2001 Volvo S80 fuel system problems

Filed Oct 19, 2017 · Electrical, Engine · 150 miles · MI

Takata recall" frist I called volvo to inquire about recalls referening to the cooling system and the fuel pump the first lady I spoke with informed me this problem was under recalls and to take my car to get it serviced at the nearest dealer after taking my car to the dealer at 7:15am 4hours later after I called them first they now are saying that there isn't anything they can do with my car and they do not know who told me that false information. On top of all of this my car accelerates by itself lucky when it happens I hurry and push the brakes and the car dosent start up once turning the key even the guy say that's always been a problem. Based on how expensive this car is it seem there wouldn't be many problems with it or it seem that they would at least try todo something about the false information over all I will never buy another volvo again!

Filed Dec 29, 2011 · Fuel system · NV

Tl* the contact owns a 2001 volvo s80. The contact took the vehicle to the dealer for repairs under the federal safety agency campaign id number: 09v483000 (fuel system; gasoline; delivery; fuel pump) and was told that the vehicle could not be repaired under the recall because it had been ten years since the vehicle was manufactured. The recall was issued december 7, 2009. The contact had not experienced a failure. The current mileage was 65,000.

Filed Jul 20, 2010 · Fuel system · 155,000 miles · OK

Tl*the contact owns a 2001 volvo s80 t6. While driving approximately 25 to 30 MPH the contact stated that he smelled fuel inside the vehicle. He drove home and had not driven the vehicle since the failure occurred. The vehicle was previously owned and purchased one week ago. The contact called the dealer and the manufacturer and was advised that the vehicle was not a part of the federal safety agency recall campaign id number: 09v483000, fuel system, gasoline delivery, fuel pump. The approximate failure and current mileages were 155,000.

Filed Jan 23, 2009 · Fuel system, Suspension · 71,000 miles · WA

Upper strut bushings cracked front lower control arm bushings front link rods rear link rods flame trap box leaking oil this 2001 s80 volvo is a piece of junk tried to have this volvo work done per the extended warr ultimate I have a piece of junk.

Filed Mar 26, 2006 · Fuel system · 69,000 miles · AR

2001 s80 volvo etm failure. It started as vehicle hesitation, then proceeded to surging forward with no throttle input, then progressed to no accelerator response when applying the brake pedal, then to stalling when coasting leaving the driver with no power steering or brakes at speeds up to 55 MPH, then to rough idle and check engine light. All symptoms were present upon taking to the dealer based on some web research to identify to problem. The dealer returned with an analysis for timing belt replacement, engine tune up, engine coolant flush, crankcase ventilation system cleaning, brake system flushing, and mass air flow replacement amounting to an initial cost of $1980.00 us. I requested a conference with the technician, and a review of the diagnostics report. The end result was a maf replacement paid for by me (customer) and amazingly the tech notes recommended cleaning of the crankcase ventilation system and the etm cleaning which was covered by the dealer. Total cost was $328.21 to consumer and balance covered by dealer. The repairs were made on 3/07/06, replaced maf unavailable. I feel that I have been taken advantage of and essentially paid $328 unnecessarily due to further web research identifying cleaning of the etm and crankcase ventilation system would in fact cause trouble codes leading the replacement of the maf.

Filed Nov 30, 2005 · Fuel system · 50,020 miles · FL

I own a 2001 volvo s-80. There is a dangerous problem with this car . It involves the electronic throttle module (etm). The car at times will not move even though the engine is running and the car is in gear. It just will not move. Particularly when trying to move into traffic. I am aware through my reading of the fact that there are hundreds of thousands of vehicles with the same problem. Volvo knows about this but to date has done nothing to correct it. I also know that the federal safety agency is investigations the problem and I wanted to list my name with you for a complaint on this.

