2021 Volkswagen ID.4 technical service bulletins
406 technical service bulletins and manufacturer communications cover the 2021 Volkswagen ID.4, including 2 warranty extensions.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the...
- Condensation and or water droplets visible on inside of exterior light lenses
- Condensation
- Installation of the service parts listed in the table below requires an ID.S compound update.
- Do Not replace the Electric Drive Power and Control Electronics -JX1- before performing the update outlined in
- We have deployed this consent email to approximately 6000 customers on 10/7
- Update content to ID.S 3.8.14 KD and potential for separate replacement of power electronics JX4.
- Installation of Battery Regulation Control Module -J840-, -SX7-, -SX8-.
- Additional Information for DC/DC Converter Replacement
- Another Bulletin, or Parts catalog notice leads to
- A technical bulletin and/or parts catalog notice leads to this technical bulletin to perform the ID.S...
- Range reduction / battery cell replacement
- Steps to take if DTC P0AA500 (DA:008C)
- This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Diagnosis of low insulation resistance in the High-Voltage (HV) wiring.
- Checking Installation and calibration
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Subject: Get ready for your Over-the-Air software update
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Inquiries
- Important Step when replacing Battery Cell Modules
- Replace Battery Regulation Control Module Kit -J840- / -SX7- / -SX8
- Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer reports that the vehicle performed an unwarranted Autonomous Emergency Braking (AEB).
- Flushing H.V. Battery before opening
- Determine H.V. Battery Health & Remaining Capacity
- Programming a new Information Electronics Module -J794
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- The federal safety agency has issued an urgent warning regarding counterfeit replacement airbag inflators...
- This special notice is to inform dealers to return the parts listed and only order the successor parts...
- The OUE7 code has been applied to vehicles that will be receiving an over-the-air update to software level...
- DTC B203400
- Assessment of Damage to steering wheel leather
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- How to perform Component Measurement Process
- Ready” mode cannot be established and High-volt
- Diagnosis for Excessive Current Draw.
- H.V. Battery Hints, Tips & Suggested Practices
- Warranty Instruction and guidance
- Alignment sheet submission.
- Programming Modification
- A campaign kit part number was created in Parts on Command (POC) for ordering.
- Rotary latch operation.
- What to do if customer mentions water droplet within tail lights.
- Remote Key Battery Replacement
- How to check for HVAC system leaks using nitrogen.
- Over all summary of HV Battery range
- Additional build status Information required when Replacing H.V. Battery Cell Modules
- Steps to perform when a
- HV Battery Checking Remaining Capacity and Determination of HV Battery Health
- Diagnostic Testing of the Battery Regulation Control Module -J840- for reduced or dropping range.
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- A/C System Flusing Instruction
- Brake Repair or Replacement Information
- Determining HV-Battery Health, Remaining Capacity
- Update Programming replacement Information Electronics Module -J794-.
- Customer states MIL-on, P0442 stored in ECM memory;
- Customer states MIL-on, P0442 stored in ECM memory;
- Identifying and Mixing Engine Coolant
- CV Boot replacement
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Water migration under the RAPGARD® protection when vehicle arrives at dealership.
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer states MIL-on, P0442 stored in ECM memory;
- Time Recording Waiver for Compliance Recall 919A
- Customer states MIL-on, P0442 stored in ECM memory;
- OUJ9
- Capacitive Discharge Instruction.
- Cleaning the refrigeration Circuit R1234YF
- Internal Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication for...
- Moisture witin rear tail lamp assembly
- Customer states rattle from below the vehicle;
- HVAC duct cleaning and deodorizing
- Customer states rattle from below the vehicle;
- Additional reporting
- OUJ9
- Customer states rattle from below the vehicle;
- Vehicle Concerns Before Recall Repair Available
- Inspecting sensors for damage
- ID.4 Stop Sale Update and Dealer Support Measures
- How to manage software versions using VW diagnostic Tool
- Wind & Water Leak Checking
- The affected vehicles may have been built with door handles that do not meet the factory specifications...
- Rattling or knocking noise over bumps or rough roads.
- The software of individual control units in ID family vehicles (MEB platform) is generally updated within...
- Battery Health, Remaining Capacity
- OUH1
- Battery testing
- Customer states rattle from below the vehicle;
- Build status documentation step to include during a justified cell module repair.
- OUJ9
- Over-the-Air (OTA) Software Update (SW Level 3.2.11) Added several reminders that
- This communication is a notice for software changes with the ODIS program to correct the ECM...
- This is a notice for software changes with the ODIS diagnostic program to correct the communication for DA...
- Reminder to complete 97ZZ/97HB campaign
- Erroneous message "New Setting Available" reappears, software update required.
- This communication is a notice for software changes with the ODIS diagnostic program to correct the...
- This communication is a notice for software changes with the ODIS program to correct the A5 Front Camera...
