2004 Volkswagen Beetle recalls
There are 3 safety recalls on record for the 2004 Volkswagen Beetle, covering 1,098,184 vehicles in total across all the models in each campaign. Newest first.
All recalls
Air bags: frontal: sensor/control module-inactive
- What is wrong
- Volkswagen is recalling 76,900 my 2004-2005 new beetle and my 2003-2005 new beetle convertibles equipped with an advanced (dual-stage) air bag system. This system may have air bag frontal crash sensors that contain a solder joint on the circuit board that may crack under certain high temperature conditions. If this occurs, the air bag indicator light will illuminate and the fallback algorithm will ensure that the front air bags always deploy in a frontal crash in which the vehicle's deceleration is high enough to activate the frontal air bags.
- Risk
- In low-severity frontal impacts, the front air bags may deploy more forcefully than designed, increasing the possibility of injury to out-of-position front seat occupants.
- Remedy
- Dealers will inspect each vehicle to determine that the specific defect crash sensor is present on one or both sides of the vehicle. All of the defect crash sensors will be replaced free of charge. The recall is expected to begin on or before july 31, 2008. Owners may contact volkswagen at 1‑800‑822‑8987.
Recall number 08V178000 · Recall details
Exterior lighting: brake lights: switch
- What is wrong
- On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.
- Risk
- The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.
- Remedy
- Dealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06v‑183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact vw at 1‑800‑822‑8987.
Recall number 07V063000 · Recall details
Fuel system, diesel
- What is wrong
- On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.
- Risk
- Fuel leakage in the presence of an ignition source may lead to a fire.
- Remedy
- Dealers will replace the diesel pump. The recall began on february 8, 2005. Owners should contact volkswagen at 1‑800‑822‑8987.
Recall number 04V586000 · Recall details
Questions about the 2004 Volkswagen Beetle recalls
How do I check if my 2004 Volkswagen Beetle has an open recall?
Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.
Do I have to pay for a recall repair?
No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.
How many recalls does the 2004 Volkswagen Beetle have?
3, covering air bags, exterior lighting and fuel system, diesel.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Volkswagen Beetle?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history