2022 Volkswagen Taos fuel system problems

Filed Oct 29, 2026 · Electrical, Engine · IL

Fuel is running through the car faster then normal emergency break went off 10x when nothing was in the way or in front of me reported to dealer said nothing was wrong screen and electrical turns off when driving and all lights go off in dash then come back on after 2min dealer said nothing was wrong. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 20, 2026 · Electrical, Fuel system · IL

Head gasket was replaced due to no cap and causing fuel and engine issues. Multiple electrical issues where cat states multiple warnings.on dash turns.on and off by itself. Battery low voltage on dash have had it to dealer more then 3x and they say everything is fine. Suspenshion rear and front gave been given issues was told after bringing to my dealer that both where broken and they couldn't tell me why when there is no collision or anything that could have caused it. Front sensor has falsely detected objects and has thrown .e into emergency park while driving on many accasions and also was told they couldn't identify why

Filed Oct 7, 2026 · Engine, Fuel system · UT

On [XXX], while driving through [XXX] in high-speed highway traffic, the vehicle suffered a sudden, catastrophic loss of throttle response and engine power. The instrument cluster displayed a solid Check Engine light alongside an Electronic Power Control (EPC) warning light and assist system failure notifications. The complete loss of acceleration forced the driver to coast across active highway lanes onto a dangerous shoulder, creating an immediate and severe collision risk. This sudden loss-of-drive-power symptom mirrors the safety hazard detailed under the federal safety agency Recall #23V‑214 (VW Campaign 20DV). This breakdown is the third major powertrain failure on this vehicle across just 13,382 miles of ownership. Prior dealer-serviced failures include a failed camshaft seal requiring replacement (Feb 2025) and a complete Transmission Mechatronic Unit replacement (Aug 2025). 100% of all mechanical service and maintenance has been performed exclusively at an authorized Volkswagen dealership. The vehicle is available for inspection. Volkswagen of America and the dealer have been formally notified under active Case #[XXX] but have failed to remedy the vehicle or provide safe replacement transportation. This vehicle is still under factory warranty and CPO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 1, 2026 · Fuel system, Transmission · MD

The transmission completely failed, first it was showing emergency transmission in safe mode messages, if you stopped the car turned it off and back on it would go away. After getting a transmission flush the day after my car's transmission completely failed...leaving me in the middle of the road with no power to go forward or backwards. I got towed back to the dealership and am basically being told to replace the transmission entirely with no reason as to why this has happened at only 57,000 miles. Yes it is available for inspection if needed at the dealership. My safety was put at risk because I was stranded in the middle of the road with no way to move my car without towing it. There are other reproductions of this from other customers online I found with similar issues. It has only been inspected by the dealership. There were "emergency transmission in safe mode" messages 2 days prior to the trip to the dealership.

Filed Sep 22, 2026 · Engine, Fuel system · CO

A recurring fuel-odor and drivability problem began while the vehicle was under manufacturer warranty and was never permanently resolved. In September 2022, a Volkswagen dealer documented code P2421 for an EVAP system vent valve stuck open and performed a software update. In June 2024, another Volkswagen dealer documented a strong fuel smell intermittently entering the passenger compartment but found no leak and made no repair. In April 2025, the vehicle was reported to sputter when accelerating from a stop. In July 2025, fuel odor at startup, poor fuel economy, and slow acceleration were again reported, but no leak was found and the vehicle was declared to be operating normally. In June 2026, the vehicle developed an EPC warning and codes P0316 and P0302, resulting in diagnosis of a cylinder 2 injector problem. In September 2026, another repair facility documented continued gas smell, hesitation, possible misfire, cold-start code P0316, and a damaged intake-pipe O-ring causing an air leak. Fuel odor and drivability concerns continued. On September 22, 2026, Volkswagen Customer CARE advised that the vehicle should not be driven until the fuel-leak concern is resolved and instructed that it be towed to an authorized Volkswagen dealership. My concern is that a potentially safety-related fuel/EVAP and drivability defect was repeatedly reported over several years but was never permanently identified or corrected. That wording tracks the records in your packet: the 2022 P2421 EVAP finding, 2024 cabin fuel odor, 2025 sputtering, 2026 P0316/P0302, the damaged intake O-ring, and VW’s later do-not-drive warning.

