2012 Volkswagen Golf engine problems

Filed Jul 23, 2018 · Engine, Fuel system · 123,986 miles · CA

Tl* the contact owns a 2012 volkswagen golf. While driving 5 MPH, all of the warning indicators illuminated and the vehicle stalled. Moss brothers volkswagen of moreno valley (27750 eucalyptus ave, moreno, valley, california 92555, (951) 485-4188) was made aware of the failure and stated that the fuel system was contaminated. The vehicle was not repaired. The manufacturer was made aware of the failure and provided the contact with case number: 180-76-1675. The failure mileage was 123,986.

Filed Mar 9, 2016 · Engine · CA

Smog control fraud with diesel engine

Filed Sep 17, 2015 · Engine · 27,525 miles · CA

While coming to a stop at a red light, heard a slight ringing sound as the engine slowed down and stalled right as we stopped. The engine would not restart and the "coils" warning light was illuminated in the dash board. Several attempts were made to restart the vehicle as we waited for a tow truck. The problem was with a failure of the high pressure fuel pump (hpfp). The vehicle was towed to the dealership. We were without a vehicle for over a week as the fuel was being tested for contamination (which there was none) and waiting approval from volkswagen for approval under warranty coverage. This is the second problem with the fuel system on this car. There was a previous problem with a leaking fuel rail (leaving a puddle of diesel fuel in a parking lot) which was covered with a warranty repair while on a vacation.

Filed Aug 21, 2014 · Acceleration, Engine · 32,378 miles · CA

2012 vw golf tdi (diesel) vehicle began losing power on acceleration from a stoplight and began clicking. Check engine and glow plug lights flashed. Power was reduced to 15% and limped to shoulder. Shut off engine and attempted restart. Engine turned over but no ignition. Towed to dealer who confirmed that high pressure fuel pump had failed. Dealer replaced high pressure fuel pump, tank pump, high pressure fuel lines, fuel rail with both sensors, all injectors, fuel return lines, fuel filter, and aux fuel pump. Tank and fuel lines were flushed and cleaned. All repairs done under vw 60k powertrain warranty.

Filed Feb 1, 2014 · Engine · 51,245 miles · VA

First incident was 1/06/14. My wife was a week over her delivery date tried to start the car and it tried to turn over but wouldn't start. Eventually called dealer who had her tow it in to them. The dealer informed her of moisture in intercooler pipe which they blew out with an air hose and charged her $48 (they said it is normally about $150). They informed her it was due to driving short distances & the cold weather; that diesels needed to be driven long distance only. The 2nd incident was 1/30/14. My wife & newborn were running errands in town when the car engine malfunction light came on & she pulled over to check on it. The car then would not start & again had to be towed to dealer. This time they pulled a big chunk of ice from inter-cooler pipe and said the inter-cooler had to be replaced & cold weather kit installed (est. $1100). A quick search on-line shows this is not a new problem & vw has been aware of it on north american diesels for several years yet they have failed to inform new buyers or fix the problem. Also many owners who have gotten vw's "fix" (cold weather kit) say it has not solved the problem. If we had know their diesels could not be driven in the winter or for short distances we definitely would not have bought one. Leaving any one stranded in the winter is bad but leaving my very pregnant wife & my newborn baby is something I can't put up with. Because vw doesn't admit to having a design flaw I am going to have to foot the bill for something I have now control over but vw does. On top of that I may have the same problem within a week due to an unforeseen event called "winter" if their fix doesn't work. If knowing you have a design flaw in your vehicles that leaves owners stranded at the worst possible time (winter) does not constitute a safety issue & deserve immediate attention&accountability if not a recall then I'm not sure what does.

Filed Jul 11, 2013 · Acceleration, Engine · 13,000 miles · DC

Car purchased november 2011. August 29, 2012 (much <10,000 miles) reported rough shifting of automatic transmission to volkswagen of alexandria. Told that experience was normal. Trusted mechanic and used vehicle. March 18, 2013--complete transmission failure while driving in a parking lot. Engine shut off while moving and abruptly brought car to a stop. This is the same problem that prompted recalls for this car in australia, china, and japan. Brought into volkswagen of alexandria and told problem was related to computer errors controlling transmission. July 10, 2013--(@15,000 miles) car loses reasonable amount of power, makes grinding noise, engine light appears. Blocks from volkswagen of alexandria. Just able to make it in. Technicians report that a number of faults were reported and have contacted vw of america to advise what to do next. Ultimately they decide that the mechatronics unit (part of transmission) should be replaced but will not be available soon. Alexandria volkswagen advises me to take the vehicle back into my posession and drive it as is until the part arrives. They claimed it to be just a noise issue. I object and have to point out the complaint about severe lack of power and previous complete engine/transmission failure (which they claimed to be unrelated). After complaint told I could rent a car. Finally able to complain my way into a loaner. I have read about this tactic for ways around lemon law liability. Was advised to report it here.

