2023 Volkswagen ID.4 technical service bulletins
331 technical service bulletins and manufacturer communications cover the 2023 Volkswagen ID.4, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Volkswagen has extended the Warranty coverage for the Steering Wheel for 2 years / Unlimited mileage,...
- Water Migration under RAPGARD® during PDI
- Condensation and or water droplets visible on inside of exterior light lenses
- Condensation
- Installation of the service parts listed in the table below requires an ID.S compound update.
- Do Not replace the Electric Drive Power and Control Electronics -JX1- before performing the update outlined in
- We have deployed this consent email to approximately 6000 customers on 10/7
- Installation of Battery Regulation Control Module -J840-, -SX7-, -SX8-.
- Additional Information for DC/DC Converter Replacement
- Another Bulletin, or Parts catalog notice leads to
- Safety Related Inquiry and Reporting
- Range reduction / battery cell replacement
- Steps to take if DTC P0AA500 (DA:008C)
- Heat Sensative Trouble Shooting Explanation.
- This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
- Brake rotor resurfacing
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Diagnosis of low insulation resistance in the High-Voltage (HV) wiring.
- Warranty Alignment Worksheet
- Replacement instruction
- Checking Installation and calibration
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Subject: Get ready for your Over-the-Air software update
- Inquiries
- Difference between Component fluid leakage and seepage
- Update Programming for Memory Seat Module
- Important Step when replacing Battery Cell Modules
- Replace Battery Regulation Control Module Kit -J840- / -SX7- / -SX8
- Condition is normal due to cold fresh air and humidity
- Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer reports that the vehicle performed an unwarranted Autonomous Emergency Braking (AEB).
- Diagnostic DTC's with symptom codes stored in Battery Regulation Control Module -J840
- Reset Parameterization of door control module
- Flushing H.V. Battery before opening
- Determine H.V. Battery Health & Remaining Capacity
- Programming a new Information Electronics Module -J794
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Paint color and/or finish of the engine compartment may not match the exterior paint color
- The federal safety agency has issued an urgent warning regarding counterfeit replacement airbag inflators...
- Guided Fault Finding Requirement for Component Replacement
- This special notice is to inform dealers to return the parts listed and only order the successor parts...
- Inspecting Cooling system for proper installation to prevent restrictions
- The OUE7 code has been applied to vehicles that will be receiving an over-the-air update to software level...
- Email communication to customers who have consented to download SW 3.8.11 that the SW is ready to install...
- Clearing DTC B101C07
- DTC B203400
- Assessment of Damage to steering wheel leather
- How to handle a suspected paint flaw during PDI
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- How to perform Component Measurement Process
- Ready” mode cannot be established and High-volt
- Diagnosis for Excessive Current Draw.
- Alignment Submission Form
- H.V. Battery Hints, Tips & Suggested Practices
- PDI Instruction
- A "How To" activate Car Net® 2.0
- Warranty Instruction and guidance
- Identify and resurfacing brake rotors.
- Alignment sheet submission.
- Programming Modification
- Oil leak from Cylinder Head Cover;
- Special instruction after replacement of Electronics Control Module 1 -J794- during campaign 919A
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- A campaign kit part number was created in Parts on Command (POC) for ordering.
- Activation
- Rotary latch operation.
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- How to identify and when to replace a leaking strut
- What to do if customer mentions water droplet within tail lights.
- Customer states MIL-on, P055F stored in ECM memory with message on cluster stating “please warm engine oil...
- Remote Key Battery Replacement
- Using Alignment Sheet Submission Form
- How to check for HVAC system leaks using nitrogen.
- Over all summary of HV Battery range
- Additional build status Information required when Replacing H.V. Battery Cell Modules
- Steps to perform when a
- Customer states MIL-on, P055F stored in ECM memory with message on cluster stating “please warm engine oil...
- Warranty brake rotor machining is allowed between 6 and 12 months or 6,000 and 12,000 miles
- HV Battery Checking Remaining Capacity and Determination of HV Battery Health
- Diagnostic Testing of the Battery Regulation Control Module -J840- for reduced or dropping range.
