2024 Volkswagen ID.4 technical service bulletins
249 technical service bulletins and manufacturer communications cover the 2024 Volkswagen ID.4.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Water Migration under RAPGARD® during PDI
- Condensation and or water droplets visible on inside of exterior light lenses
- Condensation
- Installation of the service parts listed in the table below requires an ID.S compound update.
- Do Not replace the Electric Drive Power and Control Electronics -JX1- before performing the update outlined in
- Installation of Battery Regulation Control Module -J840-, -SX7-, -SX8-.
- Additional Information for DC/DC Converter Replacement
- Another Bulletin, or Parts catalog notice leads to
- Safety Related Inquiry and Reporting
- Programming instruction.
- Repair instruction for overly sensitive pinch protection
- Steps to take if DTC P0AA500 (DA:008C)
- Heat Sensative Trouble Shooting Explanation.
- This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
- Battery charger control unit software update
- Brake rotor resurfacing
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Diagnosis of low insulation resistance in the High-Voltage (HV) wiring.
- Battery Checking Procedure before replacement
- Warranty Alignment Worksheet
- Replacement instruction
- Checking Installation and calibration
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Subject: Get ready for your Over-the-Air software update
- Inquiries
- Difference between Component fluid leakage and seepage
- Update Programming of Seat Module
- Update Programming for Memory Seat Module
- Important Step when replacing Battery Cell Modules
- Replace Battery Regulation Control Module Kit -J840- / -SX7- / -SX8
- Condition is normal due to cold fresh air and humidity
- Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer reports that the vehicle performed an unwarranted Autonomous Emergency Braking (AEB).
- Diagnostic DTC's with symptom codes stored in Battery Regulation Control Module -J840
- Instruction for overly sensitive pinch protection.
- Reset Parameterization of door control module
- Flushing H.V. Battery before opening
- Determine H.V. Battery Health & Remaining Capacity
- Programming a new Information Electronics Module -J794
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Paint color and/or finish of the engine compartment may not match the exterior paint color
- The federal safety agency has issued an urgent warning regarding counterfeit replacement airbag inflators...
- Guided Fault Finding Requirement for Component Replacement
- This special notice is to inform dealers to return the parts listed and only order the successor parts...
- Inspecting Cooling system for proper installation to prevent restrictions
- The OUE7 code has been applied to vehicles that will be receiving an over-the-air update to software level...
- Email communication to customers who have consented to download SW 3.8.11 that the SW is ready to install...
- Clearing DTC B101C07
- DTC B203400
- Replace Front Information Display Control Head -J685- after 5.4.3KD update
- Assessment of Damage to steering wheel leather
- 12V BatteryTesting, Charging and Required Documents before replacement.
- How to handle a suspected paint flaw during PDI
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Software Version Management
- Software-related deviation in the Engine/Motor Control Module -J623- (diagnostic address 0001).
- High Voltage batter cannot be charged
- Software-related deviation in the Engine Sound Generator Control Module -J943- (diagnostic address 00C0).
- Battery Check Process before replacement
- How to perform Component Measurement Process
- Ready” mode cannot be established and High-volt
- Diagnosis for Excessive Current Draw.
- Alignment Submission Form
- H.V. Battery Hints, Tips & Suggested Practices
- Clears Codes & Adaption Drive Test Drive
- Vehicle Software (SW Level 5.4.3)
- PDI Instruction
- A "How To" activate Car Net® 2.0
- Vehicle Software (SW Level 5.4.3)
- Warranty Instruction and guidance
- Identify and resurfacing brake rotors.
- Alignment sheet submission.
- Oil leak from Cylinder Head Cover;
- Irrelevant Diagnostic Trouble Codes
- Explanation of state-of-charge at the end/start
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- A campaign kit part number was created in Parts on Command (POC) for ordering.
- Activation
- Rotary latch operation.
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- Oil leak from Cylinder Head Cover;
- How to identify and when to replace a leaking strut
- What to do if customer mentions water droplet within tail lights.
- Customer states MIL-on, P055F stored in ECM memory with message on cluster stating “please warm engine oil...
- Remote Key Battery Replacement
- Using Alignment Sheet Submission Form
- Disc Cleaning
- How to check for HVAC system leaks using nitrogen.
- Over all summary of HV Battery range
- Additional build status Information required when Replacing H.V. Battery Cell Modules
- Steps to perform when a
- Customer states MIL-on, P055F stored in ECM memory with message on cluster stating “please warm engine oil...
- Warranty brake rotor machining is allowed between 6 and 12 months or 6,000 and 12,000 miles
- HV Battery Checking Remaining Capacity and Determination of HV Battery Health
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- On March 5, 2025 you received notification of Safety Recall 93CJ / Onboard Charger with Integrated...
- Irrelevant Trouble Codes stored in HV Battery Charger Control Module.
