2001 Volkswagen Jetta problems

What is wrong

On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Risk

The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

Remedy

Dealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06v‑183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact vw at 1‑800‑822‑8987.

Recall number 07V063000 · Recall details

What is wrong

On certain passenger vehicles equipped with automatic or manual transmissions and cruise controls, a brake light switch on these vehicles may malfunction if it was installed incorrectly during safety recalls 03v‑265 or 04v‑096.

Risk

The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

Remedy

Dealers will install the newly designed brake light switch free of charge. The recall began on november 27, 2006. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06v‑183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact vw at 1‑800‑822‑8987.

Recall number 06V183000 · Recall details

What is wrong

On certain passenger vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher wattage turn signal bulbs.

Risk

This may result in intermittent or inoperative turn signal and hazard flasher function.

Remedy

Dealers will replace the hazard flasher switch/relay kit. The recall began on march 31, 2005. Owners should contact volkswagen at 1‑800‑822‑8987.

Recall number 04V584000 · Recall details

What is wrong

On certain passenger vehicles, a brake light switch on these vehicles may malfunction.

Risk

If this happens, the brake lights could become inoperative, or come on and stay on, even though the vehicle is parked.

Remedy

This recall has been superceded by 06v‑183. Owners who have had a remedy performed under this recall should return to their dealer for the redesigned remedy. Owners should contact volkswagen at 1‑800‑822‑8987.

Recall number 04V096000 · Recall details

What is wrong

Certain passenger vehicles fail to comply with requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." child seat anchorages installed in the vehicle's rear seats must be identified by markings, and their location and use be described in the owner's manual.

Risk

These vehicles were not marked or described as required by the standard.

Remedy

Owners will be provided with a supplement for the owner's manual and also one set of four guidance fixtures intended to use in conjunction with child seats equipped with rigid or semi-rigid lower anchorage attachments. Also enclosed will be four decals together with installation instructions and a template for attaching the decals to the lower seat backs. Owner notification is expected to begin september 15, 2002. Owners should contact vwoa at 1‑800‑822‑8987.

Recall number 02V244000 · Recall details

What is wrong

On some passenger vehicles, short circuits can occur within the electronic control unit of the anti-lock braking system (ABS).

Risk

This can result in a fire.

Remedy

Dealers will replace the ABS control unit. Owner notification began march 8, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1‑800‑822‑8987.

Recall number 02V031000 · Recall details

By letters dated may 24, 2006 and august 4, 2006, volkswagen (vw) notified the agency that it is conducting a safety recall (the federal safety agency recall no 06v‑183) involving model year (my) 1998-2002 volkswagen new beetle and 1999-2002 volkswagen jetta vehicles equipped with cruise control.volkswagen?s recall covers 646,246 vehicles.previously, vw recalled these vehicles to replace a defective brake light switch (recalls 03v‑265 and 04v‑096) that was unique to vehicles with cruise control.volkswagen reports that the brake light switch may malfunction if it was installed incorrectly during recalls 03v‑265 and 04v‑096.volkswagen will install a new design brake light switch.based on volkswagen's safety recall action, this investigation is closed.

RQ06004

By letter received on june 24, 2005, mr. Ronald m. Strickland of raleigh, nc, submitted a petition requesting that the agency investigate the performance of the ignition coil plugs on model year (my) 2000-2003 volkswagen jetta, golf and passat sedans.the petitioner alleges that he had experienced multiple stalling events as a result of one or more ignition coil plugs malfunctioning on his 2002 vw jetta sedan.as a result of the engine stalling, the petitioner experienced a loss of power steering and increased braking efforts when he pulled the vehicle over to the side of the road to control the vehicle.after a few minutes parked on the shoulder he was able to restart the vehicle although the engine operated at reduced power.vw issued a customer satisfaction campaign (csc) on january 31, 2003 to instruct their dealerships to inspect the vehicles for any malfunctioning ignition coil packs and to replace them at no cost to the consumer.consumers were notified to bring their vehicles to their dealerships via owner letters mailed out on june 6, 2003.while vw initially instructed the dealerships to only replace the malfunctioning ignition coil packs, a revised csc was issued to dealerships in december 2003 and january 2004, instructing dealerships to replace all ignition coil packs regardless of their performance.a reminder to the dealerships was sent by vw on april of 2004.although the concerns of the petitioner could theoretically create a safety problem, the risk is very small, due to the engine still running on either 3, 5, or 7 cylinders.there are no reported crashes or injuries due to the alleged defect.once drivers are aware of the problem (loss of power due to one of the ignition coil packs malfunctioning), drivers are able to take precautionary and compensatory measures and still maintain control of their vehicles.in addition, four fires were reported to odi.these were ignition coil burnouts with no additional damage to the vehicle and were localized on top of the engine. During the last 24 months the number of stall and drivability complaints reported to odi has greatly diminished from a peak of 195 in january of 2003 to only 3 in august of 2005.this coincides with the csc released by vw.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.

DP05004

The subject vehicles are equipped with side-thorax and side-head curtain airbags to protect the front and rear outboard occupants in a side-impact crash.this investigation identified a total of 499 reports (482 owners reports and 17 warranty claims).the crash sensing system?s algorithm may recognize certain non-crash impacts (wheel, tire and undercarriage impacts) as deployable events.the 97 alleged injuries were minor in nature and consist of abrasions, bruises, ear ringing and headaches.there was no alleged loss of control crash as a result of side-airbag deployment.odi also obtained counts of alleged inadvertent side-airbag deployments from peer manufacturers.the data shows that the subject vehicles are not unique in being subject to such allegations.the complaint rate for non-subject individual model vehicles varies widely.the rate for the subject vehicles is comparable to three peer models, each with compact chassis/wheelbases.odi has not identified any component failure or manufacturing trend that may relate to a component or manufacturing issue.a safety-related defect trend has not been identified at this time.further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute finding by the federal safety agency that a safety-related defect does not exist.the agency will take further action if warranted by the circumstances.

PE04081

This investigation was opened on october 19, 2004, based on nine reports on 2000 through 2001 jetta and gti vehicles alleging that the turn signals and or hazard flashers fail to blink, or flash.some of the complainants reported that the lights would blink only a few times and then stop.several of the complainants reported that having the hazard flasher switch replaced repaired their vehicles.by letter of december 13, 2004, volkswagen notified the agency that it will conduct a safety recall of 350,000 model year 2000 through 2002 jetta, golf and gti vehicles to repair the turn signal and hazard flasher system.vw reports 216 owner reports, 4 field reports and 4960 warranty claims on this population of vehicles. Volkswagen dealers will install a new hazard flasher switch/relay kit to remedy the defective vehicles.please see safety recall 04v584 for details.

PE04073

The number of duplicates between odi and manufacturer failure reports cannot be determined due to missing and or inaccurate information.the injury noted above was minor.on february 26, 2004, volkswagen of america, inc. (vw) submitted a defect notification (per 49cfr573) to the federal safety agency advising that certain model year (my) 1999 - 2002 volkswagen jetta vehicles manufacutured with the same brake light switch as recalled under 03v‑265 (my 1998-2002 new beetle) are affected by a safety defect.specifically, if the brake light switch malfunctions, the brake lights could fail to illuminate when the brakes are applied, or could stay illuminated continually even when the brakes are not applied.either condition results in the inability of the brake lights to notify other motorists of vehicle braking, thus increasing the risk of a rear end collision and occupant injury.accordingly, volkswagen is recalling jetta vehicles manufactured from may 1998 to november 2001 to inspect and replace free of charge any affected brake light switches.the recall program, vw code wx, will commence in april 2004.

RQ03010