2021 Tesla Model Y airbags problems

Filed Sep 24, 2026 · Acceleration, Airbags · CA · crash

On September 23, 2026, the vehicle was being driven at low speed when the driver experienced sudden and unexpected acceleration. The vehicle rapidly accelerated and a collision occurred. The driver reports that she did not intentionally accelerate the vehicle to this degree. Vehicle data and the Event Data Recorder (EDR) were subsequently obtained. The data records the vehicle accelerating from approximately 0 mph to approximately 35 mph in about four seconds, with the recorded accelerator-pedal-position signal reaching 100%. The EDR does not record brake application before the first crash trigger. Vehicle data records driver brake application shortly after the initial crash trigger, including ABS activity. The cause of the accelerator-pedal-position signal is UNKNOWN. It has not been determined whether the recorded signal resulted from driver pedal application, the accelerator pedal/sensor system, or another vehicle system. I am reporting this because of the sudden acceleration and severity of the resulting collision and would like the incident reviewed as a potential vehicle safety issue. The EDR also indicates that airbag and seat-belt pretensioner deployment was not commanded during either of the two recorded crash events. Given the severity of the collision, I am also reporting the lack of airbag deployment as a safety concern. I do not know whether the collision met the applicable deployment thresholds. The vehicle is available for inspection. The EDR report and complete raw vehicle-data CSV have been preserved. There were no known warning messages indicating an accelerator problem before the incident.

Filed Aug 5, 2026 · Airbags · VA

Description of Safety Incident:The front passenger safety restraint system failed, displaying the warning alert: "Seats - Front passenger safety restraint system fault / Service is required." This alert disables or suppresses the front passenger airbag and seatbelt restraint system, creating a direct safety hazard for front-seat occupants.Service History & Recurring Defect:On February 26, 2025 (at 50,596 miles), Tesla Service Center diagnosed an open circuit in the front passenger seat harness/back frame. Under Service Bulletin / SRS Warranty, Tesla replaced the front seat back, seat harness assembly (PN: 1489060-03-G), occupancy sensor (PN: 1099592-00-F), and SBR sensor clip (PN: 1130363-00-B). On August 1, 2026 (at 63,583 miles)—less than 13,000 miles after the initial replacement—the exact same safety restraint system fault recurred.Safety Concern:The front passenger seat harness and Occupant Classification System (OCS) appear to suffer from design strain, pinching, or premature wiring degradation during normal seat movement. Because this defect disables critical safety restraint components and recurs shortly after replacement, I am submitting this report to request a federal safety review and investigation regarding Tesla Model Y front passenger seat wiring harness integrity.

Filed Jul 11, 2026 · Airbags, Seat belts · NC

Recurring front passenger safety restraint system fault causing incorrect occupant detection for airbag deployment. Failed and was ‘repaired’ 3 times since 2024, including 2 consecutive failed repairs of the same part within the last 3 months. Tesla service advisor also mentioned informally this is a common issue. Tesla is now refusing further no-cost repair despite both recent repairs remaining under Tesla’s own parts warranty.

Filed Apr 13, 2026 · Airbags, Electrical · FL

**What component or system failed or malfunctioned, and is it available for inspection upon request?** The vehicle experienced a critical failure immediately on the same day of purchase, rendering it not functioning or inoperable. It was deemed to be preexisting from the dealership I bought it from. The battery is malfunctioning affecting the driving capacity and range. --- **How was your safety or the safety of others put at risk?** The failure created a significant safety concern, as the vehicle was not operating reliably immediately after purchase. This placed me at risk of being stranded and potentially exposed to hazardous conditions, including loss of transportation in unsafe or uncontrolled environments. Or stopping while driving. --- **Has the problem been reproduced or confirmed by a dealer or independent service center?** The issue was immediately reported to the dealership, and they acknowledged the problem by agreeing to an exchange of the vehicle due to its defective condition. It was confirmed by a service center of the car's manufacturer. --- **Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?** At this time, the vehicle has inspected by the manufacturer. --- **Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?** Yes, although the manufacturer can't pinpoint when they started but said they had been on since ATLEAST March 10. My purchase was made April 1, undisclosed to me of this huge issue.