- Improper installation
- A/C System Flusing Instruction
- Customer states MIL-on, P0442 stored in ECM memory; Oil leak from Cylinder Head Cover;
- Brake Repair or Replacement Information
- Determining HV-Battery Health, Remaining Capacity
- Customer states MIL-on, P0442 stored in ECM memory;
- Customer states MIL-on, P0442 stored in ECM memory;
- What to do if accessory pack is missing, incorrect or damaged during Perfect Delivery Inptection.
- Customer states MIL-on, P0442 stored in ECM memory;
- Identifying and Mixing Engine Coolant
- CV Boot replacement
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Water migration under the RAPGARD® protection when vehicle arrives at dealership.
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Customer states MIL-on, P0442 stored in ECM memory;
- Time Recording Waiver for Compliance Recall 919A
- Customer states MIL-on, P0442 stored in ECM memory;
- Capacitive Discharge Instruction.
- Replacing cretain control modules will require specific Guided Fault Finding (GFF) direction.
- Cleaning the refrigeration Circuit R1234YF
- Internal Moisture Accumulation
- This is a notice for software changes with the ODIS diagnostic program to correct the communication for...
- Half of the VW emblem, light strip in the grill, and the daytime running lights will no longer be...
- Moisture witin rear tail lamp assembly
- Customer states rattle from below the vehicle;
- HVAC duct cleaning and deodorizing
- Customer states rattle from below the vehicle;
- Additional reporting
- Customer states rattle from below the vehicle;
- Vehicle Concerns Before Recall Repair Available
- 12V battery testing instruction
- Inspecting sensors for damage
- The purpose of this Technical Bulletin is to inform Volkswagen dealerships that beginning on 10/1/2024,...
- ID.4 Stop Sale Update and Dealer Support Measures
- How to manage software versions using VW diagnostic Tool
- Wind & Water Leak Checking
- The affected vehicles may have been built with door handles that do not meet the factory specifications...
- Battery Health, Remaining Capacity
- Battery testing
- Battery Testing
- Customer states rattle from below the vehicle;
- Build status documentation step to include during a justified cell module repair.
- Charging Circuit Interrupting Device (CCID) activates during AC charging w/ fault codes P1D6E00 and U19FF00
- This communication is a notice for software changes with the ODIS program to correct the ECM...
- Starting with model year 2024, some vehicles have a change in the profile of the electronic engine sound
- After the pre-delivery inspection (PDI) has been performed (transport mode has been deactivated), the...
- This communication is a notice for software changes with the ODIS program to correct the A5 Front Camera...
- Process and reference information for Volkswagen technicians who have already completed high voltage...
- Irrelevant Diagnostic Trouble Codes (DTCs) Logged in Various Control Units.
- ID.4 Only Cleaning the R1234YF Refrigerant Circuit using VW approved flush machine & Flush kit.
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- This communication is a notice for software changes with the ODIS program to correct the Front Camera...
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- A/C Compressor leak diagnosis
- Addressing Cybersecurity or Vehicle Hack concerns
- Airbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
- Customer states rattle from below the vehicle
- Customer states rattle from below the vehicle
- To ensure that the customer is familiar with the various Driver Assist systems and the system limitations...
- Instruction to determine the remaining battery capacity of the high-voltage battery
- Coolant hose improper assembly.
- Reporting procedure for A/C compressor replacement regardless of the reason for failure
- Determination of HV-Battery Health, Remaining Capacity
- Explain the reason for not removing the dielectric adhesive tape from the high voltage battery connector.
- Service Information regarding electrical consumption (range too low)
- Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger
- This Document reminds dealers of TSB 00-20-04 which provides instructions on how to remove the liquid...
- Helpline & Parts Dept
- Removal process for Liquid Applied Transit Coating during Perfect Delivery Inspection (PDI)
- Brake repair or replacement instruction.
- Diagnostic assistance for excessive static current draw
- How to handle Brake noise or Pulsation during Perfect Delivery Inspection (PDI)
- Brake Disc (rotor) instruction for resurfacing following Volkswagen Warranty Policy & Procedure Manual.
- Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
- Software Version Management (SVM) instruction.
- Handling instruction for accessory pack components during perfect delivery inspection (PDI).
- Introduce new engine coolant compatible with all models and all model years.
- Battery adaptation procedure when battery label is missing.
- Battery Capacitive Discharge Steps.
- VW contact when reporting a Airbag or Pyrotechnic safety belt deployment
- Carefree Maintenance and VW Care Maintenance Plans Interim AdBlue Refills -? Diesel Engines Model Year...
- This communication contains important information and SAGA claim entry requirements for the Volkswagen...
- Volkswagen Carefree Maintenance Program ? Diesel Engines Model Year 2015 and Newer
- Infotainment Worksheet (U.S. Only)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2024 Volkswagen ID.4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history