Sold a lemon vehicle from dealer and contract fraud, Total loss accident left emergency life threatening surgery Tesla lost control driver side driving fsd package FAiled tire steering front control battery failed hardware updates seatbelt lossed, lost control, hit medium and another total vehicle, this is one of a few complaints to several cyclists a Including Tesla can’t get a lawyer no matter hard I try, no one is helping, car is sitting in my backyard until someone helps us. Lives ruined and no one is helping
2019 Tesla Model 3 suspension problems
83 complaints (13% of all complaints for this car). Typical mileage when it fails: 10,000. 7 crashes reported.
- owner complaints
- 83
- of this car's complaints
- 13%
- typical mileage
- 10,000
- crashes
- 7
- recalls
- 2
Which part fails
- Front: control arm1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Tesla Model 3 suspension problems in other years
Specific symptoms reported on the 2019 Tesla Model 3 suspension
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Suspension: critical fasteners
- What is wrong
- Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
- Risk
- A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
- Remedy
- Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1‑877‑798‑3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V‑835.
Recall number 23V235000 · Recall details
Suspension: front
- What is wrong
- Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
- Risk
- A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
- Remedy
- Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1‑877‑798‑3752. Tesla's number for this recall is SB-21-31-003.
Recall number 21V835000 · Recall details
Related investigations
Lower Lateral Link detachment
The Office of Defects Investigation (ODI) has received 156 complaints alleging a suspension failure in model year (MY) 2018-2020 Model 3 and MY 2021-2023 Model Y vehicles. The suspension failure involves the detachment of the front lower lateral link, which potentially causes a loss of vehicle directional control. In most cases, there was no advance warning or indication that the suspension failure would occur.  Some cases cite noises occurring prior to failure, but note that the vehicle provides no visual warnings. Once the failure occurs, the vehicle may not be drivable, thus requiring a tow. Tesla has previously recalled vehicles for lateral link detachments through two recalls. Recall 21V‑835 addressed 2,791 MY2019-2021 Tesla Model 3 vehicles due to a production issue. Recall 23V‑235 addressed 422 2018-2019 Tesla Model 3 vehicles that had experienced similar failures to those recalled under 21V‑835. The subject failures for this investigation exceed the scope of these recalls and do not appear to be related to the production issue that prompted those recalls. ODI is opening this Preliminary Evaluation to determine the underlying cause, scope, and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
PE26006
What 2019 Tesla Model 3 owners say
Most recent owner complaints, unedited.
Noise came from front left wheel while driving around a turn. Later the same day another noise when turning the wheel when leaving a parking spot. Steering felt strange. It was late at night, so left the vehicle until the morning. In the morning, discovered a large bolt in front of the vehicle. The front left wheel was turned differently than the right front wheel. Had to spend almost $400 to get the vehicle towed to a Tesla service center. They later confirmed, "The cause was detached links from the bushings and bolts. Technician replaced the front lower lateral links, front lower compliance links, and front stabilizer bar bushing brackets. Total cost for those repairs was $1,902.90. This could easily have resulted in an accident and even a fatality if we were not so lucky.
Over a period of several weeks, the front suspension increasingly made noise (squeaking and groaning) and felt loose when turning and going over bumps. The front control arms were replaced 10/31/24. The problem has begun recurring over the last few months, with the same noise occurring and progressively worsening.
The vehicle has quite a bit of noise coming from the suspension during normal driving. Creaks and groans.
Between 2023 and 2026, I have had several clunking and creaking sounds from the suspension. These were then found isolated to "lateral and compliance link detachments" and Tesla noted these were "serious safety issues" and fixed them out of warranty at a cost of roughly $2500. When I pointed out that vehicles within this model range (manufactured April 2019 at the Fremont, CA plant) were flagged for a recall, they mentioned my vehicle was outside that range and insisted on an out-of-pocket repair. Further, I have similarly had to have the front left driver's side seat belt harness replaced because of a restraint control module failure. I have owned 3 other vehicles and have never had a restraint control module/seatbelt fail over just 82000 miles of use.
