2004 Volvo VHD technical service bulletins
124 technical service bulletins and manufacturer communications cover the 2004 Volvo VHD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- Cbr - z
- Cbr
- TSB - V-710-001
- Cbr - 11
- CBR: Volvo VHD & VN Models
- Barksdale Leveling Valve, Leak Test
- CBR: Programming Failure
- CBR: Volvo VHD Models
- CBR: Volvo On-Highway Vehicles
- CBR: Volvo Chassis
- Flywheel Housing Thread Repair
- Instrument Cluster Programming
- Volvo Chassis
- Engine Control Module (EMS) Software (MSW) Information – August 2022; Improvement List (Change Log)
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Particulate Matter (PM) Sensor Troubleshooting Guide
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
- Volvo Chassis Ghost Codes Due To Poor Grounding
- Volvo Chassis
- Volvo Chassis
- Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
- Volvo Fault Code MID 144 PSID 204 FMI 9
- The Diagnostic Process
- Volvo Chassis
- Radio, Replacement (revised from FSB 392-005)
- Volvo Chassis
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- US07 / US10 D13
- Volvo Chassis
- Exhaust Gas Recirculation (EGR) System
- Diagnostic Trouble Code ( DTC ) P009E
- Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement )
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Flywheel Resurfacing Guidelines, I-Shift
- ECM and ACM Reprogramming, OBD2015
- Diagnostic Trouble Code ( DTC ) P009E
- Diagnostic Trouble Code ( DTC ) P0194
- Automated Manual Transmission ( AMT
- Volvo Chassis
- Service Only Regen Requested With No Warning
- Volvo Chassis
- Volvo Chassis
- Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL )
- Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL )
- Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL )
- Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement )
- In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing...
- On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly...
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine...
- Hill Start Assist Solenoid, Replacement
- Oil Filter Housing
- Regeneration in PTO Mode
- High Soot Output
- Timing Plate Flange Screw
- Range Synchronizer, Repair
- EGR Mass Flow Rate Low, diagnostic trouble code
- Battery Cable, Routing
- Transmission ECU Compatibility
- Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
- Single Fuel Tank Ventilation Filter Kit
- Dual Fuel Tanks Ventilation Filter Kit
- Service Door Rust Prevention
- AMT High Range Cone Replacement
- Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
- Seat Harness Routing (Swivel) wires pulling away from clipping points
- Engine Control Module (ECM) Software Update
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of...
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload
- Oil Level Sensor Harness Wire Splice
- Engine Data Label
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of...
- Transmission ECU Programming
- Software Update, revise document
- Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
- Floor Cracks Repair (Front Panel)
- Volvo trucks: missing signal from engine variable geometry turbocharger actuator (engine vgt actuator)...
- Volvo trucks: connector pin, replacement
- Volvo trucks: oil seepage at flywheel housing
- Volvo: light control module (LCM), reprogramming
- Volvo truck: fuel tank mounting
- Volvo trucks: some engines leak oil through the grommet
- Mack trucks: there is revised mounting hardware for the exhaust manifold and turbocharger
- Volvo truck: i shift transmission with mixed components
- Volvo truck: door seal, outer, replacement
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering
- Volvo trucks: engine update campaign for certain D13F engines (VN-2, VHD-2) consists of inspecting the...
- Volvo truck; clutch switch clip; it has been found that vn, vhd and vt vehicles use a spring clip to...
- Volvo truck: on some vehicles, coolant overflow out of the overflow tube occurs during the diesel...
- Volvo: leakage detection diagnostics improvements to remedy dtc's
- Volvo truck: reports prompted the release of a replacement connector for the cab HVAC motor resistor
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Volvo VHD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history