Tesla Model X tire blowout problems

Filed Oct 8, 2026 · Tires · CA

Safety Investigation Team, I am filing an urgent safety complaint regarding dangerous and premature inner-edge rear tire wear on my 2022 Tesla Model X. I have already been forced to replace five tires due to excessive inner-edge wear, which I believe is caused by improper rear suspension camber. Despite repeatedly raising this concern, Tesla has failed to provide a permanent solution. This is a critical safety hazard, not routine tire wear. The damage occurs on the inner edges of the tires, making it difficult to detect and creating a serious risk of sudden tire failure, loss of vehicle control, and potentially catastrophic highway accidents. Similar complaints from other Model X owners suggest a possible widespread suspension-related defect. I strongly urge the federal safety agency to investigate the 2022 Tesla Model X rear suspension design and determine whether an immediate safety recall or mandatory corrective action is warranted before lives are lost. Sincerely, [XXX] [XXX] [XXX] 2022 Tesla Model X Owner INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 17, 2026 · Suspension · 48,000 miles · CA

The contact owns a 2023 Tesla Model X. The contact stated that while his wife was driving 65 MPH with Full Self-Driving mode activated, the rear passenger’s side tire exploded. The message “Loss Pressure Rear Tire" was displayed. The contact's wife nearly lost control of the vehicle but was able to drive slowly to the residence. The contact took the rear passenger’s side tire to a tire retailer to be replaced. The vehicle was then taken to the tire retailer, where the contact was informed that the vehicle was too heavy for the tires, which caused the tires to warp. All four tires were replaced, and a rear suspension alignment was performed. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 48,000.

Filed May 30, 2026 · Wheels · UT

To Whom It May Concern, I am writing to you once again to emphasize and provide additional details regarding the critical safety issue I previously addressed concerning the Tesla Model X vehicles, which is similarly affecting Tesla Model S models. My personal experience underscores the severity of this problem: I have had to replace six tires due to accelerated inner wall wear in the last 5 months. This specific wear pattern is a direct result of improper camber alignment, an issue that Tesla has continuously refused to rectify. This problem is not isolated to my vehicle alone. A growing number of Tesla Model X and Model S owners have reported similar experiences, indicating a widespread and systemic issue. The accelerated inner wall tire wear poses significant safety risks, as it can lead to unexpected and dangerous tire failures on the road. Despite the clear evidence and numerous complaints from Tesla owners, Tesla has consistently declined to address this issue adequately. It appears that the company’s reluctance is rooted in the fact that proper repair or recall to fix the camber alignment is not cost-effective from their perspective. However, this cost-cutting measure is putting drivers and passengers at risk. Given the scale and gravity of this issue, I urge the National Highway Safety Institute to take immediate action. It is essential to investigate these recurring problems with both the Tesla Model X and Model S models. The safety of Tesla drivers, passengers, and the general public is at stake, and a thorough investigation could compel Tesla to take the necessary corrective actions. Thank you for your attention to this urgent safety matter. I trust that the National Highway Safety Institute will act promptly to ensure automotive safety and hold manufacturers accountable for their vehicles’ reliability and safety.

Filed Apr 13, 2026 · Steering, Suspension · CA

The failure involves the rear suspension system, specifically suspected rear control arm / suspension linkage play, which caused severe misalignment (rear toe out of specification). The vehicle is available for inspection upon request. This defect created a significant safety risk. The abnormal toe condition caused rapid and uneven tire wear, with both rear tires becoming nearly completely bald within less than 7,000 miles. This condition increases the risk of tire blowout, loss of traction, and potential loss of control at highway speeds. The issue has been confirmed by an independent service center (Les Schwab), which documented suspension play in the rear control arm area and alignment out of specification (rear toe approximately +1.20° total). The alignment could not be maintained, indicating an underlying mechanical issue. Tesla inspected the vehicle but stated that no suspension components required replacement and attributed the issue only to alignment. However, alignment does not go out of specification without a mechanical cause. Despite multiple requests, Tesla refused to provide detailed documentation regarding the inspection or repair of the suspension system. They replaced only one rear tire and did not address the root cause. The other rear tire had already worn completely bald. After approximately 5,386 miles, the replacement tire has again worn down close to the minimum safety limit, demonstrating that the underlying issue was not corrected and continues to affect vehicle safety. There were no warning lights or system messages prior to the failure. The first symptoms were abnormal tire wear, increased energy consumption, and unstable driving behavior at highway speeds, which began shortly after vehicle purchase. This appears to be a repeat safety-related defect that has not been properly diagnosed or repaired.

Filed Jan 26, 2026 · Tires, Transmission · 78,886 miles · AZ

The contact owns a 2018 Tesla Model X equipped with Lexani Tires, Tire Line: LX-20 Performance, Tire Size: 265/45/R20, DOT Number: 1TBA7B95C3724. The contact stated that while driving at an undisclosed speed, there was a loud sound coming from the front of the vehicle. After the vehicle was inspected, the contact observed tread separation on the driver’s side rear tire, and that the top tread portion of the tire was separating. Due to the tire failure, the vehicle became inoperable. Additionally, the transmission failed to properly shift into park(P), and there was a wiring harness failure following the failure. Due to the failure the vehicle was not drivable and required to be towed. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The contact stated that the failure was associated with the federal safety agency Campaign Number: 23T009000 (TIRES). The tire was a replacement tire. The tire failure mileage was approximately 8,000. The vehicle failure mileage was approximately 78,886.

