2022 Tesla Model S suspension problems

Filed Oct 30, 2026 · Suspension, Wheels · OH

At approximately 62,600 miles the lower rear reward control arm sheared off which then required a repair cost of $2000.00. The car became essentially un-operatable, it could only move forward and there was the distinct possibility of the wheel separating from the car

Filed Oct 29, 2026 · Suspension, Wheels · VA

2022 Model S Long Range, 21″ Arachnid wheels, Michelin Pilot Sport 4S 295/30ZR21 rear, 265/35ZR21 front. Rear tires wear through to the cords on the inner shoulder while the rest of the tread looks new; fronts wear the outer shoulder. Nine replacement tires from Tesla in 47,000 miles (rears May 2025 and Oct 2026; fronts May 2024, Apr 2026, Jun 2026), plus two loaner-wheel flats (May and Aug 2026). Every failure presented as a slow leak or flat with no visible wear. Tesla performed four-wheel alignments on 5/18/2024 and 4/22/2026, both recorded “within specifications”; a front tire fitted at the second alignment failed about 2,300 miles later. Tesla never identified a cause. On 10/22/2026 the Tysons Corner, VA service manager attributed the wear to lack of tire rotation; Tesla's own invoices of 12/23/2022, 7/19/2023, 4/22/2026 and 10/22/2026 record “Tire rotation recommended: No,” and the service manual allows only side-to-side swaps on this staggered setup, which cannot move inner-shoulder wear. The cause appears to be the non-adjustable negative rear camber on 2021+ Model S, as described in ODI 11636646, 11645675, 11710217, 11732580 and 11580793. Hidden inner-edge failure on a 4,800-lb car at highway speed is a blowout risk. Requesting investigation of the 2021+ Model S rear suspension geometry on 21″ wheels.

Filed Oct 20, 2025 · Suspension, Wheels · NY

Since purchase, I have experienced nine tire-related failures, including four separate blowouts at highway speed, leaving the vehicle disabled on major roads multiple times. The most recent occurred on [Insert Date], when the car suffered another blowout and is now disabled at my residence. This pattern of failure has occurred despite tire replacements and service visits by Tesla. The issue began on the day of delivery, when a tire failed within 70 miles, and service staff admitted the car had not been safety inspected prior to delivery. Tesla has replaced nearly all tires, reimbursed a third-party shop once, and confirmed on a recorded call that the level of tire failure is abnormal. Still, no root cause has been identified. The failures have occurred under normal driving conditions and pose a serious safety hazard to me, my family (including children), and others on the road. My family now refuses to ride in the car. This issue is ongoing, unresolved, and I believe there is a systemic defect involving the vehicle’s suspension, alignment, or structural components that is contributing to abnormal tire wear and catastrophic blowouts. I am requesting that the federal safety agency investigate this vehicle and Tesla’s CPO inspection process, and that appropriate safety action be taken before someone is seriously injured or killed.

Filed Aug 15, 2025 · Suspension · AZ

Michelin Pilot Sport 4S T2 295/30R/21 102Y. These tires are engineered by Michelin specifically for a Tesla Model S 2022+ hence the T2 mark. These are a second generation as the previous ones were a T1. Everything is supposed to be factored in by Michelin to cater to the vehicles specifications and needs. I bought a set of 4 of these mentioned tires brand new from Discount Tire. In less 10000 miles and 7 months the sidewalls have completely decoupled from the tread section/rest of the tire. The treadwear itself shows and even smooth normal wear pattern. Discount tire and Michelin are trying to claim this is an alignment issue citing too much camber. This is a false claim. The area of separation is not in the contact patch with the surface of the road. This is a defect in engineering and construction in the tire itself. This calls for a mass recall. I put the trust of my pregnant wife into these tires and she complained to me about a wallowing car ride with a decrease in handling, especially over bumps and on the highway. I could not see an issue. A few days later she informed me of a tire pressure indicator on the dashboard. It indicated tow low rear tires. Upon inspecting the tires I found both sides with a decoupled sidewall. Driver side being far worse than passenger. I immediately drove to Discount tire and the tire pressure sank from 26psi to 8psi in less than 4 miles. This could have proved fatal for my wife and unborn child on the highway. The tire company and the stores dont want to accept accountability. The stores just want to sell more tires. I am having them replaced at a cost of $610 per tire. Thats equaling to almost $3000 spent on tires in 7-8 months. Please investigate this matter. This is a defect. Not wear. The vehicle previously had Falken tires that lasted 24000 miles with smooth and even treadwear. No issues, no defects.

