2000 Volvo S80 fuel system problems

Filed Dec 22, 2015 · Fuel system · 181,000 miles · AZ

Vehicle has the smell of fuel. The 2001-2005 models have a recall for this same issue because of the plastic on the fuel pump flange cracking. Many owners of the 2000 models are reporting this issue. The fuel pump is the same used on the 2000 year model as the 2001-2005 so the 2000 should be part of the recall also. The smell of fuel is not just unpleasant but dangerous. I have a 11 month old son who rides in my car and it would be tragic if something happened to my family or someone else. You can search google and see many other owners reporting issues in the 2000 model volvo s80. Please do something about this. Thank you!

Filed Nov 7, 2015 · Electrical, Fuel system · CA

I was driving and my car lights and all the electronic stop working and turn off

Filed Oct 14, 2015 · Fuel system · 65,000 miles · NJ

Tl* the contact owns a 2000 volvo s80. The contact noticed a fuel odor near the rear seat of the vehicle and the fuel gauge indicator drastically decreased. The contact discovered an excessive amount of fuel leaking on the ground near the rear side of the vehicle under the fuel tank. The vehicle was taken to a dealer where it was diagnosed that the fuel pump flange was cracked. The manufacturer stated that the VIN was excluded from the federal safety agency campaign number: 09v483000 (fuel system, gasoline). The vehicle was not repaired. The approximate failure mileage was 65,000. Update 01/15/16 ma updated 02/04/16. *jb updated 03/04/16*lj updated 03/14/16.

Filed Oct 14, 2014 · Fuel system · CA

Within the past few days, I've gotten many complaints about the foul smell of gasoline lingering on my vehicle. Sure enough, I take it to a mechanic and the fuel pump is visibly moist on the exterior from an obvious fuel leakage. I researched "volvo s80 fuel pump" and found a recall is in place. The recall starts from 2001 models and ranges up to 2005 models and is due to the material used in the fuel pump (recall campaign 09v‑483). Since my vehicle is a 2000 model, my local volvo dealership said "I do not meet the qualifications". My concern is if the material used in the assembly of the fuel pump changed from s80 2000 to 2001 models. I would like to be notified what material was used for s80 2000 models versus the material used for s80 2001 models and make sure that the material for s80 2000 models "may not develop cracks due to exposure to certain environmental conditions and varying fuel quality" as does the s80 2001 material. Thank you very much.

Filed Sep 19, 2014 · Fuel system · 125,000 miles · MI

Component: fuel system, gasoline:delivery:fuel pump there is a strong smell of raw gasoline both inside and outside the vehicle. Gasoline is dripping from the fuel system directly below the position of the fuel pump. The vehicle is registered in sarasota, florida, a warm weather climate. All indications point to recall number r220. This recall begins with the 2001 volvo s-80 and therefore does not include my 2000 model year. I contend that the recall should be expanded to include 2000 model year volvos. V483000 vehicles in warm weather climates may develop a fuel leak car recalls volvo s80 recall 09v483000 vehicles in warm weather climates may develop a fuel leak engine, january 15, 2010 repairpal expert overview our quick take: vehicles operated in certain warm weather climates may develop a fuel smell and/or leak. Original recall from the federal safety agency model year(s): 2001, 2002, 2003, 2004, 2005 mfr's report date: january 15, 2010 the federal safety agency campaign id number: 09v483000 the federal safety agency action number: pe09039.

Filed Aug 27, 2014 · Fuel system · 126,000 miles · FL

Tl* the contact owns a 2000 volvo s80. The contact stated while driving approximately 45 MPH, the vehicle began to smell of fuel. The failure recurred multiple times. The vehicle was taken to the dealer for diagnosis. The mechanic stated that the fuel pump need to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 126,000.

Filed Aug 21, 2014 · Brakes, Engine · 106,987 miles · OH

While stopping or turning at low speeds the cars idle speed will fluctuate from a complete stop up to 1100 rpms. Most of the time between 500 & 1100 rpms ! When the car stops running while I am trying to turn a corner , the power steering of coarse does not work and its hard to steer it. I did take it to a volvo dealer, & they said it needed a new throttle sensor & computer software change, & it would cost me $2400. I can't find out if any of the recalls have ever been done #r155, r146, the federal safety agency I.d. #626114 & I.d. #10018801. The previous owner had the car for three years & did not receive and recalls notices. Most of the time the car runs fine, I have driven it over 40,000 miles now with the check eng. Light on & off. The check engine light will stay on for a day or too & go off for three or four days at a time. I would really like to know if any of the recalls have ever been done to this car.

Filed Jul 23, 2014 · Fuel system · 126,000 miles · CA

Tl* the contact owns a 2000 volvo s80. The contact noticed a fuel odor inside the vehicle and the fuel gauge indicator had drastically decreased. The contact discovered an excessive amount of fuel leaking on the ground near the passenger side rear tire directly under the fuel tank. The vehicle was taken to an independent mechanic who stated that the fuel pump flange was cracked. The manufacturer stated that the VIN was excluded from the federal safety agency campaign number: 09v483000 (fuel system, gasoline). The vehicle was not repaired. The VIN was unavailable. The approximate failure mileage was 126,000.

Filed Aug 14, 2013 · Fuel system · 173,000 miles · VA

This car been parked since mid may 2012 with 2 problems, cvvt & inlet hoses. I had the battery charged & the inlet hose fix, so it could go into the shop for inspection. Aug.13 I put the plates on it & drove it for the 1st time at night to drop it off at the shop for inspection. Which I had spoken with 2 days earlier.. The morning of aug 14, I call the shop and was informed my car had a fuel pump leak. I than call the volvo corp. Cause it had issue a recall for the fuel pump. Just to be told it wasn't on my car & I'm responsible for the repair.. This car gave no warning or smell of gas about a defected fuel pump. This wasn't around the corner drive for me. It a blessing cause this could've been bad...as a woman I like to know, how it went bad just sitting there?..

Filed Sep 6, 2012 · Fuel system · 100,000 miles · NJ

Tl* the contact owns a 2000 volvo s80. The contact stated that fuel fumes were emitted into the vehicle. The vehicle was taken to the dealer who diagnosed that the fuel pump and the fuel assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted who did not offer any assistance since the vehicle was not included on any recalls. The failure mileage was 100,000 and the current mileage was 128,000.