2000 Volkswagen Passat recalls

What is wrong

Volkswagen is recalling 412,000 my 1999-2005 passat (5th generation) vehicles equipped with automatic transmissions and produced after june 14, 1999. These vehicles may have an underbody heat shield that can become damaged. In addition, affected vehicles with automatic or manual transmissions may have a fuel line (1.8t engines only) or fuel tank ventilation valve (4motion/all wheel drive only) that can leak due to fracture.

Risk

A heat shield that may contact the exhaust system can result in a vehicle fire. In addition, a fuel leak from a fuel line or fuel tank ventilation valve, in the presence of an ignition source, can lead to a vehicle fire.

Remedy

Dealers will install additional underbody heat shields on vehicles with automatic transmissions to cover the possibly damaged areas and flash all 1.8t engines with a precautionary software update. Dealers will also inspect and adjust the fuel line routing on 1.8t vehicles and the fuel tank ventilation valve on 4motion/all wheel drive vehicles, and replace components if necessary free of charge. The recall began on june 13, 2008. Owners may contact volkswagen at 1‑800‑822‑8987.

Recall number 08V156000 · Recall details

What is wrong

On some passenger vehicles, the fuel tank filler neck can suffer abrasion damage if the rear tire goes flat and the vehicle is driven until the tire disintegrates.

Risk

Fuel leakage can occur increasing the risk of a fire.

Remedy

Dealers will fit passat vehicles with a new wheel house liner that will better protect the car's filler neck. Jetta vehicles will be fitted with a different metal shield designed to enhance abrasion protection in the event of tire disintegration. Owner notification began june 13, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1‑800‑822‑8987.

Recall number 02V026000 · Recall details

What is wrong

Vehicle description: passenger vehicles. Sulfur in fuel interacts with certain additives found in widely available gasoline causing sulfur to become deposited on the contact points of three fuel sending units mounted inside the fuel tank. This could cause the fuel gauge to read full while the fuel tank may not in fact be full or could be empty.

Risk

Running out of fuel without warning while the fuel gauge indicates that there is sufficient fuel in the tank lead to safety problems.

Remedy

Dealers will remove the existing fuel level sending units and replace them with fuel level sending units using a new alloy composed of gold, silver, and a small amount of nickel, which will not chemically react with sulfur. Vw/audi will also call back vehicles that were repaired under a previous recall last june in order to install the updated fuel sending units the federal safety agency 00v137/audi lb). Owner notification began may 1, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact audi at 1‑866‑892‑2834.

Recall number 01V157000 · Recall details