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Improper installation
- A/C System Flusing Instruction
- Customer states MIL-on, P0442 stored in ECM memory; Oil leak from Cylinder Head Cover;
- Brake Repair or Replacement Information
- Determining HV-Battery Health, Remaining Capacity
- Customer states MIL-on, P0442 stored in ECM memory;
- Update Programming replacement Information Electronics Module -J794-.
- Customer states MIL-on, P0442 stored in ECM memory;
- What to do if accessory pack is missing, incorrect or damaged during Perfect Delivery Inptection.
- Customer states MIL-on, P0442 stored in ECM memory;
- Identifying and Mixing Engine Coolant
- CV Boot replacement
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Water migration under the RAPGARD® protection when vehicle arrives at dealership.
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer states MIL-on, P0442 stored in ECM memory;
- Time Recording Waiver for Compliance Recall 919A
- Customer states MIL-on, P0442 stored in ECM memory;
- Capacitive Discharge Instruction.
- Replacing cretain control modules will require specific Guided Fault Finding (GFF) direction.
- Cleaning the refrigeration Circuit R1234YF
- Internal Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication for...
- Half of the VW emblem, light strip in the grill, and the daytime running lights will no longer be...
- Moisture witin rear tail lamp assembly
- Customer states rattle from below the vehicle;
- HVAC duct cleaning and deodorizing
- Customer states rattle from below the vehicle;
- Additional reporting
- Customer states rattle from below the vehicle;
- Vehicle Concerns Before Recall Repair Available
- Inspecting sensors for damage
- The purpose of this Technical Bulletin is to inform Volkswagen dealerships that beginning on 10/1/2024,...
- ID.4 Stop Sale Update and Dealer Support Measures
- How to manage software versions using VW diagnostic Tool
- Wind & Water Leak Checking
- The affected vehicles may have been built with door handles that do not meet the factory specifications...
- Rattling or knocking noise over bumps or rough roads.
- Battery Health, Remaining Capacity
- Battery testing
- Customer states rattle from below the vehicle;
- Build status documentation step to include during a justified cell module repair.
- This communication is a notice for software changes with the ODIS program to correct the ECM...
- Ensure Software Compatibility for service part replacement.
- After the pre-delivery inspection (PDI) has been performed (transport mode has been deactivated), the...
- Erroneous message "New Setting Available" reappears, software update required.
- This communication is a notice for software changes with the ODIS program to correct the A5 Front Camera...
- An implausible current measurement by one or both of the current sensor shunts inside the High-Voltage...
- Process and reference information for Volkswagen technicians who have already completed high voltage...
- Customer states rattle from below the vehicle
- Proper installation of Charging Socket Emergency Release Cable
- ID.4 Only Cleaning the R1234YF Refrigerant Circuit using VW approved flush machine & Flush kit.
- Volkswagen is providing an owner's manual supplement that describes a revision in the Tire load and...
- Electrical system error message (yellow) with DTC P0BBD00 stored in Battery Regulation Control Module...
- Customer states rattle from below the vehicle
- The ID.S version shown on the display will remain unchanged until ID.S 3.5. The actual ID.S version of the...
- Infotainment message repeatedly appears
- Customer states rattle from below the vehicle
- This communication is a notice for software changes with the ODIS program to correct the Front Camera...
- Erroneous Infotainment message repeating
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- A/C Compressor leak diagnosis
- Addressing Cybersecurity or Vehicle Hack concerns
- Airbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- To ensure that the customer is familiar with the various Driver Assist systems and the system limitations...
- Instruction to determine the remaining battery capacity of the high-voltage battery
- Coolant hose improper assembly.
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- Reporting procedure for A/C compressor replacement regardless of the reason for failure
- Determination of HV-Battery Health, Remaining Capacity
- Customer states rattle from below the vehicle
- Explain the reason for not removing the dielectric adhesive tape from the high voltage battery connector.
- Customer states MIL-on, P2402 stored in ECM memory
- Explanation of DTC B101C07
- This special notice is to inform dealers to return the parts listed only order the successor parts going...
- Service Information regarding electrical consumption (range too low)
- Customer states MIL-on, P2402 stored in ECM memory
- Customer states MIL-on, P2421 stored in ECM memory
- Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger
- This Document reminds dealers of TSB 00-20-04 which provides instructions on how to remove the liquid...
- Customer states MIL-on, P2421 stored in ECM memory
- Charging Socket Locking Actuator and Emergency Release Cable available separately.
