2000 Thomas MVP problems

What is wrong

Certain my 2000-2003 freightliner, thomas mvp school bus and western stars trucks manufactured between november 19, 2000, and march 30, 2005, and equipped with webasto coolant heaters, model dbw 2010, assembled with webasto burner tubes, p/n 303046/26533a. The stainless steel burner tube is made out of a material that is not to specification and could fail prematurely.

Risk

Should the burner tube fail, the coolant heater could overheat, possibly resulting in a fire.

Remedy

Thomas built will notify its customers and replace the subject burner tubes with new certified burner tubes at no cost to the owner. The recall began on november 16, 2005. Owners may contact thomas built customer support office at 1‑336‑889‑4871 or contact freightliner at 1‑800‑547‑0712.

Recall number 05V207000 · Recall details

What is wrong

Certain school buses with weldon technologies' 5050-1400 surface mount marker lights have an option to replace each of the twelve clearance/marker/identification lights with four-candlepower lights, twice the candlepower normally used. The higher current demand created by these lights can cause excessive heat through the headlight switch connection if a relay is not installed between the combination tail/marker light circuit and the headlight switch.

Risk

This can result in deformation of the plastic connectors that connect the headlight switch to its wiring harness.

Remedy

Dealers will install a relay to reduce the current draw through the headlight switch. Owner notification began september 8, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1‑336‑881‑7219.

Recall number 00V174000 · Recall details

This investigation was opened after odi received notification from two fleets alleging thediscovery ofnumerous seat belts with cut webbing as a result of the webbing abrading against anunderseat metal bracket.the subject vehicles are class a school buses weighing under 10,000 pounds.they are required by federal standard fmvss 208 to have seat belts.as a result of this investigation, freightliner will conduct a safety recall to inspect all affected buses for seat belt ?chafing? And will replacedamaged belts as needed. Also, the seat belt retainer strip will be modified or replaced to prevent future chafing.freightliner expanded the scope of the recall (beyond the original investigation population) to include approximately 10,251 additional buses having gross vehicle weight ratings greater than 10,000 lbs.they determined that these buses are also susceptible to the chafing action.there is no federalrequirement for seat belts in school buses weighing over 10,000 pounds.however, some customers have ordered seat belts and some states have requirements for seat belts.therefore, freightliner has agreed to address those buses even though there is no applicable federal standard.the recall action taken by freightliner resolves the issues raised by this investigation.accordingly, this investigation is closed.

PE06057

See attached four page technical report for details.

EA04014