Filed Jun 6, 2013 · Engine, Transmission · 4,600 miles · CA

While operating the vehicle under normal conditions, I heard a rattle from the engine, followed by the sound of something rattling in the engine compartment and then falling out. The engine died immediately and I was able to coast to the shoulder. After the dealer inspected the car they found that the water pump was faulty and it caused the water pump pulley to come off and cause damage to the cylinder head, valves, cover, water pump, and timing belt, in addition to the water pump pulley falling off. The dealer then told me this was a known issue for this make and model and that they had made the same repair to several other models in their service department. They advised there was an updated water pump part that had components made of metal rather than plastic to withstand the engine heat, which was what caused my water pump to fail. Additionally, my vehicle was in for a regularly scheduled maintenance appointment days earlier and the dealer neglected to check the water pump or advise me that it might be faulty, even though they knew and admitted later to it being a known problem with the car.

Filed Jan 6, 2013 · Engine, Transmission · 14,386 miles · FL

On 12/24/2012, returning from a restaurant with my family, I heard a bang and my engine died while driving on a city street at 35 MPH. I was able to safely put the car in neutral and roll off the street. I found out on 12/26 that my water pump had fallen apart, destroying my timing belt and engine head. Several vehicles with the build date of my car have experienced water pump failures that destroy the timing belt and cause catastrophic engine failures. Luckily, I was traveling at a slow speed when the incident occurred. Vw claims to not know about "a widespread problem." I was also told that no superseded part is being installed; the same water pump part is being put back. The dealer replaced the head, pump, belt, misc bolts, etc. I am worried about my safety that this incident will re-occur. Http://forums.vwvortex.com/showthread.php?5854747-consolidated-water-pump-failure-thread http://forums.vwvortex.com/showthread.php?5813173-golf-r-water-pump-madness!!!!

Filed Dec 17, 2012 · Engine, Fuel system · 7,500 miles · CA

The car is a 2012 vw golf tdi, purchased around april of 2012. It had approximately 7500 miles at the time of the incident. I was on a short drive to the store and back (5 miles round trip from home). On the way back, I heard a metal grinding sound coming from the engine compartment and noticed a lack of power. I turned off the radio to confirm that the sound was coming from my new car and it was. At the next stop light, the car died and could not be restarted. I confirmed that I still had diesel fuel, and sure enough, I still had 1/4 tank. So I was not out of fuel. The engine would crank, but not start. Thankfully this happened at a stop light instead of on the hilly interstate I take to work 20 miles each day. Aside from hearing the metal grinding sound for approximately 30 seconds, I had no warning. The car had to be towed back to the dealer. The dealer took a few days to diagnose the problem as a faulty fuel pump. Apparently, the fuel pump malfunctioned and shot metal shards through my entire fuel system. It took the dealer well over a week to replace every component and the cost of labor and parts was over $10,000. Thankfully, vw covered the repair as being under warranty. A quick google search confirmed that hundreds of other vw diesel engines have had the same problem. Unfortunately, the dealer did not replace the fuel tank. Based on reports I have seen online, I can expect another failure any day. Please investigate this further and force vw to issue a recall. I have owned 5 volkswagens in the past (own 2 right now) and love them, but I will never buy another one after this incident.

Filed Oct 15, 2012 · Engine · 2,766 miles · FL

At 2766 miles I was cruising down the highway at 70 MPH on my way to work when the engine suddenly lost power and the epc light came on. The engine was completely unresponsive, I pulled off to the shoulder, called roadside assistance and was towed to the nearest dealer the service manager told me the water pump seized and seriously damaged the engine. I went to look and there was a big hole in the side of the engine. He told me they had to order new piston heads, rods, etc... Basically, needed to rebuild the engine. Speaking to the mechanic actually working on the car, he said it would probably need an engine replacement. They quickly realized repair wasn't possible and had a new engine en route. After a little searching online, I found that this has happened to at least 5 others (there are more now). It seems to be an issue with the water pump pulley. I am most concerned because vw denied they had ever heard of this. I have no confidence that the replacement engine will not suffer the same issue.