2001 Thomas MVP Ef recalls

What is wrong

Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. Please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.

Risk

In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.

Remedy

Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. Owners may contact thomas built at 336‑889‑4871.

Recall number 08V087000 · Recall details

What is wrong

Certain 2001 through 2008 thomas built fs-56, er, mvp er, hdx, and mvp ef school buses manufactured from october 23, 2000, through january 24, 2006, equipped with tyco pc board and type ii auto reset circuit breakers. Type ii auto reset circuit breaker temperatures may exceed the rating of the tyco pc board causing the boards to melt potentially resulting in a vehicle fire.

Risk

A vehicle fire can occur possibly resulting in a crash.

Remedy

Thomas built will notify owners and repair the buses by replacing the type ii auto reset circuit breakers with manual circuit breakers, and the jumper cable. The recall began on march 28, 2008. Owners may contact thomas built customer support office at 336‑889‑4871.

Recall number 07V544000 · Recall details

What is wrong

Certain my 1994 through 2002 thomas built minotour, fs-65, mvp-ef, er, and hdx-ef school buses manufactured between january 23, 1994, and april 15, 2002. The seat belt may chafe on the edge of a metal bracket and wear prematurely.

Risk

In the event of a vehicle crash, the seat occupant may not be properly restrained, possibly resulting in personal injury.

Remedy

Thomas built will notify owners and replace any chafed seat belts and replace or modify the retainer strip to prevent any further chafing. The recall began on february 8, 2008. Owners may contact thomas built at 336‑889‑4871 or contact freightliner at 800‑547‑0712.

Recall number 07V142000 · Recall details

What is wrong

Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.

Risk

Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.

Remedy

Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. Owners may contact cummins at 1-800-diesels.

Recall number 05V205000 · Recall details

What is wrong

Certain 2001-2004 my thomas built mvp-ef, er transit, mvp-er, hd, and hdx school buses manufactured between september 24, 2000, and march 4, 2004. The tie rod assembly can fracture and fail, possibly resulting in complete separation.

Risk

Tie rod failure can possibly result in complete wheel separation and a vehicle crash could occur.

Remedy

Thomas built will notify its customers and will replace the tie rod assembly free of charge. The recall began september 6, 2005. Owners may contact thomas built at (we do not yet have a telephone number).

Recall number 05V137000 · Recall details

What is wrong

On certain thomas school buses, the alternator cable can pinch between the air conditioning compressor and engine block.

Risk

This can result in damage to wire insulation and potentially cause a short circuit.

Remedy

Dealers will re-route the cable. Owner notification began july 28, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner/thomas built at

Recall number 03V205000 · Recall details

What is wrong

On certain school or transit buses with passenger seat belts with retractors, the cover halves for the retractable portion of the belt can separate completely and release the seat belt connector. If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury. The seat belt supplier, amsafe, will provide a snap on "over-cover" to owners to prevent the seat belt cover from separating.

Risk

If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury.

Remedy

Dealers will provide a plastic outer cover that snaps over the existing cover on units in the field and will replace broken seat belts free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336‑841‑5924 or amsafe at 574‑266‑8330.

Recall number 02V160009 · Recall details

What is wrong

On certain school and transit buses, the wheel lug nut may not tighten completely.

Risk

The wheel could loosen increasing the risk of loss of control of the vehicle.

Remedy

Dealers will install new wheel studs. Owner notification began february 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336‑889‑4871.

Recall number 02V221000 · Recall details

What is wrong

Vehicle description: certain school buses fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." a third roof hatch must be added to meet the standard requirements. Only vehicles located in the state of washington are involved.

Risk

In the event of a crash, the bus occupant may not be able to exit the bus quickly.

Remedy

Dealers will install a third roof hatch. Owner notification began may 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336‑889‑4871.

Recall number 01V378000 · Recall details

What is wrong

Vehicle description: certain school buses equipped with syntec seats fail to conform to the requirements of fmvss no. 222, "school bus passenger seating and crash protection." some seats (1) fail to meet the required four inch clearance during the test procedure, while still meeting the post test condition; (2) fail to meet the required frontal pre-load when testing under certain conditions; or (3) while still meeting the required force/defection, experience weld breakage.

Risk

In the event of a crash, the seat occupant may not be properly protected.

Remedy

Dealers will replace the seat frame and the seat back cushion on these vehicles. Owner notification began november 13, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336‑889‑4871.

Recall number 01V341000 · Recall details