The 2021 and beyond Tesla Model S comes installed with camber arms that cause the wheel to be tilted in and thus wears the tire on the inside to the point of wearing out within 6 months. This is a flaw in the building and pertains to all the model S's 2021 and greater. This is a safety issue and is not addressed by Tesla. I think Tesla should be forced to provide a recall for this.
2021 Tesla Model S suspension complaints
Page 2 of 2: complaints 11 to 16 of 16, newest first, as owners wrote them.
The control arm fore links of the car failed after 6000 miles
Severe wear on rear tires, as the camber is off. Tire failure exposing cords. Potential to be a catastrophic failure. Many with this car experiencing same issue with 21” tire option. Car has poor suspension stance and or tires are incorrect for the load being carried
My vehicle had a total rear tire failure where the inside corner of tread separated from the sidewall. There appears to be abnormal wear on the very edge of the inside line of tread. The vehicle was just aligned and nothing was out of spec. Something about the tire design, weight of the vehicle, recommended tire pressure or suspension geometry is causing this failure. My tires were always kept at the recommended pressures. There was no indication of a problem until the tire went completely flat suddenly.
The inner edge of rear tires wear out very quickly leading to loss air pressure. Many other owner of Tesla 2021+ on 21 inch wheels and Michelin stock tires have exact same issue. Very dangerous if the tire bursts on highway, can lead to serious accidents.
The rear passenger side Adaptive Suspension wiring harness was either installed improperly or routed improperly and rubbed against the inside of the tire. After many miles, this harness was worn down to the point of breaking electrical contact, which puts the vehicle into a fallback state. When the dampers are disabled, the car becomes floaty and disconnected and is dangerous to drive. There were warnings in the system immediately when this broke. It is available for inspection, as Tesla has stated they cannot fix it for 6 weeks. The problem has been confirmed by their service dept via remote diagnostics. There has been no inspection by anyone other than myself, however I have extensive photographic evidence. The issue is very obvious when you know to look.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Tesla Model S?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history