2011 Volvo VHD technical service bulletins
223 technical service bulletins and manufacturer communications cover the 2011 Volvo VHD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- Cbr - z
- Cbr
- Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low...
- TSB - V-710-001
- Cbr - 11L, 13L
- Cbr
- CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been...
- Cbr: 11L, 13L
- CBR: Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- Cbr - 11
- Cbr
- Cbr
- Cbr
- Cbr: tgw
- Cbr: 11L
- CBR: Volvo VHD & VN Models
- Barksdale Leveling Valve, Leak Test
- CBR: Programming Failure
- Cbr
- Service Literature Published and Released in May, 2023
- CBR: Automated Manual Transmission ( AMT )
- CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
- CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
- CBR: Volvo VHD Models
- CBR: Volvo On-Highway Vehicles
- CBR: Volvo Chassis
- Volvo Chassis
- Flywheel Housing Thread Repair
- Volvo Chassis
- Back Office
- Volvo Chassis
- TSB-Charge Air Cooler t-clamp install.
- Part information for AMT input shaft repair kits and the shim kit that is required for repair.
- Engine Control Module (EMS) Software (MSW) Information – August 2022; Improvement List (Change Log)
- Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F )
- US10 Emission Engines
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Premium Tech Tool (PTT)
- Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Mack Chassis
- Particulate Matter (PM) Sensor Troubleshooting Guide
- Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information;...
- (Back Office Only) Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
- Volvo Chassis Ghost Codes Due To Poor Grounding
- Volvo Chassis
- Volvo Chassis
- Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
- Volvo Fault Code MID 144 PSID 204 FMI 9
- Volvo Chassis
- The Diagnostic Process
- Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
- Volvo Chassis
- Radio, Replacement (revised from FSB 392-005)
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Monthly Bulletin Release Letter
- Volvo Chassis
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Cylinder Head Reuse And Replacement Guidelines
- Volvo Chassis
- Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be...
- Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number...
- Volvo Chassis
- Diesel Fuel Information
- Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24...
- Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
- Volvo Chassis
- Volvo Chassis
- Instrument Cluster Programming
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- US07 / US10 D13
- Volvo Chassis
- Volvo Chassis
- Exhaust Gas Recirculation (EGR) System
- Automated Manual Transmission (AMT) Faults
- Volvo Chassis
- Diagnostic Trouble Code ( DTC ) P009E
- Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement )
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Flywheel Resurfacing Guidelines, I-Shift
- ECM and ACM Reprogramming, OBD2015
- Diagnostic Trouble Code ( DTC ) P009E
- Diagnostic Trouble Code ( DTC ) P0194
- Automated Manual Transmission ( AMT
- Volvo Chassis
- Service Only Regen Requested With No Warning
- Volvo Chassis
- Volvo Chassis
- Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL )
- Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL )
- Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL )
- Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement )
- VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines...
- Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017...
- VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines...
- VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines...
- In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing...
- On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly...
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine...
- On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable...
- Diagnostic trouble codes (DTCS), low oil pressure, vah, vhd, vn
- Hill Start Assist Solenoid, Replacement
- Oil Filter Housing
- On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid...
- Regeneration in PTO Mode
- High Soot Output
- Timing Plate Flange Screw
- Engine Brake Loss
- Range Synchronizer, Repair
- EGR Mass Flow Rate Low, diagnostic trouble code
- Battery Cable, Routing
- Transmission ECU Compatibility
- Volvo: on some vehicles, the steering knuckle would have wheel hub displaced and would to replace wheel hub.
- Volvo: some trucks show signs of brake shoe protrusion beyond brake drum and need replacing
- Volvo: to resolve condition of brake shoes, showing signs of protrusion of brake shoe beyond brake drum,...
- Volvo: replacement of brake shoes that shows brake shoe protrusion beyond brake drum
- Volvo: brake shoe is protruding beyond brake drum and is corrected by replacing/installing new 152 mm (6.0...
- Volvo: the meritor or bendix brake shoes are showing signs of brake shoe protrusion beyond brake drum and...
