Here is another tesla in the junkyard: https://www.copart.com/lot/48517337 the back wheel has fallen off for no good reason. Tesla uses cast aluminum for the suspension parts. These parts have very little margin of safety even when brand new. After a few years and with the effects of fatigue and corrosion these parts become even more fragile. Owners are under the mistaken belief that these cars are very safe and require very little maintenance. As the fleet of teslas ages the risk of failure becomes even greater than it is already. Many countries in which the tesla is sold do not require safety inspections for the first few years. Some countries require no annual safety inspections at all. This is a ticking time bomb. Please investigate before more lives are lost. Thank you. Concerned citizen.
2013 Tesla Model S suspension complaints
Page 3 of 4: complaints 41 to 70 of 92, newest first, as owners wrote them.
Tesla.... Junkyard... Https://www.copart.com/lot/27986168 the usual - suspension fell to bits, wheel fell off. Please investigate if you can spare the time. Thank you. Annoying citizen.
Here is a tesla in the junkyard: https://www.iaai.com/vehicle?itemid=26868872&rownumber=18&loadrecent=true the front and back wheels on the lh side have simply fallen off and the suspension parts have snapped. The suspension has collapsed on all sides of the car probably due to an air leak in the suspension lines or a glitch in the software. The rate at which wheels are falling of teslas is simply ridiculous. Please demand a recall. Thank you. Concerned citizen.
Here is a tesla in the junkyard: https://www.copart.com/lot/31421117/photos once again the back wheel and suspension has completely fallen off. No air-bags deployed. No sign of collision damage. Suspension has simply snapped off for no good reason. There is a clear trend of defect in the tesla suspensions. If this car was being produced in the same volumes as mainstream car-makers then you would be seeing thousands of cars with wheels fallen off. It is scandalous that this danger is allowed to continue. Please act now to protect the public. Date of incident is an approximation.
Here is another tesla in the junkyard: https://www.copart.com/lot/42232387/photos it has been in a rollover. The suspension has collapsed on all four wheels and both back wheels have gone whompy. There is a strong likelihood that the whompy wheels caused the crash rather than being merely the result of it. Please investigate the reason that tesla suspensions collapse so often. Thank you. Concerned citizen etc.
Here is another tesla in the junkyard: https://www.iaai.com/vehicle?itemid=26175292&rownumber=59&loadrecent=true the front suspension has totally collapsed and the wheels are jammed up in the wheel arches. The wheels are not pointing straight but are skewed in towards each other. No air-bags have deployed. There is no impact damage to the bodywork. This looks like another case of spontaneous collapsing suspension. Please investigate. Very concerned citizen etc. Etc.
I made a left turn on kellogg drive.I ran over some safety dots on the floor. The safety dots was abnormal large in size. Both my front and rear wheel ran over many large safety dots. The complete tesla brake function failed and I have no brake. By the time my car stops I was literally sitting on top of safety dots. Once I come out of the car I saw that my left rear tire and rims look like is falling out of place. The police campus came and said it looks like your axel was broken. There was no damage to the outer appearance of my tesla only a upper suspension which was damage. I believe the parts was an integrity issue and tesla denies it.
Here is another tesla in the junkyard: https://www.copart.com/lot/35967857/photos the car is completely undamaged apart from the lh rear wheel which is skewed over at a crazy angle. No air-bags have deployed. There is no impact damage. The tire and wheel are undamaged. This can not be the result of a collision. It is simply a case of whompy wheels due to weak and unsafe suspension. Please recall these cars before more lives are lost. Concerned citizen etc.
Here is a fresh report of a tesla suspension failure: https://teslamotorsclub.com/tmc/threads/tesla-upper-control-arm-cracked.96329/#post-2257474 snip:it all took place yesterday when my wife were driving to visit one of her colleague. While turning into a left turn at a relatively low speed she heard a loud bang. She did not think of much but immediately she notice that her brake were completely gone and the dash had malfunction warning all over the place. She had to struggle to pull the car to safety but was hitting many of the safety bump on the ground. Within minutes the campus police pull up and ask her what happen. She got out of the car notice the our 2013 model s p85 was sitting on the ground with one of the wheel completely bend. It looks like as if the axle had gave away. *** to me it is obvious that this is not an wear and tear. It is an manufacturer part defect. And after reading on many form it seem that the suspension was a big problem on the early production tesla model s. I have been in mercedes for years and my previous s class were at 125,000 miles. I have not seen anything like this. Currently they are still refusing to cover the repair. Luckily enough my wife was driving locally not on the freeway. I can't imagine what a catastrophic accident it will be if she were travel at a high speed. *** if the federal safety agency continues to ignore these failures there will be consequences. Please note: I am not a tesla owner. I am continuing to file these reports in the public interest because you can see by reading the thread that owners come under pressure from tesla supporters to keep these failures a secret. The pro-tesla forums frequently censor, delete, or bury such complaints. I have used a dummy us address to comply with website requirements. My genuine contact details have been supplied to the federal safety agency.
