2020 Tesla Model 3 steering problems

Filed Oct 30, 2026 · Steering, Suspension · CA

I am reporting a premature and severe multi-component front suspension failure on my 2020 Tesla Model 3 that poses a serious steering and control safety hazard. While driving and turning at low speeds (such as parking), the front end began emitting a loud mechanical clicking and popping sound. A certified technician diagnosed the vehicle and found that multiple critical suspension components had failed or worn prematurely at just 55,089 miles. The failures include the front lower lateral links, front lower compliance links, front upper control arms, stabilizer bar and front end hubs failing completely and simultaneously. This is a well-documented issue among 2018–2020 Model 3 vehicles and is currently the subject of an active the federal safety agency Preliminary Evaluation investigation regarding front lower lateral link detachment. Premature failure of these load-bearing suspension components compromises the vehicle’s structural integrity, accelerates extreme tire wear, and presents an immediate risk of component separation or sudden loss of steering control at high speeds. Tesla should issue a safety recall for these defective suspension components and compensate owners for out-of-pocket repairs.

Filed Oct 16, 2026 · Driver assistance, Steering · DE

VEHICLE INFORMATION Make/Model/Year: Tesla Model 3 (2020) Component: Steering / Autonomous Control (ADAS) INCIDENT SUMMARY While driving on Autopilot/FSD southbound from [XXX], the vehicle experienced a sudden, uncommanded lateral steering excursion (phantom steering actuation) pulling abruptly toward the roadside shoulder. The driver had to immediately apply manual counter-steering torque to override the system and prevent a major collision. This unprompted steering correction caused the passenger side mirror structure to strike a roadside utility pole. KEY SAFETY FACTORS Sudden loss of directional control caused by computer-generated steering inputs rather than driver command or road obstruction. Quick driver intervention prevented a severe collision, but resulted in structural impact to the entire passenger mirror assembly. An official service ticket has been filed with the manufacturer requesting an immediate engineering telematics log pull (Steering Angle Sensor inputs vs. manual override torque, FSD state logs, and camera arrays) for the specific timestamp. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 16, 2026 · Steering · CA

The steering assist reduced alert popped up on the tesla screen. While attempting to turn into a parking garage, a "steering assist reduced" alert suddenly appeared on the tesla screen, and the steering wheel locked up/became extremely heavy and unable to steer left or right. Because the steering assist failed in active traffic at the entrance, the vehicle was temporarily stranded, exposing to oncoming traffic and created an immediate risk. Failed component: electronic power-assisted steering (EPAs) rack and steering gear assembly. The failed component was replaced by Tesla and is not available for personal inspection. Safety risk: The sudden loss of steering ability in active traffic prevented normal maneuvering, forcing the vehicle into a hazardous position where passing vehicles could have collided with it. The issue was confirmed by Tesla Service, who performed a full steering rack replacement. The vehicle was inspected and repaired directly by the manufacturer (Tesla Service Center). There were no warning lights or symptoms prior to the incident; the failure and "steering assist reduced" error appeared abruptly during the turn.

Filed Jul 14, 2026 · Acceleration, Brakes · TX · crash · 1 injury

On July 11 at approximately 6:47 a.m., I was operating my Tesla Model 3 on Interstate 65 in Hart County, Kentucky, with Full Self-Driving (FSD) engaged during normal highway travel. Approximately one hour earlier, I had departed a highway rest area after sleeping from the previous day’s travel. Rain developed during the trip, but I observed adequate visibility, apparent roadway traction, and I was not impaired. I was traveling in the far-right lane of a three-lane interstate. The posted speed limit was approximately 70 mph; however, FSD limited the vehicle to approximately 65 mph and displayed warnings indicating that the higher speed was unavailable. While FSD remained engaged, the system initiated a lane change from the far-right lane into the center lane. After entering the center lane, the vehicle began displaying repeated warning messages and FSD disengaged multiple times. I attempted to locate settings related to the warnings on the touchscreen but could not identify an available adjustment. During the third disengagement, I perceived that the vehicle continued braking without releasing while steering resistance increased significantly. The steering wheel then rotated abruptly, and I was unable to regain normal directional control before the vehicle departed its intended travel path and struck a concrete median. The collision caused personal injuries and substantial vehicle damage. I have not been able to reproduce the condition. The incident was investigated by the Kentucky State Police. Based on the sequence of repeated FSD warnings, disengagements, continued braking, and abrupt steering behavior, I believe this event warrants investigation. I request that the federal safety agency review the vehicle’s Full Self-Driving logs, telemetry, Event Data Recorder (EDR) data, steering and braking commands, diagnostic records, and software history to determine whether a vehicle or software malfunction contributed to the collision. Almost like someone had control, into the wall -KM

