engine later in the month. June 2013 the same thing happened. Piston through the engine completely blown up and now they will not replace it because I am two months past my warranty. For some reason I thought there would be a warranty on the replaced engine. I bought this car brand new in 2006 and followed all the warranty repairs and maintenance .

Filed Mar 13, 2013 · Acceleration, Electrical · 97,000 miles · NC

My check engine light came on. I went to auto zone and was told it was the transmission sensor. After some research, we discovered this problem runs rampant on 2006 suzuki forenza models. We took it to the dealership and the manager over parts and service changed the sensor for us. However, the connector it plugs into was broken and he would look for a used one, as buying a new one means buying a whole new engine harness ($800-$900). Anytime I look up my make and model this is all anyone has to say and suzuki will do nothing about it except charge more money to keep trying to fix it.they should be forced to recall all of these vehicles until the problem is resolved.

Filed Nov 16, 2011 · Engine · 89,000 miles · FL · 1 injury

Tl* the contact owns a 2005 suzuki forenza. The contact was driving approximately 45-50 MPH when the vehicle stalled and abruptly came to a stop. The contact received whiplash from the jerking motion. The vehicle was towed to the dealer where they advised him that the engine bearings had seized and the idle pulley failed. The vehicle was not repaired. The manufacturer was contacted and they offered no assistance. The failure and the current mileage was approximately 89,000.

Filed Jul 22, 2010 · Airbags · 23,481 miles · MO

Tl*the contact owns 2006 suzuki forenza. The contact stated that the air bag warning light displayed that the air bag was disconnected. The contact stated that it took three years to correct the engine failure. The contact stated that the failure was caused by the wiring since the air bag light for the driver side remained illuminated. The dealer worked on the vehicle, but they have been unable to find the problem. The failure mileage was 5400 and the current mileage was 23481.

Filed Mar 31, 2010 · Transmission · 35,300 miles · NV

2006 suzuki forenza: while driving on highway at 70 MPH, "engine" failed to accelerate when I stepped on the gas. Car sounded and felt like it was in neutral when I pressed the gas pedal (engine revved, but didn't go anywhere). Panel showing what gear I was in showed an r with and "x" through it even through I was supposed to be in drive. Car decelerated quickly to 40mph. I put car into third gear to get the power back. This same problem happened twice while on my way to dealership for repair. Drove in third gear for the rest of the way to avoid further engine failure while driving on busy streets. On 3/25/2010 I called suzuki dealership and was told by service representative that my problem sounded like a bad sensor. While at dealership, representative was proved right, car had a bad transmission range sensor. Service representative stated that they were fixing a lot of trs in 2006 forenzas. Repair not covered by extended powertrain warranty, I paid cost. Part was approx $50 and labor was approx $150.

Filed Feb 12, 2008 · Electrical, Transmission · 50,000 miles · NC

Car has trouble starting and check engine light comes on intermittently. July 2007 took car in with 'hard start" problem. They found resonator assembly needed replacing. That repair was done on august 3, 2007. Car ran for approx. 2 months and we took it back in october with the check engine light on and the same "hard start" problem. They replaced the starter october 18, 2007 and stated it was arcing to high. Took car back october 21, 2007 with the same problem. October 26, 2007 the ecu computer was replaced. Took car back to shop october 29, 2007 with the same "hard start" problem. Moved the car to another dealership november 7, 2007 as no one was working on the car. This was suggested by the corporation. A repair was done on the car. December 13, 2007 took car back to this dealership with the same "hard start" problem. They checked the code and reset the check engine light. December 18, 2007 returned to the dealership with the same problem. They replaced the engine wiring harness. January 25, 2008 the car is having the same "hard start" problem and is sitting in the yard.

Filed Jun 15, 2006 · Airbags, Engine · 5,000 miles · NJ

Dt*: the contact stated the front passenger side air bag light illuminated. While attempting to start the vehicle the engine failed. When using the air conditioner there was an exhaust smell. The problems occurred intermittently. Although the dealership was alerted, no inspections have been made. The manufacturer has not been alerted.