2023 Volkswagen GTI technical service bulletins
291 technical service bulletins and manufacturer communications cover the 2023 Volkswagen GTI, including 2 warranty extensions.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the...
- Prevent Sporatic Misfire Faults.
- Checking engine oil level.
- Reprogramming Control Module process
- Water Migration under RAPGARD® during PDI
- Condensation and or water droplets visible on inside of exterior light lenses
- Condensation
- This OTA update addresses a potential issue with special characters being broadcast over HD radio.
- Engine missfire diagnostic aid
- Identifying and Mixing Volkswagen Engine Coolants
- When replacing Evaporative Emissions System components, it is not always necessary to replace the entire...
- Safety Related Inquiry and Reporting
- Heat Sensative Trouble Shooting Explanation.
- Suggested fuel additive
- This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
- Brake rotor resurfacing
- Repair or Replace Information
- Steering wheel sensor mat (hands on detection) and software deviation in the steering wheel detection...
- Warranty Alignment Worksheet
- Replacement instruction
- Permission to change Daily Order upgraded to RED Order
- Differences between a leak and seepage
- MIB3 Recovery Solution
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Over-the-Air Software Update Dealer Recovery Process
- Oil Consumption Measurement and Electronic Oil Consumption Measurement
- Lubricating engine components before reassembly.
- Instruction, how to lubicate engine before initial start.
- Your vehicle is currently eligible for the 91UB software update designed to
- Inquiries
- Volkswagen Engine Oil Standards
- Emergency Call Module
- Difference between Component fluid leakage and seepage
- Condition is normal due to cold fresh air and humidity
- Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer reports that the vehicle performed an unwarranted Autonomous Emergency Braking (AEB).
- Damage Inspection of Park assist sensors
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Paint color and/or finish of the engine compartment may not match the exterior paint color
- The federal safety agency has issued an urgent warning regarding counterfeit replacement airbag inflators...
- Engine Light ON, DTCs P2004,P2006,P2014 or P2015 Stored in Engine Motor Control Module, Replace Intake...
- Guided Fault Finding Requirement for Component Replacement
- Update Infotainment Software for various issues
- Update Programming software of the Engine/Motor Control Module -J623- to improve thermostat performance.
- Hardware deviation of the steering wheel touch detection.
- Assessment of Damage to steering wheel leather
- How to handle a suspected paint flaw during PDI
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Diagnosis for Excessive Current Draw.
- Alignment Submission Form
- PDI Instruction
- A "How To" activate Car Net® 2.0
- What is and what is not a leaking suspension strut.
- Contamination within the Intake maniold runner control module causing the valve to stick closed.
- This special notice is to inform dealers to return the parts listed and only order the successor parts...
- Warranty Instruction and guidance
- Identify and resurfacing brake rotors.
- Alignment sheet submission.
- Replace steering wheel cover.
- Update programming Front Camera
- Coolant Bleed Procedure
- Update Programming
- Engine misfire diagnostic aid.
- EVAP and Leak Detection Pump replacement components.
- G12Evo can now be mixed with previous coolants.
- Cautions about using aftermarket transmission flush machines and aftermarket transmission fluids.
- How to measure engine oil consumption.
- Diagnosing Manual Transmission Noise
- Proper engine oil level before leaving the factory.
- Fuel Additive to prevent sporatic misfire
- A list of suggested fuel stations
- GFF Requirements regardless of concern plus System flush requirement
- Activation
- Fuel Additive
- How to activate CAR NET including additional diagnostics
- How to identify and when to replace a leaking strut
- What to do if customer mentions water droplet within tail lights.
- This OTA update provides improvements to GPS positioning accuracy in the navigation system and the...
- Remote Key Battery Replacement
- Volkswagen Engine Oil Quality Standards (U.S. Only)
- The diagnostic code B2F0100 with symptom code 1124417 in the front sensors/front camera for driver assist...