Filed Jul 20, 2025 · Suspension · CA

Tesla Model X are already known to wear out the rear tires on the inside edge due to excessive negative camber, or wheels tilting inwards from the top. Lowering the suspension setting makes the wheels tilt in even further! This causes more the weight of the car to rest on the inner shoulder of the wheel. Driving this way quickly wears down the inside edge of the rear tires which can cause a sudden and unexpected dangerous blowout

Filed Jun 14, 2025 · Suspension · VA

Hello - I'm having extreme Inner tire wear on rear tires due to a bad camber arm design on my Tesla model X. The negative chamber is way outside of normal standards. I had an issue recently where my tire blew out. I did not notice until I had to replace it. I have changed tires three times in the last year. That's just egregious.

Filed May 16, 2025 · Suspension · FL

This vehicle suffered a flat tire on the left rear at 20,000 miles. It was discovered that the tire had worn out on the inside prematurely due to a faulty negative camber alignment. The other tire on the right rear was examined and found to be worn down to the treads on the inside as well. I informed Tesla and they said this is normal for the make and model. You cannot see the inside of these tires during a normal walk around inspection. Tesla says that the problem cannot be fixed. I could have suffered a tire failure at high speed which could have been catastrophic. Tesla just says its unfortunate and you have to live with this issue. i consider this to be a very unsafe issue that Tesla should address at their expense. This car is under warranty and Tesla refused to repair the car.Tesla did not divulge this issue to me prior to purchasing the vehicle.

Filed Feb 20, 2025 · Suspension, Wheels · CA

The tire blow up on the freeway while driving with no impact, collision or any warning or any external factors, it’s very well documented all over the internet that Model X Tesla have serious Tire problems associated with faulty tire pressure system TPMS and in accurate tire reading as well with a car alignment that don’t compensate or adjust for the air suspension height changes that is available within the car settings and that causes a rapid and dangerous uneven tire wear that could lead to a tire failure on the road while driving. Tesla just recently recalling 700,000 cars with tire pressure issues and my car is effected as well because we never received any warning before the blowout. We did inspect the tire and documented everting showing no evidence of any that went through the tire to cause it go flat, the car is 8 month old and everything is fairly new and we should never have to deal with such and event that almost got us killed on the freeway, also since we were forced to exit the freeway for our safety driving on a flat tire that did cause a serious damages to the tire and vehicle with no spare wheel available to get it replaced on the spot to prevent any further damages, the car is not safe to be driven with serious Tire Pressure and bad alignment that comes from the factory that don’t match the suspension profile selected by the user that puts lots of unnecessary stress on the tire that causes a serious dangerous event to happen anytime. Tesla is refusing to take any responsibility for this issue even though it’s very well documented and we end up with a $4500 bill, something that we never should be responsible for. Also Tesla manager Oliver Ftankcom suggested that it’s ok to risk our lives staying in the car and not move it after a flat tire so we don’t cause more damages to the car, but we would of been killed on the freeway waiting for 4 hours for a tow truck to show up, so we had no choice but to exit the freeway for safety with a spare tire.

Filed Feb 15, 2025 · Wheels · NC

To Whom It May Concern, I am writing to you to emphasize and provide additional details regarding the critical safety issue concerning the Tesla Model X vehicles. My personal experience underscores the severity of this problem: I have had to replace over 8 tires in 3 years due to accelerated inner wall wear. This specific wear pattern is a direct result of improper camber alignment, an issue that Tesla has continuously refused to rectify. This problem is not isolated to my vehicle alone. A growing number of Tesla Model X and Model S owners have reported similar experiences, indicating a widespread and systemic issue. The accelerated inner wall tire wear poses significant safety risks, as it can lead to unexpected and dangerous tire failures on the road, which has happened to me. Very dangerous. Despite the clear evidence and numerous complaints from Tesla owners, Tesla has consistently declined to address this issue adequately. It appears that the company’s reluctance is rooted in the fact that proper repair or recall to fix the camber alignment is not cost-effective from their perspective. However, this cost-cutting measure is putting drivers and passengers at risk. Given the scale and gravity of this issue, I urge the National Highway Safety Institute to take immediate action. It is essential to investigate these recurring problems with both the Tesla Model X and Model S models. The safety of Tesla drivers, passengers, and the general public is at stake, and a thorough investigation could compel Tesla to take the necessary corrective actions. Thank you for your attention to this urgent safety matter. I trust that the National Highway Safety Institute will act promptly to ensure automotive safety and hold manufacturers accountable for their vehicles’ reliability and safety. There have been 4 incidents of this happening with my car. Just putting one date below.