Filed Jun 17, 2025 · Airbags, Seat belts · NM

“Front passenger Safety restraint system fault, service required” RCM2_a636 message keeps appearing on the screen. It happened right after I bought the car, so I took it to Tesla to fix. It went away for a few months and now it’s back again. According to Tesla, this fault, “ Based on the airbag system's self-diagnostic checks, a persistent fault has been detected in one or more safety restraint components. This could involve seat belts, impact sensors, occupant sensors, or related safety components. • If the airbag warning indicator stays on, the vehicle should not be driven until inspected. • Recurring faults require immediate Tesla service attention. • Pre-tensioner or sensor damage can compromise proper seat belt functionality.” This is a serious safety issue that should be addressed in a recall as it could jeopardize occupant safety of the seat belts or air bags do not work. It also appears to be somewhat widespread and persistent. Tesla also does not appear to have a permanent fix as the first time I took it in they made a comment about one repair already having been done on this before I got the car as a certified used one from Tesla.

Filed Apr 14, 2025 · Airbags · 68,400 miles · CA

The contact owns a 2021 Tesla Model Y. The contact stated while attempting to start the vehicle, the message "Front Passenger Safety Restraint System Fault" was displayed on the instrument panel. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 68,400.

Filed Mar 6, 2025 · Airbags, Brakes · 39,264 miles · CA · crash

The contact owns a 2021 Tesla Model Y. The contact stated that while driving at 10 MPH and depressing the brake pedal; however, the vehicle accelerated independently and failed to brake without warning. The contact assured there were no distractions that could have caused the crash. Due to the failure, the contact crashed into another vehicle as the air bags deployed. Despite the air bag deployment, the vehicle continued to accelerate and repeatedly hit the same vehicle. The brake pedal eventually responded after depressing multiple times to the floorboard and the vehicle finally came to a stop. The contact did not sustain any injuries and did not seek medical treatment. The driver of the other vehicle did not report any injuries. A police report was filed. The vehicle was towed from the scene to an independent tow yard. The contact mentioned reviewing the Tesla App on the crash however it was not recorded and there was a recording lag. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was 39,264

Filed Nov 25, 2024 · Airbags, Seats · TX

I have a notice that a sensor went out in my passenger seat. I took it into Tesla to get a quote to repay rid and was quoted $2,000 to fix it. When I asked why it is so expensive I was told it is be cause Tesla has to retrofit my car to fit the new sensors because they stopped making my years sensors, my car is only a 2021. This is safety issue that should be a recall, I have several other friends that own teslas that have had the same issue. The sensor that is not working properly is the sensor that registers if a passenger is in the seat or not determining if the airbag needs to deploy when in an accident. so without a working sensor it puts the passenger at risk. This is something I believe Tesla should covering as it is a safety issue & as a consumer I shouldn't have to pay over the fact they discontinued the proper sensor for my vehicle putting anyone that sits in my passenger seat at risk for the airbag to not deploy in the case of an accident.

Filed Oct 11, 2024 · Airbags, Brakes · 18,850 miles · CA · crash

The contact owns a 2021 Tesla Model Y. The contact stated that his wife was driving at 5 -10 MPH and traffic ahead was slowing down, the vehicle in front stopped and the driver depressed the brake pedal however the vehicle then unintendedly accelerated. As a result, the contact crashed into the rear of the vehicle in front. No warning lights were illuminated and no air bags were deployed. No police report was filed due to no injuries being sustained and the insurance company would be handling the incident. The vehicle was towed to a body center where it was diagnosed that the front air bag sensors were fractured in half and failed to activate the air bags but did activate the seat belts during the impact. The vehicle was not repaired, and the repair decision from the insurance company was pending. A dealer was not contacted. The manufacturer was informed of the failure via the app however the contact was still waiting for a return call to speak with a live agent. The failure mileage was 18,680.

Filed Aug 30, 2024 · Airbags, Electrical · TX

The front passenger safety restrain system keeps switching off and showing an error randomly during driving, especially with younger passengers on the passenger seat. The problem was already fixed by Tesla 4 times and is appearing again.