Here is a tesla in the junkyard: https://www.iaai.com/vehicle?itemid=25626248&rownumber=65&loadrecent=true&isnext=true it has been completely burned out. The airbags have not been deployed. The front lh wheel is pushed back in the wheel well and that could have caused the fire by making the coolant leak out. If the battery pack is hot from recent charging or from hard driving it is highly likely to catch fire if coolant is lost. Teslas seem to catch fire more often than any other electric vehicle. Please investigate.
Here is a tesla in the junkyard: https://www.salvagereseller.com/cars-for-sale/30827127-2013-tesla-model-s-jacksonville-fl it has not been in a crash. There is no collision damage and the air-bags have not deployed. The suspension has collapsed on both sides of the car causing the wheels to jam up in the wheel wells. This same failure is occurring repeatedly. It seems that the design is lacking a bump stop and that a simple air leak in the suspension can result in catastrophic failure. Please investigate.
Here is a tesla in the junkyard. Https://www.salvagereseller.com/cars-for-sale/make/tesla/page/25 it has not been in a crash, no airbags are deployed and there is no impact damage. The front lh suspension upper ball joint has simply popped apart causing the wheel the skew over and go totally whompy. This same failure has occurred repeatedly in these teslas. The ball joints seem to be undersized for a car of this weight and performance. Please take immediate action to prevent innocent lives being lost. Concerned citizen. (date of incident is an approximation)
Here is a tesla forum discussion regarding broken suspensions in the model s: https://teslamotorsclub.com/tmc/threads/model-s-axle-issues.92069/page-2#post-2142321 prompted by this discussion the owner of a 2013 model s has inspected his own suspension and has posted a photograph which is attached. The lower suspension arm bolt has snapped off. The rim of the wheel has been gouged. The suspension arm is rubbing against the tire and fragments of rubber are spread all over the suspension. This is obviously highly dangerous. Just one such event should be justification for an immediate recall. You have dozens of similar failures on record. Please investigate.
Here is a tesla in the salvage yard: https://www.iaai.com/vehicle?itemid=24305455&rownumber=18&loadrecent=true the front rh wheel is rammed back in the well and has pushed hard up against the hv controller. There does not appear to be any significant damage forward of the wheel that would have been the reason for the wheel being pushed back. The airbags have not deployed which suggests that there was collision. These repeated failures seem to be caused by weak suspension components that are unable to safely cope with the forces in this heavy and powerful vehicle. Please investigate the reason for so many similar wrecks showing up in the junkyards. Tesla owners are unlike the owners of mainstream cars. They are very likely to hold shares in tesla and are also passionate supporters of the tesla "vision". They are also very dependent upon maintaining friendly relations with the company since it holds a monopoly on service and spares.
Here is another burned out tesla in the junkyard. Https://www.iaai.com/vehicle?itemid=24762753&rownumber=10&loadrecent=true the suspension has collapsed on the lh side and the front wheel is jammed into the battery. The airbags have not deployed. The car does not appear to have been in a collision. The wheel jamming into the battery is the most likely cause of the fire. If the battery is hot from hard driving or from recent charging then any loss of coolant is likely to cause a fire. Please conduct a test to see whether such a simple loss of coolant can cause a fire in those circumstances. The rate of fires in teslas is alarming and it is extremely hard to suppress a lithium battery fire. Thank you. Concerned citizen etc.
Suspension links in my tesla model s 2013 were advised to be replaced at 56,000 miles. If not replaced by service I was told the wheels could break off. No timeline was given. The car was moderately used on average condition roads in the state of connecticut. Suspension links should be more reliable and not require a replacement after 56,000 of regular usage.
Here is a tesla in the junkyard. Https://www.copart.com/lot/18905747/photos the suspension has collapsed. The front wheel is jammed up in the wheel well. The back wheel has gone all whompy. The air-bags have not deployed. The car does not appear to have been in a crash but the suspension has simply fallen to bits. Please investigate.
Here is another tesla in the junkyard. Https://www.iaai.com/vehicle?itemid=24260079&rownumber=47&loadrecent=true the suspension has totally collapsed and it appears the only damage to the vehicle is that which was caused by the wheels jamming up in the wells. I am reporting these incidents as a concerned citizen and I request that you launch an urgent investigation into the suspension defects in this vehicle.
Here is a tesla in the salvage yard. Https://www.iaai.com/vehicle?itemid=23837634&rownumber=43&loadrecent=true the front end of the car is completely smashed up. The back rh wheel and suspension wheel has fallen off completely and there is no impact damage to that area of the car. Bearing in mind the large number of incidents of suspension failures on teslas it would seem highly likely that the cause of this serious crash was that the back wheel fell off. In addition to photographic evidence you have published complaints from actual owners complaining of wheels going whompy or falling off completely. Please investigate whether these crashes are being caused by suspensions that have design, manufacturing or maintenance problems. Note that I am not the owner just a concerned citizen. Date of crash is an approximation.