Filed Jun 26, 2024 · Suspension · TX

Air Suspension system throws an error. Car attempts to lift but it feels like a limit switch or some upper bound is not working properly, as the car lifts in the rear, then suddenly kicks back down before trying to lift again. This process repeats 5-6 times before stopping. Initially, I could hear a motor or compressor running for about 30 seconds while initially driving the car. Since then, I've not heard any sounds from the suspension and it consistently says that the suspension is either not available or not functional in the driver heads up screen. Tesla is forcing me to pay for this repair, it is uncertain or unclear whether this should be covered under a recall, especially considering the issues on Suspension faced in China. Tesla has ridiculous wait times at their service centers - it will take me at least until late July to get this fixed.

Filed Apr 14, 2024 · Brakes, Steering · CA

Recall issue for my vehicle. Have been having issues with the auto steer/auto pilot that comes in the car. The auto steer automatically goes off and whenever you make a turn, there's a weird sound.

Filed Aug 1, 2023 · Suspension · CA

Severe inner tire wear on the rear tires of Tesla Model S and X. I have a brand new 2022 Model S Long Range model and started noticing heavy inner tread wear on the OEM tires at only 15k miles. The car defaults the suspension to "Low" which goes into negative camber and wears out the inside of the rear tires. This is a known problem and discussed often online. See such forums from other owners: https://teslamotorsclub.com/tmc/threads/plaid-21%E2%80%9D-rear-tire-woes-factory-defect.269394/page-1 T

Filed Feb 14, 2023 · Suspension, Wheels · GA

My car has 10K miles and rear wheels started to layer off. This is the same issue as many other reporting on the web. I tired to reach out to Tesla but they deny any responsibilities. Something needs to be done ASAP before people will get hurt. I am lucky that I noticed this issue.

Filed Dec 19, 2022 · Suspension · OR

Rear tires have alarming wear on the inside, where the inside sidewall meets the tread. This is identical to the other complaints that are logged on the federal safety agency about Michelin Pilot Sport 4S rear tires on Tesla Model S Plaid cars. Tires are: Michelin Pilot Sport 4S 295/30 ZR21 102Y XL BSW. Specifically, the right rear tires loses pressure and needs to be reinflated. The left rear tire, according to inspection, actually looked worse, but is not yet losing pressure. This is impossible to see or know about without removing the tire or putting the car on a lift, since it is on the is inside sidewall/tread of the rear tire. There is high danger of a blowout because of some type of defect (camber/suspension or tire) which cannot be seen by the consumer. I would have never known about this if the tire technician had not alerted me, and probably would have had a high-speed blowout.

Filed Oct 14, 2022 · Suspension · 10,000 miles · PA

The contact owns a 2022 Tesla Model S equipped with Michelin tires, Tire Line: Pilot Sport 4S Tires, Tire Size: 295/30/ZR21, DOT Number: 4M5203DX4321. The contact stated that while driving at various speeds, TPMS warning light was illuminated. The contact took the vehicle to an independent mechanic where it was discovered that the tread inside both rear tires had severely worn to the extent that the wires inside both tires were exposed. The contact was informed that the failure could have led to a severe tire blowout. The mechanic also informed him that the failure was caused by a vehicle misalignment. The manufacturer was notified of the failure and the contact was informed that a diagnostic test was needed to determine the cause of the failure. The tires were not replaced. The failure mileage was approximately 10,000.