1999 Volvo S80: headlights failing or too dim

Filed Oct 4, 2010 · Acceleration, Electrical · DC

1999 volvo s 80. Consumer states problems with the transmission and electrical problems *tgw the consumer stated while driving, the interior dashboard and overhead lights began to dim and then returned to normal light levels on a repeated basis. There were a couple of incidents, where the vehicle would lunge forward without applying pressure to the accelerator and at times would almost come to a complete stall. The consumer stated he also had problems accelerating as he entered the interstate on entrance ramps due to what appeared to be stalling of the engine. The vehicle completely stalled. The vehicle was taken to a repair shop and it was determined the etm had failed and needed to be replaced. The repair shop informed the consumer about a recall and extended warranty. However, when the consumer contacted volvo, he was told his vehicle was updated in august 2008 and they wouldn't assist any further.

Filed Mar 4, 2008 · Lights, Suspension · 142,000 miles · TX

During normal driving conditions at night, the low beam (dipped beam) headlights failed while out of town with my wife and two daughters. I was able to drive to a safe location using the high beams. A check of headlamp bulbs and fuses showed that everything was in good working order and I was left scratching my head. The headlights are still not working three weeks later, and I finally know why. Volvo owners exchange information on various websites and on more than one I found people suggesting that the cem (main computer) used "shunts" for various components on the vehicle and they were proned to shorting out due to random overheating issues. I checked the area under the driver's side dash and sure enough, there is a shunt inserted into the cem with heavy charring around the terminals. The 1999 volvo s80 was the first year of my particular model, and the first year this type of wiring architecture was used on their vehicles. The shorting of a crucial circuit such as headlamps not only poses a grave danger when driving the vehicle at night, but could also cause a fire. I feel the failure in the design of the cem and the vehicles wiring architecture could also be responsible for the random electrical problems occurring with the s80 as well. There are several websites that mention the constant "check engine" light that comes on and dealers are claiming they repair the problem after each visit, which usually end up costing over $1,000.00. There's also several examples of customers , including myself, who lose the A/C compressor randomly, and the alternator indicating that it isn't charging correctly. Finally, there is also something inherently wrong with the design of the front suspension of the s80. I've paid for struts and ball joint repairs and have had them repaired through a manufacturer recall. Again, the dealer claims to have repaired the problem after each visit, yet the problem has recently come up again in my vehicle. Please contact me anytime.

Filed Feb 28, 2004 · Acceleration, Lights · 4,000 miles · FL

Vehicle message center displayes: ABS system failure/servicing transmission system service power steering service emissions control service also, there is an engine oil leak and a tie rod replacement/four wheel alignment was required cruise control is intermittent directional signal inop headlights come on when not commanded etc. Incident date--throughout ownership .

Filed Dec 14, 2001 · Body, Brakes · CA

While driving 55-60 MPH, brakes were pulsating, after applying brakes again noticed brakes were fading. Consumer pulled over and noticed rotors were red hot. Dealer replaced front rotors and pads.*ak the gas tank had a defect that would cause a vacuum leak. The front suspension makes a cracking noise when turning due to ball joint failure. The gear shifter switch makes loud clicking noise. The rear passenger door handle could not be opened from outside. Automatic transmission had slippage and shudder while up shifting, creating a vehicle loss of control. Passenger side rear seat backrest cushion makes noise due to loose clips. The front passenger window developed a wind noise due to defective window seals. Due to design fault, the upper torque mount bushing cracked. The driver side front headlight lens broke. The consumer is asking for a full refund of the actual price paid for the vehicle or for it to be replaced with a new equally equipped vehicle.

Filed Jan 16, 2001 · Brakes, Electrical · MA

Electrical system malfunctioned, causing lighting on dash/ windshield wipers and power windows to be inoperable.*ak the vehicle had bent brake calipers failure, head light failure, broken mirror switch. The door remote failed. The consumer wants the dealer to take the vehicle back at no cost.