2003 Volvo VN technical service bulletins
104 technical service bulletins and manufacturer communications cover the 2003 Volvo VN.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- Cbr - z
- Cbr
- Cbr - 11
- CBR: Volvo VHD & VN Models
- Barksdale Leveling Valve, Leak Test
- CBR: Programming Failure
- CBR: Volvo On-Highway Vehicles
- CBR: Volvo Chassis
- Flywheel Housing Thread Repair
- Instrument Cluster Programming
- Engine Control Module (EMS) Software (MSW) Information – August 2022; Improvement List (Change Log)
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Particulate Matter (PM) Sensor Troubleshooting Guide
- Volvo Chassis
- Volvo Chassis Ghost Codes Due To Poor Grounding
- The Diagnostic Process
- Volvo Chassis
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo VN Models
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Flywheel Resurfacing Guidelines, I-Shift
- In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing...
- On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly...
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine...
- This communication is to return unsold inventory because some product may have porosity that CAN cause a...
- Hill Start Assist Solenoid, Replacement
- Oil Filter Housing
- Twin Mass Flywheel Conversion
- Turbocharger Outlet Pipe
- Regeneration in PTO Mode
- High Soot Output
- Timing Plate Flange Screw
- Timing Plate Leak Repair
- DEF Sensor Assembly Routing
- Aftertreatment DEF Tank Vent Filter
- Range Synchronizer, Repair
- EGR Mass Flow Rate Low, diagnostic trouble code
- Twin Mass Flywheel Conversion, Transmission Removed
- Fuel Management Module, Replacement, incorrect calibration
- Battery Cable, Routing
- Transmission ECU Compatibility
- Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
- Coolant Hose, EGR Cooler, Replacement
- Single Fuel Tank Ventilation Filter Kit
- Dual Fuel Tanks Ventilation Filter Kit
- Service Door Rust Prevention
- AMT High Range Cone Replacement
- Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
- Seat Harness Routing (Swivel) wires pulling away from clipping points
- Engine Control Module (ECM) Software Update
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes...
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of...
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload
- Oil Level Sensor Harness Wire Splice
- Transmission ECU Programming
- Software Update, revise document
- Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
- Engine Coolant Thermostat Software Update
- Floor Cracks Repair (Front Panel)
- Floor Cracks Repair (Rear Panel)
- Volvo trucks: during operation of driver side swivel seat and i shift transmission, the harness rubbing or...
- Volvo trucks: on the steering axle of the volvo trucks, the zerk fitting on the meritor slack adjuster...
- Volvo trucks: connector pin, replacement
- Volvo trucks: oil seepage at flywheel housing
- Volvo: light control module (LCM), reprogramming
- Volvo: trucks built prior to 18/8/2011 were shipped without four (4) spring nuts pre-installed from the...
- Volvo trucks: some engines leak oil through the grommet
- Mack trucks: there is revised mounting hardware for the exhaust manifold and turbocharger
- Volvo trucks: vehicles with partial chassis fairings may experience damage to the fairing¿s lower support...
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering
- Volvo trucks: engine update campaign for certain D13F engines (VN-2, VHD-2) consists of inspecting the...
- Volvo truck; clutch switch clip; it has been found that vn, vhd and vt vehicles use a spring clip to...
- Volvo truck: on some vehicles, coolant overflow out of the overflow tube occurs during the diesel...
- Volvo: leakage detection diagnostics improvements to remedy dtc's
- Volvo truck: reports prompted the release of a replacement connector for the cab HVAC motor resistor
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 Volvo VN?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history