- Customer states MIL-on, P0442 stored in ECM memory
- Helpline & Parts Dept
- Customer states MIL-on, P0442 stored in ECM memory
- Dealer Letter to announce Repair Available
- Rear suspension bolts may not have been properly torqued
- Removal process for Liquid Applied Transit Coating during Perfect Delivery Inspection (PDI)
- Brake repair or replacement instruction.
- Diagnostic assistance for excessive static current draw
- How to handle Brake noise or Pulsation during Perfect Delivery Inspection (PDI)
- Brake Disc (rotor) instruction for resurfacing following Volkswagen Warranty Policy & Procedure Manual.
- Customer states MIL-on, P0442 stored in ECM memory
- This communication is a notice for software changes with the ODIS program for specific cars.
- Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
- Software Version Management (SVM) instruction.
- Customer states MIL-on, P0442 stored in ECM memory
- Customer states MIL-on, P0442 stored in ECM memory
- Notifying customers they can take advantage of complimentary safe and secure after their complimentary...
- Rattle or Knock noises on poor road surfaces.
- This communication is a notice for software changes with the ODIS program for specific cars
- Handling instruction for accessory pack components during perfect delivery inspection (PDI).
- Volkswagen Engine oil quality standards, update to attachments.
- Customer states MIL-on, P0442 stored in ECM memory
- Customer states key FOB lock/unlock functions do not work via button press (not KESSY)
- Introduce new engine coolant compatible with all models and all model years.
- Customer states MIL-on, P0442 stored in ECM memory
- Customer states MIL-on, P0442 stored in ECM memory
- Customer states MIL-on, P0442 stored in ECM memory
- Battery adaptation procedure when battery label is missing.
- Customer states MIL-on, P0442 stored in ECM memory
- Front of vehicle rattle or knocking noise on rough roads
- Engine oil quality standards, update to attachments.
- This document outlines updates to the ODIS diagnostic software
- Current Sensing DTCs
- Daytime Running Lamps (DLR) or Parking Light illumination only 1/2 operational with error C123B01
- Irrelevant Diagnostic Trouble Codes (DTCs) Logged in Various Control Units
- Battery Capacitive Discharge Steps.
- Correct connection on evaporator case drain hose.
- High Voltage Battery Repair Hints, Tips and Suggested Practices
- Strut or Shock leak assessment.
- This Document informs dealers on VWP-23-01
- VW contact when reporting a Airbag or Pyrotechnic safety belt deployment
- Water migration underneath transportation covering (RAPGARD).
- Driver Seat, Memory Set procedure.
- Doors sticking when opening from the outside, update to include additional model year applicability.
- Required Alignment Submission form.
- Taillight Cluster Condensation
- Park Assist Sensors Providing False Warnings
- Update model year applicability to include 2023.
- Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger
- A/C requirements, update to model year applicability.
- Instruction for set-up of SD creator to obtain Software updates
- Instruction for set-up of SD creator to obtain Software updates
- Instruction referral for proper handling
- 2023 ID.4
- Update to required vehicle wash shampoo.
- Minimum battery charger requirements during software updates
- Additional instruction before replacing A/C compressor
- Unwanted Autonomous Braking instruction
- Brake repair or replace worksheet.
- Software Version Management (SVM) instruction
- Vibration / Pulsation or Noise when Braking
- Brake Rotor, Vibration / Pulsation
- Refrigerant leak diagnosis using Nitrogen
- Battery Testing and Charging using VAS6161 and or GRX3000VAS
- Instructional document regarding the installation of a hotfix for the ODIS service software
- This bulletin contains general instructions for software updates.
- Airbag Issues.
- Release Notes Supplement.
- Mandatory Installation from Web-Server.
- This communication contains important information and SAGA claim entry requirements for interim AdBlue...
- Carefree Maintenance and VW Care Maintenance Plans Interim AdBlue Refills -? Diesel Engines Model Year...
- Volkswagen Carefree Maintenance Program ? Gasoline Engines Model Year 2015 and Newer
- Volkswagen Carefree Maintenance Program ? Diesel Engines Model Year 2015 and Newer
- This communication contains important information and SAGA claim entry requirements for the Volkswagen...
- Infotainment Worksheet (U.S. Only)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Volkswagen ID.4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history