2015 Volvo VN technical service bulletins
253 technical service bulletins and manufacturer communications cover the 2015 Volvo VN.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- Cbr - z
- Cbr
- Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low...
- TSB
- Cbr
- Cbr - 11L, 13L
- TSB
- Cbr
- Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned...
- Cbr
- Cbr
- CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been...
- Cbr: 11L, 13L
- CBR: Cummins CU12 CNG only, P2560 Low Engine Coolant.
- CBR: Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- Cbr
- Cbr - 11
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr: tgw
- Cbr: 11L
- Engine and engine cooling
- Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
- CBR: Volvo VHD & VN Models
- Barksdale Leveling Valve, Leak Test
- CBR: Programming Failure
- CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00
- Cbr
- Cbr
- Cbr
- Cbr
- Service Literature Published and Released in May, 2023
- CBR: Automated Manual Transmission ( AMT )
- CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
- CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
- CBR: Volvo
- CBR: Volvo NOx Sensor Troubleshooting Guide
- Cbr: 11L
- CBR: Volvo On-Highway Vehicles
- CBR: Volvo Chassis
- Flywheel Housing Thread Repair
- Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be...
- Volvo DEF Pump Troubleshooting Guide
- Volvo Chassis
- Diagnostic Trouble Codes (DTC) P24F600 Or P24F700
- TSB-Charge Air Cooler t-clamp install.
- Expendable Items Parts List.
- Part information for AMT input shaft repair kits and the shim kit that is required for repair.
- Engine Control Module (EMS) Software (MSW) Information – August 2022; Improvement List (Change Log)
- Had to update the images and wording on how to access the programming file in Truck Dealer Portal.
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide
- Particulate Matter (PM) Sensor Troubleshooting Guide
- Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information;...
- Back Office
- (Back Office Only) Volvo Chassis
- (Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
- Volvo Chassis Ghost Codes Due To Poor Grounding
- Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide
- The Diagnostic Process
- Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- (Back Office Only) Volvo Chassis
- Volvo Chassis
- Volvo Monthly Bulletin Release Letter
- Volvo SNV 15-010 US14 versus US15 Emissions Injector Compatibility
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
- Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure
- Volvo Chassis
- Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL );...
- Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
- Volvo Chassis US13 And Up Pre-trip Assistant Enable
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Cylinder Head Reuse And Replacement Guidelines
- Volvo Chassis
- Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be...
- Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number...
- Volvo US13, US14, US15, Chassis LED Headlights Conversion Programming Procedure
- Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not...
- Volvo Chassis
- Diesel Fuel Information
- Revised How And When To Diagnose A US14 / US15 Emissions P2463 Diagnostic Trouble Code ( DTC )
- Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24...
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
- Volvo VN Models
- Volvo Chassis
- Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL )
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet,...
- Vehicles Equipped With An Automated Manual Transmission (AMT)
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be...
- Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer...
- Volvo Chassis
- Expired
- Volvo Chassis
- ECM and ACM, Reprogramming, OBD2014
- Selective Catalytic Reduction ( SCR ) Efficiency And NOx Sensor Codes P225C, P225E, P221A, P2201, P103C,...
- Volvo Chassis
- Flywheel Resurfacing Guidelines, I-Shift
- Volvo Trucks has received reports from the aftermarket regarding oil leaks at the CCV housing inlet tube...
- This procedure is to repair I-Shift transmissions in the field that exhibit a grinding noise when the...
- VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines...
- Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017...
- On some VOLVO VN, VHD, and VAH trucks built from January 2014 to July 2017 and equipped with the name...
- VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines...
- Keyless Drive receiver issues
- SCR Harness Connector, Replacement: The front chassis harness on some Volvo VNL trucks equipped with a...
- Engine
- On certain Volvo models built between November 10, 2014 and July 7, 2017, with Bluetooth radio and LDWS...
- Some VOLVO VN, VHD and VNX trucks built from 09/03/2012 to 07/17/2017, and equipped with the NEWAY ADZ...
- VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines...
- In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing...
- On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly...
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine...
- On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable...
- Certain VOLVO VN trucks (with VIN numbers loaded to UCHP), have a compatibility issue with the XE Package...
- Volvo trucks has determined that some vn truck models may experience cracked or broken back of cab fairing...