- Using Alignment Sheet Submission Form
- MIB Recovery Solution
- Update Programming Parking Aid Control Unit
- Steps to perform when a
- Warranty brake rotor machining is allowed between 6 and 12 months or 6,000 and 12,000 miles
- Volkswagen Engine Oil Quality Standards
- Installing Software revision
- Brake Repair or Replacement Information
- Transmission Control Module (TCM) Software
- What to do if accessory pack is missing, incorrect or damaged during Perfect Delivery Inptection.
- EVAP Components replacement
- Identifying and Mixing Engine Coolant
- CV Boot replacement
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Water migration under the RAPGARD® protection when vehicle arrives at dealership.
- Replacing cretain control modules will require specific Guided Fault Finding (GFF) direction.
- Internal Moisture Accumulation
- Moisture witin rear tail lamp assembly
- HVAC duct cleaning and deodorizing
- Engine Oil Standards
- Lack of paint under roof
- Replace Steering Wheel Steering Wheel Sensor Mat
- Additional reporting
- Green Light Does Not Illuminate
- Vehicle Concerns Before Recall Repair Available
- Inspecting sensors for damage
- The purpose of this Technical Bulletin is to inform Volkswagen dealerships that beginning on 10/1/2024,...
- How to perform the engine oil consumption measurement
- Engine Misfire Diagnostic Aid
- How to manage software versions using VW diagnostic Tool
- Checking Engine Oil and correctly reading dip stick
- A list of engine oil that meet Volkswagen Engine Oil Standards
- Fluid requirements
- Wind & Water Leak Checking
- Fuel additive to help with misfire faults
- Recommended Gasoline Quality
- Manual transmission noise diagnosing
- Travel Assist Not Available due to hardware deviation of the sensor mat (hands on detection).
- Battery testing
- Car-net® 2.0 may not fully complete the initial Register and Pairing process (R&P) after removal of
- An engine cover was either not installed during vehicle production, or was removed as part of a previous...
- Phyical condensation within Taillamp cluster is an optical phenomenon and does not affect the function of...
- Mandatory Fastener Replacement
- Engine No Start, ECM shorted due to incorrect battery removal
- Engine Replacement Tip
- Engine Assembly Tip
- Engine Oil Pressure-Priming
- Engine oil quality standards
- After the pre-delivery inspection (PDI) has been performed (transport mode has been deactivated), the...
- Remnants of the valve stem seal on the valve guide can interfere with the installation of new valve stem seals
- Incorrect assembly of the rubber lip/seal (between hood and headlight
- Infotainment software updated to 3700
- Forigen objects inside seat belt buckle
- Contamination within Intake Runner Control Valve (N316)
- Hardware-related deviation of the sensor mat ("hands on detection") in the steering wheel and...
- VW Engine oil quality standards
- In certain vehicles equipped with a manual transmission, the shift knob could become detached during use
- Volkswagen is providing an owner's manual supplement that describes a revision in the Tire load and...
- Various Issues with heated steering wheel
- Air Conditioning, Cleaning of the R1234yf Refrigerant Circuit (U.S. Only) updated to adjust Flush machine...
- On vehicles of a limited production period, because of a data bus diagnostic interface software fault...
- Engine Crank, No Start or No -J623- ECM Communication with DTC U0100 Stored in ECM Fault Memory
- Remote Key testing & replacement.
- Headlamp: Rubber lip-seal (between headlight and fender) loose
- A/C Compressor leak diagnosis
- Addressing Cybersecurity or Vehicle Hack concerns
- Airbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
- To ensure that the customer is familiar with the various Driver Assist systems and the system limitations...
- Paint inspection during Perfect Delivery Inspection (PDI)
- Reporting procedure for A/C compressor replacement regardless of the reason for failure
- Various driver assist features do not work or are able to be switched on.
- MIB infotainment system recovery for unresponsive condition.
- Headlamp rubber lip seal repair.
- Travel Assist Not Available
- Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger
- Flushing an R1234YF A/C circuit using a flush machine
- Update to Volkswagen engine oil standards
- Helpline & Parts Dept
- Brake repair or replacement instruction.
- Diagnostic assistance for excessive static current draw
- How to handle Brake noise or Pulsation during Perfect Delivery Inspection (PDI)
- Brake Disc (rotor) instruction for resurfacing following Volkswagen Warranty Policy & Procedure Manual.