Filed Oct 24, 2005 · Acceleration, Fuel system · 46,000 miles · NJ

Surging idle speed. Car lurches forward at times when accelerating from a stop. Car almost stalls when idling in bumper to bumper traffic, requiring you to press on the gas to keep it from stalling, but this makes the car lurch forward even more. Several times I have almost hit the car in front of me. This problem is due to a faulty etm (electronic throttle module) that is described in the federal safety agency defect investigation shown below. The etm in my car was replaced two years ago at 46k miles but the same symptoms are recurring. The federal safety agency action number : pe05041 the federal safety agency recall campaign number : n/a make : volvo model: s80 manufacturer : volvo cars of n.a. Llc. Year : 2001 component : vehicle speed control date investigation opened : july 26, 2005 date investigation closed : open summary: the office of defects investigation (odi) has received one hundred and thirty-one (131) consumer complaints alleging a variety of concerns resulting from failure of the electronic throttle control module (etm) in the subject vehicles, including a sudden loss of speed and steering assist when driving in highway traffic and sudden and complete stall without warning. In some instances, it has been reported that the vehicles would restart, and in some cases the vehicles were towed. Some consumers allege that after having the etm replaced the new component failed in a similar manner. A preliminary evaluation has been opened to determine the scope, frequency, and potential safety-related consequences of the alleged defect.

Filed Oct 18, 2005 · Fuel system · 80,988 miles · SC

Week of 10/10/05 as traveling uphill, my car sputtered and loss power. After nearly being rear ended on the busy road, I was able to limb my car into a parking lot and turn off the engine. After a few minutes, I was able to restart my car and continue driving. Today, 10/18/05, as I was entering I-85, my car once again sputtered and stalled. The entrance ramp was downhill, so I was able to coast into the emergency lane as tractor trailers and cars whizzed by me. I restarted the car after a few minutes of being turned off. I went to a mechanic friend and he told me that it was probably the etm and if it was not, it would be the next time the car breaks down. He could not repair it. He estimated the dealership would charge me $1200.00. He reported that he sees this at least once a month in volvos. I took the car to the dealer. An hour and a half later, I was informed my etm needed to be replaced and the cost would be $1150.00. I relunctantly agreed to the repair. I have researched the etm problem over the internet and have learned that volvo knew of this problem years before they sold the car to me. At a personal level, I had to pay for a defective part that volvo has known it has a 94%-100% failure rate! At a much higher level, volvo is risking people lives by not informing or voluntarily recalling this defective part. Cars stall unexpectively. I was fortunate that I was not on the interstate yet. Otherwise, the outcome could have been deadly.

Filed Sep 26, 2005 · Fuel system · 57,642 miles · NJ

I own a 2001 volvo s 80. It died on the highway in the middle of busy rush hour traffic. Had it towed to volvo and repaired. Need a new throttle body and mass air flow sensor. Very expensive repair and was told off the record that this part failure has been much more common than it should be. I am notifying you so that you will look into manner. Seems this should be a recall item. Thank you.

Filed Sep 23, 2005 · Fuel system · 98,562 miles · RI

We own a 2001 volvo s80 with an electronic throttle module problem that we attempted to have the volvo dealer fix in august 04. The car had 98,000 miles on it at that time. The dealer claimed to not be aware of any problems with the etm, but that they could attempt to clean the system, which they proceeded to do at $566. The problem wasn't fixed, but the dealer said they could now fix the problem for an additional $1000. This really irked me, I never went back, now it is a year later and the car still is not fixed, but it won't pass inspection un til it is corrected. I've visited several non-dealer mechanics who have all said they can't fix the problem, so I'm stuck having to go back to a dealer who has tried to swindle me. I recently became aware of the thousands of complaints about this problem with the volvos, but I refuse to have the untrustworthy and "unknowing" volvo dealership touch the car. I now have found a mechanic who formally worked for volvo attempt to repair the car. It will probably cost me doulbe what the volvo mechanic has said it would, but there is no faith in the dealership. I un derstand there is a class action lawsuit against volvo because of this problem, I will save all my receipts for the possibility of filing a claim either with you or with the lawsuit plaintiffs.