2001 Volvo V70 lights problems

Filed Oct 31, 2018 · Lights · 206,000 miles · VA

Tl* the contact owns a 2001 volvo v70. The contact stated that the rear brake lights intermittently failed to function. The brake warning light illuminated stating check rear brake lights. The vehicle was not taken to a dealer or an independent mechanic for a diagnostic testing of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not covered under the campaign number: 04v051000 (exterior lighting) and did not offer further assistance. The approximate failure mileage was 206,000.

Filed Dec 22, 2014 · Brakes, Electrical · 128,000 miles · CA

I noticed the tail light brake bulbs were burning out quickly. After getting a ticket I stopped driving it until I could determine the cause. Volvo lists a brake relay recall. Brake light fuses and relays are in 4 locations in the car. They are: 1. Under the hood in the engine control unit ecu, 2.the passenger compartment a. Central control unit ccu and b. Fuse panel by drivers side door post 3. Rear control unit in the cargo compartment. The problem was an electrical engineering design where a steel race that surrounds the taillight bulbs transfers the electrical current is designed to fail. As the bulb heats up it transfers the heat to the plate and plastic pins that hold it in place under pressure from the spring steel parts of the removable bulb socket unit. As the plastic pins weaken and move away under pressure and heat from the bulb socket spring steel keepers, and conductors of voltage and current, the current is throttled down to a pin point as the plate moves away from the bulb creating more heat and arcing to melt the steel race surround the bulbs that supply the current. The replaced bulbs seem to work for a short time as the connection is reestablished when the bulb socket is removed and replaced, and the connection is reestablished for a time, but it will soon over heat and fail from the weakened and melted plastic lens. Brake light failure results not from a failed part, relay, fuse or wire, but from an engineering design flaw that was recognized and eliminated in the 2005 models. Ford and volvo never mention this. A recall could amount to six hundred to a thousand dollars per car for the 4 lenses with labor. The arcing in the wiring may also cause other computer failures as the transmission also has an electrical problem in the kickdown process that causes an abnormal delay in neutral gear and hard engagement of the lower gear.

Filed Jun 13, 2007 · Lights · 84,000 miles · MA

2001 v70 headlight bulb socket on running lights h& bulb burned up. This caused the headlight on drivers side to fail.

Filed Apr 23, 2007 · Lights · 86,000 miles · DC

I have a 2001 volvo v70. I got a message that the left hand turn signal bulb was out. I bought a new bulb to replace it, and it did not fix the problem. The dealer found that it was a problem with the socket, and subsequently replaced it. This solved the problem. My complaint is that a recall for this very problem was issued for volvo v70s from 1998-2000, (the federal safety agency campaign id number : 00v405000 ). It seems to me that this recall should be changed to include 2001 models, as clearly, the issue was not resolved with the new model year.

Filed Apr 14, 2006 · Lights · 86,000 miles · CA

When I step on the brakes, sometimes I get a warning on my dashboard to check brake lights, when I check, I get the warning whenever the left and right brake lights do not light up, and only the center does. If I press multiple times they may work. I found a similar recall on the 2002 model, I have the 2001 model the number is 04v051000.

Filed Apr 14, 2006 · Lights · 87,700 miles · CA

Dt*: while braking the check brake lights warning illuminates. There is a the federal safety agency recall, # 04v051000, regarding the brake lights. The vehicle has the same problems as indicated in the recall; however, it is not included in the recall due to the VIN. Updated 5/10/2006 - the right and left brake lights did not work, only the center brake light worked.

Filed Jan 3, 2006 · Electrical, Lights · 45,000 miles · NY

I have intermittent failure of the dipped beams in my 2001 volvo v70 t5. I see an error report on the dash: bulb failure. Dipped beams. But there is nothing wrong with my bulbs. There is an electrical problem that is totally unpredictable leading to loss of low beams. Volvo service managers say they don't know what causes the problem. Am I the only person to report this defect? It started about 2 years ago in the winter of 2003 but is now more regular but not always.

Filed May 20, 2004 · Lights, Visibility · NH

Problems with windshield and headlights. *mr the windshield presented a glare while the vehicle was in motion, at night, the low beam setting resulted in insufficient light protection, and the high beam had limited use. *sc

Filed Oct 24, 2001 · Lights, Transmission · CA

Clutch problem: 5 speed manual transmission. Clutch sticks after pressing it in, when it comes back up. This happens when temperature is cold. Dealer checked out 4 times, could not reproduce problem. Independent mechanic found problem at once and states that clutch bearing needs lubricated otherwise will wear prematurely. Dealer refuses to do this. Light problem: problem exactly the same as 99-00 recall the federal safety agency campaign id: 00v405000. Year 2001 should get included in recall. Dealer "fixed" problem once by "cleaning the socket" problem reoccured. Required recall fix is to replace bulb and socket and not "clean socket".

Filed Mar 11, 2001 · Lights · PA

Bulb failed and bulb failure warning light came on on way home from dealership. We returned to dealership and they said they were not aware of any problems with this component on this model. They attempted to repair but were not able to repair because they did not have a service technician on site. They offered another car but we declined. Signal has been intermittent since the first incident.