- Volkswagen Engine oil quality standards, update to attachments.
- Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
- Software Version Management (SVM) instruction.
- Correct engine oil level during Perfect Delivery Inspection (PDI)
- Automatic Transmission Fluid Requirements
- Engine Oil Consumption Measurement Instruction and Work sheet.
- Volkswagen Engine Oil Standards, updated to include model year 2024.
- Diagnostic Aid for engine misfire.
- Gasoline fuel additive
- Gasoline quality information in regards to gasoline engine performance.
- Noise Diagnostic for Manual Transmission vehicles.
- Notifying customers they can take advantage of complimentary safe and secure after their complimentary...
- Handling instruction for accessory pack components during perfect delivery inspection (PDI).
- Software Version Management update for Vehicle Electrical System Control Module that may stay in bus...
- Update programming in ECM for erroneous fault codes.
- Introduce new engine coolant compatible with all models and all model years.
- Battery adaptation procedure when battery label is missing.
- Various driver assist systems do not work or cannot be switched on due to software related deviation in...
- Engine oil quality standards, update to attachments.
- Headlamp: Rubber lip-seal (between headlight and fender)
- Instructional document regarding the installation of a hotfix for the ODIS service software
- KESSY Key Adaptation.
- Generator Replacement
- ECM Update Programming for DTC P2407, P0326, P0442.
- EVAP components available separately or as an assembly.
- Strut or Shock leak assessment.
- Repairing the rubber lip seal on Headlamp assembly.
- Procedure before remote key battery replacement
- Update programming for Various Infotainment Concerns.
- Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
- This Document informs dealers on VWP-23-01
- VW contact when reporting a Airbag or Pyrotechnic safety belt deployment
- Water migration underneath transportation covering (RAPGARD).
- Driver Seat, Memory Set procedure.
- Sirius Inoperative.
- Required Alignment Submission form.
- Taillight Cluster Condensation
- Park Assist Sensors Providing False Warnings
- Update model year applicability to include 2023.
- Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger
- ACC Calibration Process
- A/C requirements, update to model year applicability.
- Cleaning of R1234YF Refrigerant Circuit
- Instruction for set-up of SD creator to obtain Software updates
- Instruction for set-up of SD creator to obtain Software updates
- Engine Oil Quality Standards updated to include the latest Engine Oil ) excluding Routan & ID.4attachments
- Update to required vehicle wash shampoo.
- Engine Oil Quality Standards updated to include the latest Engine Oil attachments
- Manual transmission noise diagnostic assistance
- Minimum battery charger requirements during software updates
- Additional instruction before replacing A/C compressor
- Unwanted Autonomous Braking instruction
- Engine oil consumption measurement.
- Engine Oil Quality Standards updated to include model year 2023 and the latest Engine Oil attachments
- Gasoline quality check
- Brake repair or replace worksheet.
- Software Version Management (SVM) instruction
- Vibration / Pulsation or Noise when Braking
- Brake Rotor, Vibration / Pulsation
- Gasoline quality.
- VW engine oil specifications
- Recommended fuel additive to avoid engine misfires.
- Auto Trans fluid requirements.
- Checking engine oil during PDI.
- Refrigerant leak diagnosis using Nitrogen
- Refrigerant leak diagnosis using Nitrogen
- Engine oil pressure priming.
- Airbag Issues.
- Release Notes Supplement.
- Mandatory Installation from Web-Server.
- This communication contains important information and SAGA claim entry requirements for interim AdBlue...
- Carefree Maintenance and VW Care Maintenance Plans Interim AdBlue Refills -? Diesel Engines Model Year...
- Volkswagen Carefree Maintenance Program ? Gasoline Engines Model Year 2015 and Newer
- Volkswagen Carefree Maintenance Program ? Diesel Engines Model Year 2015 and Newer
- This communication contains important information and SAGA claim entry requirements for the Volkswagen...
- Infotainment Worksheet (U.S. Only)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Volkswagen GTI?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history