- Volvo: brake shoe is protruding beyond brake drum and CAN be resolved by replacing and installing 152 mm...
- Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
- Single Fuel Tank Ventilation Filter Kit
- Dual Fuel Tanks Ventilation Filter Kit
- Service Door Rust Prevention
- AMT High Range Cone Replacement
- Volvo truck: procedural information regarding the replacement of high range cone in the section of the...
- Volvo truck: due to internal build up contamination of grime, salt, road debris, in harsh environments,...
- Volvo: on some trucks, an improper torque has allowed corrosion inhibitor between ring terminals of main...
- Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
- Seat Harness Routing (Swivel) wires pulling away from clipping points
- Volvo trucks: on certain trucks, an improvement change was made, for protection of stackable battery box,...
- Engine Control Module (ECM) Software Update
- Charging System Voltage
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of...
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload
- Oil Level Sensor Harness Wire Splice
- Engine Data Label
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of...
- Volvo truck: on some trucks, due to loss of calibration and ability to enable single pto functionality,...
- Volvo truck: on some trucks, due to a possible replacement of EGR temperature sensor, a new configuration...
- Battery Cable Lug, Failure
- Transmission ECU Programming
- Software Update, revise document
- Volvo: software update
- Jumper Harness, Repair
- Battery Cable Mounting Clamps
- Volvo truck: information provided regarding the battery cable mounting clamps, that might break or crack,...
- Volvo: information regarding reprogramming of engine ECM with the new software
- Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
- Floor Cracks Repair (Front Panel)
- Volvo: severe fretting damage of engine variable geometry turbocharger (VGT) actuator harness cause signal...
- Volvo truck: some trucks have potential issues with exterior sun visors cracking
- Volvo truck: procedure for the flexible braided plastic line, which replaced the existing steel engine...
- Volvo trucks: missing signal from engine variable geometry turbocharger actuator (engine vgt actuator)...
- Volvo truck: relocating of engine vgt actuator connector and mounting arrangement was developed to...
- Volvo: to prevent erosion of engine fuel injector tips, fuel tank ventilation filter was added to vent...
- Volvo trucks: connector pin, replacement
- Volvo trucks: oil seepage at flywheel housing
- Volvo: light control module (LCM), reprogramming
- Volvo truck: on certain model year trucks, the mounting bracket connection, from the urea tank, may rub or...
- Volvo truck: overtightening tank strap top bolts may cause round fuel and d shape tanks to fall or collapse
- Volvo truck: replace all coolant hose for aftertreatment diesel exhaust fluid (DEF)
- Volvo truck: on certain vehicles, the engine control module (ECM) and the bypass valve is deactivated due...
- Volvo truck: on certain trucks, an interference was discovered between the aftertreatment hydrocarbon...
- Volvo truck: as part of an investigation, certain vehicles may require inspection of the expansion tank,...
- Volvo truck: the latest software upgrades for the engine control module (ECM), aftertreatment control...
- Volvo truck: fuel tank mounting
- Volvo truck: some trucks, once performance mode has been selected, it may not be able to switch to economy...
- Volvo truck: on some trucks, once performance mode been selected, the economy mode may not switch from...
- Volvo truck: the allison transmission would be easier to install after applying high temperature...
- Volvo truck: check if truck has loss of low speed assist; if a pool valve was replaced; check pump flow...
- Volvo: there is an oil leak on the side of the engine turbocharger
- Volvo: an exhaust pipe insulation blanket CAN deteriorate over time
- Volvo trucks: some engines leak oil through the grommet
- Volvo: information on fuel hose replacement
- Volvo: the LED indicator may display an incorrect cruise control set point
- Volvo: there are new clutch bearing lubrication tubes
- Volvo: there is new transmission software because of rough shifting complaints
- Volvo: a new software update is available to address trouble codes
- Volvo: there is a filler screen that is needed on the filler tank to meet standards
- Volvo truck: engine ECM and acm software updates
- Volvo truck: i shift transmission with mixed components
- Volvo truck: door seal, outer, replacement
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 Volvo VHD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history