- Installation of the service parts listed requires that the vehicle be updated to ID.S3.2.12 software
- This communication is a notice for software changes with the ODIS program to correct the DA 0023 Brake...
- Process and reference information for Volkswagen technicians who have already completed high voltage...
- Vehicle Software Update to Level 3.2.12
- Get your Volkswagen ID.4 ready for over-the-air software updates
- Proper installation of Charging Socket Emergency Release Cable
- ID.4 Only Cleaning the R1234YF Refrigerant Circuit using VW approved flush machine & Flush kit.
- Electrical system error message (yellow) with DTC P0BBD00 stored in Battery Regulation Control Module...
- During vehicle inspection, maintenance, or repair, one or more diagnostic trouble codes (DTCs) are found...
- The ID.S version shown on the display will remain unchanged until ID.S 3.5. The actual ID.S version of the...
- Infotainment message repeatedly appears
- This communication is a notice for software changes with the ODIS program to correct the Front Camera...
- SERV_ACT HV Battery Module(s)
- Erroneous Infotainment message repeating
- On vehicles manufactured within a specific period, the pressure/temperature sensor in the air conditioning...
- This software update provides minor bug fixes and enhances the performance of the electronic control...
- SERV_ACT HV Battery Module(s)
- A/C Compressor leak diagnosis
- Addressing Cybersecurity or Vehicle Hack concerns
- Airbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
- To ensure that the customer is familiar with the various Driver Assist systems and the system limitations...
- Front Electric Drive Power Electronics Software Update.
- Instruction to determine the remaining battery capacity of the high-voltage battery
- OUH1
- Over-the-Air (OTA) Software Update (SW Level 3.2.11) Added several reminders that
- DC_Over-the-Air (OTA) Software Update (SW Level 3.2.11)
- Over-the-Air (OTA) Software Update (SW Level 3.2.11)
- Reporting procedure for A/C compressor replacement regardless of the reason for failure
- Determination of HV-Battery Health, Remaining Capacity
- Explain the reason for not removing the dielectric adhesive tape from the high voltage battery connector.
- Front Electric Drive Power Electronics with specific symptom codes diagnostics
- This special notice is to inform dealers to return the parts listed only order the successor parts going...
- Service Information regarding electrical consumption (range too low)
- Safety Related Inquiry and Reporting
- Circular revision was for updated additional cell module replacement claiming, updated check cell...
- Dealer Letter to announce Campaign Circular Revision
- Charging Socket Locking Actuator and Emergency Release Cable available separately.
- Helpline & Parts Dept
- An unsealed splice may have been routed in the lower part of the under hood electronics box where it can...
- Dealer Letter to announce UPDATE 97GX / Electronics Box Wiring Harness
- Brake repair or replacement instruction.
- Diagnostic assistance for excessive static current draw
- Brake Disc (rotor) instruction for resurfacing following Volkswagen Warranty Policy & Procedure Manual.
- This communication is a notice for software changes with the ODIS program for specific cars.
- Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
- Software Version Management (SVM) instruction.
- Notifying customers they can take advantage of complimentary safe and secure after their complimentary...
- Rattle or Knock noises on poor road surfaces.
- This communication is a notice for software changes with the ODIS program for specific cars
- Volkswagen Engine oil quality standards, update to attachments.
- Introduce new engine coolant compatible with all models and all model years.
- Serv_act
- Serv_act
- Serv_act
- Battery adaptation procedure when battery label is missing.
- SERV_ACT_ Battery Module(s)
- Serv_act
- Front of vehicle rattle or knocking noise on rough roads
- Engine oil quality standards, update to attachments.
- Air Conditioning Compressor Inop
- 97ZZ and 93P7 Alternate Transportation Reminder
- This Document informs dealers on VWC-23-02
- Instructional document regarding the installation of a hotfix for the ODIS service software
- This document outlines updates to the ODIS diagnostic software
- This week, we released repair information for Safety Recall 97ZZ and Service Action 93P7. With the number...
- SERV_ACT HV Battery Module(s)
- Update
- Upcoming Campaign Advanced Tool Requirement Notice
- Battery Capacitive Discharge Steps.
- Upcoming Campaign Advanced Tool Requirement Notice
- Correct connection on evaporator case drain hose.
- Customer concern of reduced range and/or yellow electrical error message with stored DTC.
- Serv_act
- High Voltage Battery Repair Hints, Tips and Suggested Practices
- Strut or Shock leak assessment.
- This Document informs dealers on VWP-23-01
- VW contact when reporting a Airbag or Pyrotechnic safety belt deployment
- Update Regarding MY 21 ID.4 Software Service Action
- Water migration underneath transportation covering (RAPGARD).
- Serv_act
- Resetting the inspection service test plan for instrument cluster display.
- Driver Seat, Memory Set procedure.
- Doors sticking when opening from the outside, update to include additional model year applicability.
- Serv_act
- Serv_act
- Serv_act
- Serv_act
- Required Alignment Submission form.
