2019 Tesla Model X suspension problems

Filed Apr 7, 2026 · Suspension, Wheels · CA

On March 6, 2026, at 7:15 PM, the rear lower control arm on my 2019 Tesla Model X Raven catastrophically failed while traveling at 55 mph. The suspension component snapped without warning or impact, causing an immediate and dangerous loss of vehicle stability with my children inside. I was forced to perform an emergency stop on the narrow shoulder of US-395, an unlit one-lane highway with a 65-mph speed limit. Because the vehicle was disabled in a remote, dark area, my family was stranded in a hazardous high-speed traffic zone until 10:30 PM waiting for a tow. This failure matches the casting fracture defect described in Tesla Service Bulletin SB-25-31-002. I am reporting this as a severe safety defect that placed my family in a life-threatening situation. There were no warning lights to advise of the failure. Incident details: Mileage at Failure: 76,980 miles Date/Time: March 6, 2026, at approximately 7:15 PM Speed at Failure: 55 mph (Speed Limit: 65 mph) Emergency Pull-over: Yes

Filed Mar 31, 2026 · Steering, Suspension · IL

I have replaced several sets of tires with this Tesla Model X 2019. After years of dealing with a front end alignment problem, I finally had the repair done with some assistance from Tesla. When I purchased my vehicle under warranty, I reported problems with steering and pulling to one side, but they repeatedly claimed they couldn't replicate. This was before they allowed customers to drive with the repaid team. I mention the front-end problems as that has coupled with the rear tires. Inner wear is a consistent problem. I went to Costco today to have them look at tires I bought in November of 2024 and they said the tire was balding and unrepairable. In fact the tires were showing wear on both sides and needed to be replaced. A full set costs $1400.00+ and this is the second time I'm having to replace tires for wearing out quickly. There's a fix online from a company "N2itive". On their website they state, "The N2ITIVE SX-2 adjustable rear camber arms are designed to address the common inner tire wear issues that plague the Tesla Model S and X. These arms are available in the Red and Natural Anodized finishes with a 3-Year Warranty or the Black Anodized finish with Lifetime Warranty and work best when used in conjunction with our TSX-2 Toe Arms." External companies are standing up lines of business based on Tesla's failures. This is a problem and someone is going to get hurt, or worse.

Filed Mar 3, 2026 · Suspension · VA

Vehicle: 2019 Tesla Model X VIN: [XXX] Component: Suspension/Steering/Drivetrain Defect Description: Three concurrent Technical Service Bulletin failures: 1. TSB SB-21-39-001: Front drive unit halfshafts premature failure (manufacturing defect, pre-May 2019 builds) 2. TSB SB-20-32-004: Steering intermediate shaft corrosion due to inadequate road contaminant protection (design defect) 3. Ball joint/control arm water ingress from inadequate sealing (design defect) All three TSBs failing simultaneously at 177K miles. Vehicle purchased April 2019, within affected population for all TSBs. Tesla issued technical bulletins acknowledging these as defects but requires customers to pay full repair cost ($6,337). Local service management admitted not reading TSBs when reviewing goodwill request. After escalation, received 32% cost-sharing. Three concurrent TSB failures suggest systemic design/manufacturing issues warranting recall consideration. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 29, 2025 · Suspension · WA

I got my suspension replaced on my 2019 Model X (that I bought used from Tesla directly) in June 2023. Tesla was suppose to do a through 140 point inspection before putting the car for sale on their website but after less than 2 years and 15000 miles (after the suspension was replaced). The same suspension same issue came up. Tesla told me that they need to replace the suspension again and will bill me $2100. I have owned multiple cars but I have not have to replace suspension on any of my cars ever. How can a suspension fail first at 35000 miles and then again 15000 miles. This seems like Tesla is knowingly putting faulty parts in the car to keep making money on parts and labor. This should be looked into and investigated by National Highway Safety. And Tesla should issue a recall for these and replace them with good quality parts.

Filed Nov 22, 2024 · Suspension · CA

To Whom It May Concern, Service bulletin SB-21-39-001 [XXX] ) was issued for the front half shaft repair for model X, S. In my case, the repair work was done but did not address the issue. They only replaced the parts, and after two years the problem still occurs: vibrations at accelerations, etc. I had to pay over $2000 for the same work, which will probably not address the issue in the permanent matter. Tesla, especially, Model Xs has issues with front half shafts, and I want to encourage the federal safety agency to look into this bulletin and mandate Telsa to repair the vehicle with a more permanent solution and provide reasonable repair costs in doing so. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 5, 2024 · Suspension · CA

The suspension is making loud clicking noises when turning or accelerating. The suspension system seems to have an inbuilt design flaw as many people are reporting the issue online.

Filed Feb 15, 2024 · Steering, Suspension · CO

I was just out of warranty and have a VERY loud squeaky noise when I turn my wheel. I was told that because of the weight of the battery, this can happen. I was told it was not an expensive fix but now they say it's $3,000. It is a known issue and the engineers didn't build to hold the car up properly with the weight of the battery. May be a potential hazard and I don't feel safe driving it and also hard to drive as loud as it is. If they are aware and have since fixed this issue, my car should be fixed at no cost to me. For the record, they took off the cost of the estimate and put all zeros which I also found to be odd.

Filed Jan 13, 2024 · Suspension · CA

Hello, It's [XXX] again. This Tesla has just showed up in the junkyard. [XXX] It has not been in a crash, the back wheel and suspension have simply wrenched themselves off. Information from within Tesla proves that these suspension defects have been known about by Tesla for many years but rather than fix the problems they are covering it up and blaming the owners. [XXX] Proof of this can be found here [XXX] The VW "scandal" involved VW covering up slightly smelly exhaust emissions. The Tesla scandal involves negligent homicide. PLEASE TAKE ACTION AND HOLD TESLA ACCOUNTABLE INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 8, 2023 · Driver assistance, Electrical · 55,482 miles · MD

The contact owns a 2019 Tesla Model X. The contact stated that while turning the steering wheel, there was an abnormal sound coming from the front end near the tires and wheel wells. There was a vibration in the front end of the vehicle while driving. The Autopilot feature became inoperable. The "Autopilot camera unavailable" message was displayed. While driving, the instrument cluster went dark. The vehicle was taken to the local dealer, where it was diagnosed that the failure was due to a possible camera blockage. The ball joints and control arm were resealed. The vehicle was calibrated and informed that the vehicle was working as designed. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 55,482.

Filed Mar 14, 2023 · Suspension, Wheels · CA · crash

At the low speed, the car suspension failed (most likely the control arm) and the vehicle swung to the right and crashed into the car bridge rails. As a result of this, the right front wheel dislodged completely, which would not be possible if there were no mechanical problems with the suspension. Tesla Dublin had worked on my suspension three weeks prior to the accident. The full video from the dash cam before and after the accident is available below. https://drive.google.com/drive/folders/1gbVniik6OTrQHAek_k1OfzSAld3btUcu https://share.icloud.com/photos/0019fXn5YAMpzr2s9Yq0oTnfA