Filed Aug 30, 2026 · Engine, Fuel system · MO

My 2022 Toas AWD stalls while driving at speed, mimicking the failing fuel pump recall #23V‑214 but the VIN is not included on the recall list.

Filed Aug 22, 2026 · Engine, Fuel system · AZ

On July 30, 2026, while driving my 2022 Volkswagen Taos out of my apartment parking lot, the EPC and check engine lights illuminated. The vehicle shook, lagged, stalled, and could not accelerate normally. I parked and turned it off. An authorized Volkswagen dealer diagnosed a faulty spark plug. On August 12, the same failure recurred. The EPC and check engine lights illuminated, the vehicle shook, and it again lost acceleration. The dealer attributed the misfire to poor fuel caused by Arizona monsoon and dust-storm conditions and added a fuel additive. However, the only major dust storm around these dates occurred on August 19, after the first two incidents. No fuel-test results were provided to support this explanation. On August 20, the failure occurred a third time while I was driving on a major road. The vehicle shook and experienced a severe loss of propulsion and acceleration. The check engine light remained on after the engine was turned off. I had to restart the vehicle three times before I could move it into a parking lot. I was less than one mile from entering a highway, and the sudden loss of acceleration in traffic created a serious collision risk. The vehicle was towed to the dealer. On August 21, the dealer again attributed the misfire to poor fuel. It added fuel-system cleaner, filled the tank with 91-octane fuel, and test-drove the vehicle, but the misfire remained. The technician then reported that three spark plugs were fouled and required replacement. The same dangerous loss-of-power condition occurred three times within 22 days despite two prior repair attempts. The cause of the repeated misfires and fouled plugs remains unidentified. The vehicle is at the Volkswagen dealership and is available for inspection. There was no crash, fire, or injury.

Filed Jul 14, 2026 · Engine, Fuel system · CA

On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.

Filed Jun 22, 2026 · Fuel system · 45,009 miles · PA

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated, and the engine seized. The contact stated that while attempting to restart the vehicle, the vehicle failed to start. The vehicle was towed to the dealer to be inspected; however, the failure was not duplicated. The failure reoccurred. The vehicle was taken back to the dealer; but the failure was not duplicated. The contact was informed that an adjustment to the fuel system was performed. The vehicle was repaired but the failure reoccurred. The failure was persistent. The contact stated that the failure had occurred with minor children inside the vehicle. In addition, the contact noticed a fuel odor on the interior of the vehicle. The vehicle was driven to the residence. The vehicle was later towed to an independent mechanic where it was diagnosed with high and low fuel pump failures. The contact was informed that the high and low fuel pumps needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,009.

Filed Jun 13, 2026 · Electrical, Engine · VA

The systems failing are electrical, engine, and fuel/propulsion systems. VW TAOS 2022 purchased Sept. 2023. Two weeks after purchasing the vehicle, I'm driving down the street and the vehicle began to lose power and start slowing down. It eventually cut off. About a week later, I experienced the same issue. I called the dealer and they had me to bring my car in. I was told that they couldn't find the problem, but that the car was misfiring. They "repaired" and returned it to me. As I drove on local streets and the interstate, I have problems with acceleration. The car does not pick up speed like it should and lags behind and then suddenly jerks forward (even after battery rest times during a stop). It rides a bit rough. Occasionally, my dashboard blacks out while I'm driving. My auto-start doesn't always work, even after the fob batteries have been changed. My gas seems to disappear and I find myself gassing up more often than I should be. I would contact the dealership, they'd coordinate service around my scheduled service dates and claim that they could never find or duplicate the problems that I'm having. The problems continue. My engine light came on while I was driving and stayed on. I was told to bring in my car. The dealership kept it from July-Sept 2025, replacing parts and then returned it to me. Two days later the engine light came back on and I had to return to the dealer again for service. After leaving a parking lot (Jun 2026), two blocks down the street the TAOS began to lose power, the engine light is flashing and the EPC code (engine control malfunction) light lit up. I called VW and they dispatched a tow. My TAOS was towed to Checkered Flag VW. My safety (and others) is at risk because the power loss just happens without warning. If a driver is not paying attention, they could run into the back of me or hit me on the side during a lane change due to the slow movement.