Tl* the contact owns a 1995 volvo 850. The contact stated that the odor of gasoline fuel was emitted inside and outside of the vehicle. The vehicle was taken to an independent mechanic for diagnosis and the contact was informed that the fuel hose was leaking. The hose was replaced however, the contact continued to smell fuel. The vehicle was taken back to the independent mechanic and another cracked hose was replaced but to no avail. The contact stated that he cold see gasoline fuel leaking from under the fuel tank whenever refueling the vehicle. The contact referenced the federal safety agency campaign id number: 04v368000 (fuel system, gasoline) and the vehicle was taken to a dealer for repair. He was informed that an exhaust pipe would occasionally strike the fuel tank, causing a stress fracture in the tank. As a result, the fuel tank would need to be replaced. The vehicle was not included in the recall. The manufacturer was notified but offered no assistance. The vehicle was not repaired. The failure and current mileage was 147,000.
1995 Volvo 850: fuel leak
9 of the 111 complaints about the 1995 Volvo 850 describe fuel leak.
- owner complaints
- 9
- of this car's complaints
- 8%
- typical mileage
- 117,900
- recalls
- 1
Fuel leak by model year
- 19971
- 199612
- 19959
- 19944
- 19933
What owners say
Tl* the contact owns a 1995 volvo 850. The contact stated after receiving repairs for recall the federal safety agency campaign id number: 04v368000 (component: fuel system, gasoline: storage), the vehicle was still experiencing a fuel leakage. The contact stated that the vehicle had to be taken back to the dealer after it failed to pass a smog test, as a result of an evop leakage. The dealer inspected the vehicle and stated that they had already performed the recall repairs and could not find anything else wrong with the vehicle. Since the problem persisted, the vehicle was taken back to the dealer a third time, which diagnosed that the fuel pump was defective and needed to be replaced. The contact decided to take the vehicle to a local mechanic for a second opinion who stated that all of the prior diagnosis were incorrect, and that the actual problem was the vent hose that was attached to the fuel tank was cracked and needed to be replaced. The manufacturer was not made aware of the failure. The vehicle was repaired. The failure and current mileage was 116,007.
Tl*the contact owns a 1995 volvo 850. The contact noticed fuel leaking on the floor of his garage underneath the vehicle. Through research, he discovered the federal safety agency action number ea03008, the federal safety agency campaign id number 04v368000 (fuel system, gasoline:storage). The dealer stated that the VIN was not included in the recall. The contact stated that since the failures were identical, his VIN should be included and the manufacturer should be responsible for the repairs. The current and failure mileages were 117,900. Updated 01/08/09.
Tl*the contact owns a 1995 volvo 850. The contact noticed gas leaking from the fuel tank. The dealer stated that the leaked occurred where the heat shield was attached. There is a recall fuel system, gasoline: storage (the federal safety agency campaign id #04v368000) however, the dealer stated that his VIN was not included. The failure mileage was 112,750 and current mileage was 113,000. The VIN was unavailable.
Tl*the contact owns a 1995 volvo 850. He noticed a gas smell coming from the rear of the vehicle. He stated that gas leaks from the gas tank when he fills it up. He has not spoken with the dealer or the manufacturer. The current and failure mileage was 132,000.
While attempting to start the vehicle it caught fire in the engine compartment without warning. The consumer states that there was excessive fuel leakage. The cause has yet to be determined. Please provide additional information.
Gas was leaking onto the ground due to heat shield being punctured.
I purchased a used vehicle and filled the tank full until auto pump kicked off, drove less than 1 mile home and parked in the garge. The next morning, garage filled with gas fume odor, no visible leak, researched hayned repair manual, found access cover to fuel tank sending unit and fuel pump inside vehicle, removed covers, found fuel leak at fuel pump cover.
Consumer saw/smelled fuel leaking from the fuel tank. Dealership was notified, but did not resolve the problem.
Related recalls
Fuel system, gasoline: storage
- What is wrong
- On certain passenger vehicles, after prolonged exposure to heat, the fuel tank may seep or leak fuel at the points where the heat shield is attached.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Volvo will inspect the fuel tank and replace it if any evidence of fuel seepage or leakage is found. All vehicles will receive new reinforcement bushings at the heat shield attachment points to prevent future leaks. This recall will be conducted as a safety recall in the hot weather states of alabama, arkansas, arizona, california, florida, georgia, hawaii, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, and utah, and as a service recall in the other 33 states and the district of columbia. The recall began on september 24, 2004. Owners may contact volvo at 1‑800‑458‑1552.
Recall number 04V368000 · Recall details
Questions about the 1995 Volvo 850 fuel leak
Is fuel leak a common problem on the 1995 Volvo 850?
9 of 111 owner complaints about the 1995 Volvo 850 (8%) mention fuel leak. The model year with the most reports is 1996.
Is there a recall or service bulletin for this on the 1995 Volvo 850?
There is 1 recall and 0 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 1995 Volvo 850
VIN decoder
See the problems and recalls for an exact car
Buying a used 1995 Volvo 850?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history