Honestly since I took delivery the vehicle I did notice a clunking sound every time I would turn into a steep driveway. I reported the problem to Tesla on multiple occasions and they either could not replicate the sound or find the problem when they inspected the vehicle. So I lived with the on and off clunking sound. Years later while driving on the freeway I heard a really hard clunk and I began to lose control of the car luckily I was close to home and I was able to make it to my street. Upon arrival my tires completely fell off the control arm and I could move the steering wheel at all. I had to get it towed to the body shop. Long story short the lower control arm bolt completely fell off. I just happy this didn’t result in a major accident. But I had to get the car towed. I am pretty upset that Tesla pretty much said there is no issue. My family has Teslas and in all of them I hear the same clunking sound.
About one month ago, my 2019 Tesla Model 3 developed a suspension issue that caused a noticeable vibration in the rear of the vehicle whenever I drove above 40 mph. At first, we suspected the problem was related to a tire. However, after the technicians at the Tesla Service Center lifted the vehicle for inspection, they discovered a much more serious issue. They brought me into the service area to show me that the right rear suspension was being held together by only the front portion of a bolt. The retaining nut had completely come off, leaving the bolt barely in place. Had that bolt shifted even a few millimeters while I was driving, it could have resulted in a catastrophic suspension failure and a serious accident. Tesla determined that the loose bolt had caused damage to the right rear (passenger-side) suspension assembly. The necessary repairs totaled approximately $1,800, which I paid to restore the vehicle to safe operating condition.
Summary of the Problem Rear subframe assembly and multiple rear suspension links required full replacement due to failure/wear at approximately 51,890 miles, on a vehicle with no history of collision or accident damage. Tesla diagnosed the issue as an interior rattle/squeak reproducible over bumpy roads and speed bumps, which led to replacement of the rear subframe and nearly the entire rear suspension link set. Total repair cost was approximately $7,667.65, entirely out of pocket, as Tesla stated no recall applies to this VIN. Full Description (detailed narrative field) In December 2025, I began noticing a rattling/squeaking noise from the rear of my 2019 Tesla Model 3, reproducible on bumpy roads, speed bumps, and rail tracks. The vehicle has never been in an accident and has no history of collision damage. I brought the vehicle to Tesla Service (Fremont, CA) on 07-Jan-2026 at 51,890 miles. Tesla's diagnosis found it necessary to replace: The rear subframe assembly Rear toe link assemblies (left and right) Rear upper fore link assemblies (left and right) Rear lower fore link assemblies (left and right) Rear upper aft link assemblies (left and right) Front lower compliance links (left and right) Front lower lateral links (pair) A four-wheel alignment This amounted to nearly a full rear (and partial front) suspension rebuild, at a cost of $6,843.34 for this job alone, and $7,667.65 total, entirely at my expense. Tesla confirmed there is no open recall covering this VIN or this failure. I am concerned this represents a premature structural/suspension component failure unrelated to accident damage or normal wear, at a mileage (51,890) that suggests a potential defect in the subframe or suspension hardware/corrosion resistance for this model year, rather than an isolated wear item. I am filing this complaint so the federal safety agency can evaluate whether this is part of a broader pattern for 2019 Model 3 vehicles.
these cars have a defective control arm system and they are prone to messing up over and over, they have replacement revisions but try to charge you for labor and parts if youre out of warranty even though they know the parts were a problem and revised them. Tesla does nothing to help you and will even try to charge you $200 just to diagnose the issue.
Suspensions. I know there’s been known defects with the suspensions and they’ve only recall 422 vehicles so far (2018-2019 Tesla model 3, I feel more vehicles in those years are affected.
Questions about the 2019 Tesla Model 3 suspension
Does the 2019 Tesla Model 3 have suspension problems?
Owners have filed 83 complaints about the suspension of the 2019 Tesla Model 3, 13% of all its complaints.
At what mileage do 2019 Tesla Model 3 suspension problems start?
The typical (median) mileage in owner complaints is 10,000 miles.
Was there a recall on the 2019 Tesla Model 3 suspension?
Yes, 2 recalls: 23V235000, 21V835000. Check your VIN to see if your car still needs the free repair.
What year does the Tesla Model 3 have bad suspension?
The Tesla Model 3 model years with the most suspension complaints are 2018 (194 complaints), 2019 (83 complaints) and 2020 (47 complaints).
Other 2019 Tesla Model 3 problems
Driver assistance 224Electrical 94Airbags 89Acceleration 71Brakes 64Seat belts 58Steering 54Seats 47Visibility 34Body 23Transmission 10Fuel system 8Lights 6Tires 5Wheels 5Engine 2Locks 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Tesla Model 3?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history