Filed Jul 2, 2026 · Driver assistance, Steering · CA · 1 injury

On XXX at approximately 5:00 PM, I was driving my 2020 Tesla Model 3 on [XXX] from [XXX] toward [XXX], with Tesla FSD engaged. Near the area where the center divider begins/ends, the vehicle crossed the double yellow/divider area and entered the opposing traffic lane. There was no oncoming traffic at that moment, so there was no crash, but this created a serious potential head-on collision risk. The car also did several hard jerks that aggravated my neck and back that it has been consistently doing for a long time which cause worse ongoing headaches. The system/component that malfunctioned was Tesla FSD/Advanced Driver Assistance, including lane keeping/steering behavior. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the vehicle moved into the lane for oncoming traffic. I had to intervene and no longer feel safe using FSD. I have reported unsafe FSD behavior to Tesla multiple times before, but the issue has not been resolved. Tesla service has previously listed the concern as “FSD not working properly/test drive required” and/or general diagnosis, but I have not received a clear written resolution explaining why the vehicle crossed into the opposing lane or how Tesla will prevent this from happening again. There were no warning lamps or messages that I recall before the vehicle crossed into the opposing lane. If Tesla has vehicle logs or telemetry for the incident, I request that they be reviewed. I am reporting this because the vehicle may repeat this unsafe behavior and create a head-on collision risk. The car continues to behave unsafely and erratically. i have a log of some of the incidents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 4, 2026 · Steering, Suspension · CA

Sunday [XXX] downtown Sacramento, driving about 25 mph. Heard a loud bang—bolt sheared off front subframe. Steering felt lagging upon making a right turn vehicle proceeded in a very wide turn, pulled into parking lot. Wheel locked right as I exited [XXX] parking spot; steering went slack, brakes scraped rotor. Two witnesses saw hardware hit pavement. AAA tech removed tire: lower control arm bolt missing, no Loctite, subframe raw. Second bolt loose—single point of failure. Tesla missed this on six different service visits and during their one-twenty inspection before delivery. Recall 21V835 should’ve flagged it but service personnel assured me all clear on every visit . Vehicle towed to Tesla service center at 1104 Tinker rd, Rocklin, CA. Tesla shop manager Sal confirmed this failure as manufacturers defect, and poor assembly. Safety was seconds from total loss. Need probe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 23, 2025 · Steering · CA

Steering wheel covering delaminates and peels during normal use, creating loss of grip and distraction while driving.

Filed Dec 8, 2025 · Steering, Suspension · CT

My Tesla Model 3 is experiencing premature suspension failures involving the lower lateral links and stabilizer links. These components were already replaced once, and they are failing again in less than 30,000 miles. This is not normal wear for suspension parts on a modern vehicle. These failures cause clunking, instability, and looseness in the front end—conditions that affect the vehicle’s ability to track straight and maintain control, especially over uneven pavement or during emergency maneuvers. This isn’t an isolated case. There are extensive reports from other Tesla owners across multiple models (Model 3 and Model Y in particular) showing the same premature wear on these suspension links. Many owners have parts failing even earlier. Once the car is out of warranty, Tesla charges thousands of dollars to replace these components, despite clear indications that the suspension was under-engineered for the weight of the vehicle. Tesla knows this is a recurring issue but refuses to issue a recall or goodwill repairs. A repeated failure of critical suspension links in such low mileage suggests a defect. These parts should not be wearing out this fast, and the resulting instability poses a real safety risk. I’m requesting the federal safety agency investigate these premature failures.

Filed Aug 12, 2025 · Driver assistance, Steering · CA

Subject: Urgent Complaint Regarding Power Steering Failure in 2019 Tesla Model 3 Hello the federal safety agency, I am writing to file a complaint regarding a very dangerous situation I recently experienced with my 2019 Tesla Model 3. While driving on the freeway at approximately 65 mph, the power steering failed unexpectedly. I struggled significantly to change lanes in order to exit the freeway, and it felt as though my vehicle was going to collide with other cars. After managing to get off the freeway, I nearly hit the guardrail while attempting to turn onto a side street, creating a hazardous situation. I am deeply concerned about the potential consequences; for instance, what if I had struck a pedestrian, or if the car had collided with another vehicle at high speed? I live on a winding mountain road, where I could have easily driven off a cliff. Turning the car off and back on temporarily resolved the issue. However, there are numerous complaints regarding steering rack failures with Tesla vehicles. Tesla has quoted me $2,700.00 to fix what appears to be a known manufacturing defect. They are aware of this potentially hazardous situation but are not taking responsibility for the repairs. This is a serious safety issue, and I urge Tesla to accept responsibility and cover the repair costs before someone is seriously injured or killed—if such an incident has not already occurred. Please let me know what further actions I can take to facilitate Tesla's resolution of this dangerous problem. Thank you for your attention to this matter. Sincerely,

Filed Jul 19, 2025 · Acceleration, Driver assistance · CA

Vehicle must have thought a shadow line in the road from a bridge indicated a wall I was about to hit, as it slammed on the breaks in the middle of the freeway. Car behind had to swerve to avoid. On the same trip, several nags of 'keep eyes on the road' were incorrect, as my eyes were directly on the road, but phone was in hand functioning as a microphone taking voice memos. Car proceeded to shut itself down while in the middle of the freeway, causing me to go slower than traffic and put me in danger as cars behind me had to swerve or lane change to avoid me as I tried to pull off to the shoulder. These forced shutdowns from incorrect 'nag fails' are causing safety issues. Nag failures should not forcibly shut the car down. Not sure if this is being enforced by the federal safety agency, or why Tesla is choosing to disable their auto steer or FSD when drivers are detected to be failing nags - nags should be there to help drivers, and potentially the nag data/cab video can be used after the fact should a user failing nags be involved in an accident for insurance dispute resolution, but shutting the cars down themselves is causing issues.