2014 Tesla Model S suspension problems

Filed Aug 20, 2025 · Suspension · OH

Vehicle Information: 2014 Tesla Model S VIN: [XXX] Incident Date: [XXX] Component Affected: Suspension / Air Suspension / Ride Height Control Problem Description: On [XXX], while driving, my 2014 Tesla Model S suddenly raised itself to and/or beyond maximum ride height without any driver input. Immediately afterward, the front driver-side suspension collapsed completely, leaving the vehicle unsafe to operate. This appears to be an uncommanded overinflation event caused by Tesla’s suspension control system. It is not normal wear but a manufacturer-induced malfunction. If this failure had occurred at highway speeds, it could have caused catastrophic loss of control. The collapse of a suspension system without warning is a serious safety defect. Tesla’s service center in Moraine, OH, has refused to review the vehicle logs (which would confirm this sequence of failure) and has instead classified the incident as a standard part failure. As a result, Tesla is attempting to push full financial liability onto the owner instead of addressing what is clearly a safety-critical defect. Safety Concern: A sudden, uncommanded suspension height change followed by collapse could lead to total loss of vehicle control and a crash. This poses an ongoing risk to both Tesla drivers and the public. Requested Action: I am requesting that the federal safety agency investigate this failure mode as a safety defect in Tesla Model S vehicles and require Tesla to address these failures appropriately. Service Center Involved: Tesla Service Center 1927 W Dorothy Ln Moraine, OH 45439 Owner Information: [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 14, 2024 · Suspension · CA

I have put my car in the shop 11 times since I purchased it 3 years ago. Now my suspension is having issues. I don't qualify for the lemon law due to the age of my car. I paid over 30,000 for a car that is not going to last till its paid off.

Filed Mar 14, 2024 · Suspension, Wheels · IL

While driving, my back wheel fell off. I had the car in for suspension work twice in Q4 2023, and then on March 7, 2024 my back wheel fell off. When speaking with Tesla, they said that this sometimes happens and they have seen this issue before. The also told me that they think it only happens at low speeds, but I have found articles where people were on the highway and their wheel fell off. China has made Tesla do a recall for suspension and wheel issues, why haven't we? I now have had my vehicles suspension worked on at least 4 times, this is dangerous and scary.

Filed Jan 25, 2024 · Suspension · VA

Premature wear on almost all front suspension parts relating to control arms and sway bar links. Recently had to pay out of pocket to have two steering rack bolts tightened, they were not torqued properly from the factory apparently

Filed Jan 20, 2024 · Suspension · CA

Front control arms left and right FR SUSP FORE LINK ASSY , only the replacement is available for inspection upon request. The safety that was put at risk is unknown. It was repaired by Tesla at my expense. There were no warning lamps, messages the only symptoms was noise, metal banging.

Filed Nov 19, 2023 · Suspension · IL

Our vehicle has just over 100k miles, and we have had the front control arms replaced twice. Tesla says that we have to keep replacing because it's a safety issue, but refuses to take ownership of the fact that the control arms should not fail this frequently. In China, Tesla is doing recalls for this part and there is a class action lawsuit in the US. However, Tesla has told me that I need to keep replacing this parts because if they fail then the car could crash.

Filed Oct 26, 2023 · Suspension · WA

Our right rear lower control arm broke off at the outer end. The wheel and hub dropped and cambered out away from the vehicle and the vehicle could not be driven. Fortunately this occurred entering our driveway at low speed. The car was taken to Tesla and we believe should have been repaired under service bulletin [XXX] detailing this exact issue. However, they are presenting a bill for about $7000. claiming our VIN is not within this bulletin. We note that our car was purchased in January 2014 but also the bulletin says approximate. We also believe NTSHA has been made aware of this issue but has failed to issue a recall. This is a serious safety issue! At freeway speeds this could have caused a total loss of control and a serious crash in our opinion. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 23, 2023 · Suspension · FL

This is for 2017 model s, with vin: 5YJSA7E1XHF190080, but your form didn't allow it. Front lower right forward control arm, hairline crack in the portion that holds the ball joint to the hub. Can only be visible when taken off car. When discovered early you only hear a small clicking sound in the car when steering in certain angle over a pothole or similar. When allowed to be continued used, crack is expanding in the aluminum control arm and the ball joint is coming loose, further driving fatigues the aluminum arm and breaks it.

Filed Jun 11, 2023 · Suspension · NJ

The wheel came off the car while driving with no warning. It was just at service at the Tesla in Devon PA on May 12, 2023. This is a safety issue! Tesla refused to cover the repair and charged a diagnostic fee on top of that!

Filed Apr 20, 2023 · Suspension · UT

Left rear control arm (Tesla referred to it as Upper Rear suspension link and integral link) broke from the joint causing the wheel to fall off and damage the halfshaft, air spring and bushings. Fortunately I was barely moving at the time of the accident. Had this happened on the freeway I could have been killed. Looking online and at other comments on here this does not appear to be an isolated incident.