- Taillight Cluster Condensation
- Park Assist Sensors Providing False Warnings
- Update model year applicability to include 2023.
- Serv_act
- Serv_act
- Update
- Update
- Serv_act
- Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger
- This Document informs dealers on VWC-22-22
- Update
- ID.4 flash preparation
- A/C requirements, update to model year applicability.
- Instruction for set-up of SD creator to obtain Software updates
- Instruction for set-up of SD creator to obtain Software updates
- During vehicle inspection, maintenance, or repair, one or more of the following diagnostic trouble codes...
- Instruction referral for proper handling
- Preparing for Customers: MY21 ID.4 Software Update
- Customer states rattle noise from the underbody heat shields
- MIB3 CarPlay Connectivity Issues.
- Update to required vehicle wash shampoo.
- Customer states rattle noise from the underbody heat shields
- Minimum battery charger requirements during software updates
- Customer states rattle noise from the underbody heat shields
- Additional instruction before replacing A/C compressor
- Customer states rattle noise from the underbody heat shields Any thermostat related concerns (faults,...
- A/C Inop or does not cool.
- Customer states rattle noise from the underbody heat shields Any thermostat related concerns (faults,...
- Brake repair or replace worksheet.
- Software Version Management (SVM) instruction
- Vibration / Pulsation or Noise when Braking
- Brake Rotor, Vibration / Pulsation
- Refrigerant leak diagnosis using Nitrogen
- Battery Testing and Charging using VAS6161 and or GRX3000VAS
- Customer states rattle noise from the underbody heat shields Any thermostat related concerns (faults,...
- Customer states rattle noise from the underbody heat shields
- Customer states rattle noise from the underbody heat shields
- When driving over bumps or on poor roads, rattling/knocking noises can be heard from the front of vehicle.
- Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and...
- Battery Tester VAS 6161 introduction.
- Customer states rattle noise from the underbody heat shields
- Serv_act
- Exterior Lights, Moisture Accumulation
- Instructional document regarding the installation of a hotfix for the ODIS service software
- Explanation of electronic rotary latch and correct door operation upon exiting vehicle.
- Brake Rotor, Vibration / Pulsation Instruction (U.S. Only)
- Examples of cold high voltage battery conditions displayed to customer via infotainment screen.
- Customer states MIL-on with P0087 P053F in the ECM
- This bulletin contains general instructions for software updates.
- Cleaning of R1234YF Refrigerant Circuit
- Bake Vibration, Pulsation, Noise when braking during PDI
- Battery testing using VW special tools, updated to include additional model year applicability and include...
- Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in...
- Update to model year applicability.
- Additional safety related Inquiry and Reporting instruction.
- Diagnostic assistance for DTC P0CFF00 and P2B2800.
- How to handle irrelevant diagnostic trouble codes (DTCs) if identified.
- In certain vehicles, it may be possible for the wiper arms to make contact with the wiring harness and...
- Deck Lid, center of rear LED light pops out of grommet
- Cleaning of R1234YF Refrigerant Circuit
- Republication of archived technical tip for water leak testing fixture.
- Denotes proper installation of roof rack.
- Cleaning of R1234YF Refrigerant Circuit
- A/C Compressor replacement requirements, updated to include additional model year applicability.
- Cleaning of R1234YF Refrigerant Circuit
- Gathering of data for Autonomous Emergency Braking
- Vehicle delivery by-pack instruction.
- Car-Net technical handling.
- Navigation for addressing incorrect Part direction.
- Radar Sensor Cover service information
- R1234YF a/c
- Removing musty odor from A/C system
- Update engine oil quality standard lists (attachments)
- Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both...
- Spec correction for lane change assist
- Parts ordering information
- 12V Battery Cap Discharge tip
- Information on the location of trailer brake controller connector and adapter harness creation.
- Self Study Program 861213
- Self Study Program 891213
- Update the title, repair information and model, model year applicability.
- New Doc
- Data link diagnostics and tips
- Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do...
- The High-Voltage System in the ID.4
- Additional Maintenance Items: Dust & Pollen Filter: Change ""40,000 miles or 2 years, whichever occurs...
- This special notice is to inform dealers to return the part numbers listed (State of California only).
- Airbag Issues.
- Release Notes Supplement.
- Mandatory Installation from Web-Server.
- This communication contains important information and SAGA claim entry requirements for interim AdBlue...
- Carefree Maintenance and VW Care Maintenance Plans Interim AdBlue Refills -? Diesel Engines Model Year...
- Volkswagen Carefree Maintenance Program ? Gasoline Engines Model Year 2015 and Newer
- Volkswagen Carefree Maintenance Program ? Diesel Engines Model Year 2015 and Newer
- This communication contains important information and SAGA claim entry requirements for the Volkswagen...
- Infotainment Worksheet (U.S. Only)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Volkswagen ID.4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history