I am filing this complaint to draw to the attention of the federal safety agency that there is pattern of failures in the tesla suspensions that is putting lives at risk. Here is another tesla in the salvage yard. Https://www.copart.com/lot/41350906/photos once again the air suspension has collapsed on all four wheels. The car does not appear to have been involved in a collision and the air-bags have not deployed. It would appear that all the damage caused to the car is a result of suspension collapse. Please note that I am not the owner just a concerned citizen. Date of incident is an approximation.
Yet another tesla with a collapsed suspension. Https://m.iaai.com/vehicledetenc.aspx?auctionid=0&itemid=24260079&rowid=53&pagesource=vehicleresults this same failure is happening to teslas repeatedly. Please investigate.
Here is a tesla in the junkyard. Https://m.iaai.com/vehicledetenc.aspx?auctionid=0&itemid=19172289&rowid=52&pagesource=vehicleresults# the rear lh suspension has been completely ripped off. The air-bags have not deployed and there is no impact damage that would have caused the suspension to have been ripped off. These suspension breakages are happening repeatedly. It is quite obvious that the alloy parts are too fragile for a car of this weight and power. Please investigate this problem before more lives are lost. Please note that I am not the owner but a concerned citizen. The date of the accident is an approximation.
Here is another tesla in the junkyard. Https://www.iaai.com/vehicle?itemid=23585793&rownumber=52&loadrecent=true the front rh suspension has collapsed and the wheel is skewed sideways. There is no impact damage to the wheel or to the front of the car that would have been likely to have caused the damage to the suspension. Similar failures are occurring at an alarming rate. Please investigate before more lives are lost.
Here is a tesla in the junkyard. Https://www.copart.com/lot/19512447/photos the air suspension has collapsed and all the wheels have gone whompy. I think this might make driving difficult.
My car went over a pothole on 101 s just short of woodside rd. Exit. I heard a loud thud and my car went out of control and veered into the lanes next to me as I tried to control it. After several attempts to stop it, it finally came to a stop. The rear, right tire burst and the wheel impacted badly. Rear suspension broken and the 'quarter and rocker panel' broken.
Here is a tesla in the junkyard. Https://m.iaai.com/vehicledetenc.aspx?auctionid=0&itemid=23837634&rowid=31&pagesource=vehicleresults the back rh wheel assembly has torn off and exited through the rear of the car tearing off the back bumper. The car has then had a major collision. It is most unlikely that it is a mere coincidence the back wheel has fallen off. The alloy suspension components are much too fragile and have failed many times on these vehicles. Please investigate. Note: I am not the owner of the vehicle just a concerned citizen. Date of accident and injury details are an approximation
Here is a tesla in the junkyard. Https://www.copart.com/lot/44749556/photos?resultindex=12&totalrecords=21&backto=%2flotsearchresults%2f%3ffree%3dtrue&query=tesla&query=tesla&displaystr=search%20results&viewedlot=44749556 the suspension has collapsed on all 4 wheels and the wheels are jammed up in the wheel wells which has caused damage to the bodywork and presumably a very rapid deceleration of the car. There is no impact damage. There hav been many reports of similar incidents and reports that the car lacks any form of limit stops if should there be a leak in the air suspension system. The passenger side air bag has deployed but not the drivers side. It is reasonable to assume that there was a driver in the car at the time since this car predates the autopilot system! Please note that I am not the owner and that this report is based entirely on my observations and analysis of the photographs of the damaged car. Date of incident is an approximation.
Here is a tesla in the salvage yard. Https://m.iaai.com/vehicledetenc.aspx?auctionid=0&itemid=23880040&rowid=38&pagesource=vehicleresults the front wheel is leaning outwards at an extreme angle. The tip of the steering knuckle has snapped off. The wheel and tire are undamaged and it is unlikely that the front of the car has had a hard enough impact that would account for the snapped knuckle. This cast aluminum knuckle has snapped in a similar way in many other incidents that have been reported to the federal safety agency. Later model teslas have a redesigned knuckle that is more sturdy but even that one has had incidents in which the tip has broken off or the ball joint has popped apart. The cast aluminum parts of the suspension appear to be too weak to cope with the forces that may be applied during hard braking and cornering. Please note that I am not the owner of the vehicle but that I am a concerned citizen trying to protect the lives of tesla owners and those who share the roads with them.
Here is another tesla in the junkyard https://m.iaai.com/vehicledetenc.aspx?auctionid=0&itemid=23837634&rowid=30&pagesource=vehicleresults it has been in a major front end collision. Almost certainly cause by the back wheel falling off! Please investigate this. Every tesla on the road is in danger of having a wheel snap-off at any instant. Please note that injury report is just an estimate based on the severity of damage. Date of crash is an approximation.
Here is a tesla model s in the salvage yard https://www.copart.com/lot/42150556/photos?resultindex=18&totalrecords=20&backto=%2flotsearchresults%2f%3ffree%3dtrue&query=tesla&query=tesla&displaystr=search%20results&viewedlot=42150556 there is zero damage to the bodywork and it does not appear to have been in a crash. The back suspension has simply fallen to bits. These are not isolated incidents, they are part of a pattern of failure caused by weakness in the supension components. Please take urgent action to prevent further loss of life.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2013 Tesla Model S?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history