- Equipment adaptive/mobility
- Some volvo vn model trucks built from 11/01/2011 to 10/03/2016, and equipped with the meritor/wabco...
- Some VOLVO VN model trucks built from 11/01/2011 to 10/03/2016, and equipped with the Meritor/WABCO...
- On some volvo trucks built between august 19, 2014 and august 19, 2016 possible audible feedback may occur...
- On some Volvo Trucks built between August 19, 2014 and August 19, 2016 possible audible feedback may occur...
- Volvo trucks has received reports from the aftermarket regarding oil leaks at the ccv housing inlet tube...
- VOLVO Trucks has received reports from the aftermarket regarding oil leaks at the CCV housing inlet tube...
- Brake S-Cam, Replacement,Some VOLVO VN trucks built after 05/13/2013, equipped with Bendix Brake S-Cams on...
- Front Radar, Reprogramming, Certain VOLVO Trucks built from 11/11/2013 through 07/01/2016, and equipped...
- CCV Housing Inlet Tube, Replacement
- Tire Pressure Monitoring System (TPMS) Connector, Remove
- Diagnostic trouble codes (DTCS), low oil pressure, vah, vhd, vn
- Front Radar, Failure
- Volvo Chassis
- Front Radar, Failure Certain VOLVO VN trucks built between 11/11/2013 and 01/14/2015, equipped with front...
- Engine fuel filters (part number 21380475) with week number date codes ?15_33? (August 15,2015) through...
- Certain VOLVO VN trucks built between 11/11/2013 and 01/14/2015, equipped with front radar may experience...
- Front Radar Failure
- Hill Start Assist Solenoid, Replacement
- Oil Filter Housing
- Certain VAH, VHD, and VN trucks built from 08/17/2015 to 11/18/2015 may have front chassis harnesses with...
- Field service bulletin trucks
- On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid...
- Connector Cavity plugs
- Twin Mass Flywheel Conversion
- Vehicle Speed Sensor, fault codes
- Volvo: some vehicles experience unsure lengthy time in gear changing, at any time a jerky or rough...
- Summary to be provided on a future date.
- Turbocharger Outlet Pipe
- Engine Control Module (ECM) Calibration Transfer
- Volvo truck: a cracked turbocharger outlet pipe has developed at flange to pipe weld area and a new...
- Volvo truck: under certain driving conditions, the sensor for engine low coolant light, CAN be trigger to...
- Volvo truck: some trucks will experience premium tech tool (PTT) 38 error code and should check engine ECU...
- Volvo trucks: cruise control experience erratic operation or loss of front detection object due to...
- Instrument Cluster Reprogramming (MID 140)
- Volvo truck: an inactive fault code, with multiple counts, causes check engine light and pop up display to...
- Regeneration in PTO Mode
- Volvo truck: the installations remain the same, after replacing previous style housing with new style oil...
- High Soot Output
- Timing Plate Flange Screw
- Timing Plate Leak Repair
- Engine Harness Changes
- Range Synchronizer, Repair
- OBD2013
- DEF Sensor Assembly Routing
- Transmission Control Module, Programming
- Aftertreatment DEF Tank Vent Filter
- Software Updates
- Engine Brake Loss
- EGR Mass Flow Rate Low, diagnostic trouble code
- Twin Mass Flywheel Conversion, Transmission Removed
- Rocker Arms, Replacement and Injector Re-torque
- Anti-Lock Brake System (ABS) Sensor Connector, Replacement
- Fuel Management Module, Replacement, incorrect calibration
- Control Module Software Updates
- Battery Cable, Routing
- Dual Pin Lift Gate Receptacle
- Electronically Controlled Suspension
- Transmission ECU Compatibility
- Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
- Coolant Hose, EGR Cooler, Replacement
- Single Fuel Tank Ventilation Filter Kit
- Dual Fuel Tanks Ventilation Filter Kit
- Service Door Rust Prevention
- AMT High Range Cone Replacement
- Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
- Seat Harness Routing (Swivel) wires pulling away from clipping points
- Flex Pipe Diesel Particulate Filter
- Engine Control Module (ECM) Software Update
- Oil Level Sensor Harness Wire Splice
- Transmission ECU Programming
- Software Update, revise document
- Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
- Engine Coolant Thermostat Software Update
- Floor Cracks Repair (Front Panel)
- Floor Cracks Repair (Rear Panel)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Volvo VN?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history