Dt: the consumer stated there was a loud popping sound while driving at 35-40 MPH. This happened without warning and no previous problems. The consumer inspected the vehicle because she thought she may have run over something. There was no evidence of this, and she proceeded. Afterwards, the brakes were hard to apply. Again the popping noise became more prominent after applying brake pressure. The consumer inspected the vehicle again and discovered nothing at that time. The popping noise continued along with hard braking, and the vehicle was pulling to the right in which they stated that the rear brakes failed along with the struts. The entire hardware including the shoes and the drums were destroyed. The mechanic could not diagnose why this problem occurred. The vehicle was currently in the shop for repairs. *ak (11/23/05) the consumer was informed that the cables had broken loose and the rear brakes could self destruct.
2002 Suzuki Grand Vitara brakes problems
10 complaints (21% of all complaints for this car). Typical mileage when it fails: 41,000. 2 crashes reported.
- owner complaints
- 10
- of this car's complaints
- 21%
- typical mileage
- 41,000
- crashes
- 2
- recalls
- 1
Which part fails
- Pedals and linkages1
- Foundation components: drum: shoes/linings1
- Foundation components: disc: rotor1
- Foundation components: disc: caliper1
- Foundation components: disc1
- Foundation components1
At what mileage
Complaints by mileage at the time of the problem.
Suzuki Grand Vitara brakes problems in other years
Related recalls
Service brakes, hydraulic: foundation components: disc: rotor
- What is wrong
- On certain sport utility vehicles equipped with 16-inch wheels, the front brake discs may break under severe driving conditions. The breakage can occur in conditions where the vehicle is driven on a regular basis on extremely steep paved down-slopes while continuously applying the brakes.
- Risk
- The front brakes may become inoperative and the vehicle may pull to one side. This could result in a crash without prior warning.
- Remedy
- Dealers will replace the front brake discs on these vehicles. The recall began on november 10, 2005. These vehicles are located on st. Thomas island (virgin islands). Owners may contact suzuki del caribe at 787‑622‑0600.
Recall number 05V452000 · Recall details
What 2002 Suzuki Grand Vitara owners say
Most recent owner complaints, unedited.
At speed of 55 MPH on a highway, I was cut off by another vehicle. I had to apply my brakes quickly, and much to my shock, the car went sideways and slammed into a steel divider. This caused body damage to my vehicle to the entire passenger side - from front to back and everything in between. I have not had any repairs done as of yet.
The pedals are to close, causing the consumer to simultaneously depress the brake/accelerator pedal. The dealership will be notified. The cause was not determined. Please provide more information.
There was a vibration coming from the brakes. The rotors had completely warped.
Brakes squealed excessively and cost a mint to have replaced. (had to have two sets bought to get this to stop and rotors machined within 1 yr of purchase) right seat belt locks excessively and only way to unlock is to undo the connection.
Response to a letter the consumer received in regards to selling her 2002 suzuki grand vitara. *ph the vehicle was taken to the dealer because the vehicle would pull while braking, a speaker was blown, none of the directional signals worked and the check engine light was on. When the consumer picked the vehicle up from the dealer none of the problems had been repaired.
While driving at 70 MPH brake foundation assembly and the wheel fell off. As resul, vehicle rolled over. Consumer had pictures and police report. *ak.
This is the worst SUV I have ever driven. It wanders all over the road it simply will not go straight. The brakes when applied pull you to the center of the road. Dt
From the time of purchase july 6, 2002, brakes squeaked excessively/constantly loud even after replacement of rotors twice and shaving them. The problem persisted with premature fix and problem then reoccurred. *mr remote did not lock/unlock vehicle. Control module replaced. Passenger side door rattled while driving. Tire did not hold pressure. There was vehicle pull. Tire pressure checked out ok. Consumer requested replacement vehicle.
When braking there was a grinding noise. Took to dealer, and they replaced brakes. One month later, grinding started again. Please provide any further information.
Questions about the 2002 Suzuki Grand Vitara brakes
Does the 2002 Suzuki Grand Vitara have brakes problems?
Owners have filed 10 complaints about the brakes of the 2002 Suzuki Grand Vitara, 21% of all its complaints.
At what mileage do 2002 Suzuki Grand Vitara brakes problems start?
The typical (median) mileage in owner complaints is 41,000 miles.
Was there a recall on the 2002 Suzuki Grand Vitara brakes?
Yes, 1 recall: 05V452000. Check your VIN to see if your car still needs the free repair.
What year does the Suzuki Grand Vitara have bad brakes?
The Suzuki Grand Vitara model years with the most brakes complaints are 1999 (16 complaints), 2002 (10 complaints) and 2006 (10 complaints).
Other 2002 Suzuki Grand Vitara problems
Acceleration 16Fuel system 5Seat belts 5Suspension 4Body 3Tires 3Transmission 3Electrical 2Engine 2Airbags 1Lights 1Seats 1Steering 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Suzuki Grand Vitara?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history